form designed and furnished by the Department <strong>of</strong>Transportation. Failure to comply with any requirementmay be grounds for denying, suspending, or revokingManufacturer's License, Dealer's License, or both issued bythe Division <strong>of</strong> Motor Vehicles as specified in Chapter 20 <strong>of</strong>the Motor Vehicle Law, Title 19A <strong>NC</strong>AC 03D .0219, orNorth Carolina Oversize/Overweight permit privileges.(d) <strong>Office</strong>rs <strong>of</strong> the Division <strong>of</strong> Motor Vehicles may performon-site inspections <strong>of</strong> mobile/modular homes ready forshipment at the point <strong>of</strong> manufacture or at the dealer lot forcompliance with Chapter 20 <strong>of</strong> the General Statutes, dealerand manufacturer regulations, permit regulations, andpolicy. Notification <strong>of</strong> violations shall be submitted byenforcement personnel to the Central Permit <strong>Office</strong>.(e) The penalties provided in this Rule are in addition to thepenalties provided for in Chapter 20 <strong>of</strong> the North CarolinaGeneral Statutes.(f) Permits may be declared void by the StateHighway Administrator or his designee upon determination thatsuch overdimension/overweight permit was being used inviolation <strong>of</strong> the General Statutes <strong>of</strong> North Carolina, Permit Rulesor restrictions stated on the permit.(g) Permits may also be denied, revoked or declared invalid asstated in Rule .0633 <strong>of</strong> this Section.History Note: Authority G.S. 20-119; 136-18(5);Eff. July 1, 1978;Amended Eff. November 1, 1993; October 1, 1991;Temporary Amendment Eff. October 1, 2000;Temporary Amendment Eff. January 10, 2002.Note: Previous temporary amendments which wereapproved April 19, 2001 and May 17, 2001, by RRC appearin bold print.19A <strong>NC</strong>AC 02D .0607 PERMITS-WEIGHT,DIMENSIONS AND LIMITATIONS(a) Vehicle/vehicle combinations with non-divisible overwidthloads are limited to a maximum width <strong>of</strong> <strong>15</strong> feet. After review<strong>of</strong> documentation <strong>of</strong> variances, the Central Permit <strong>Office</strong> orthe State Maintenance and Equipment Engineer mayauthorize the issuance <strong>of</strong> a permit for movement <strong>of</strong> loads inexcess <strong>of</strong> <strong>15</strong> feet wide in accordance with 19A <strong>NC</strong>AC 02D.0600 et seq. Exception: A mobile/modular unit withmaximum measurements <strong>of</strong> <strong>16</strong>' wide unit and a 3" gutteredge may be issued a single trip permit in agreement withpermit policy. If blades <strong>of</strong> construction equipment or front endloader buckets cannot be angled to extend no more than 14'across the roadway, they shall be removed. A blade, bucket orother attachment that is an original part <strong>of</strong> the equipment asmanufactured which has been removed to reduce the width orheight may be hauled with the equipment without beingconsidered a divisible load except as provided in this Rule. A14' wide mobile/modular home unit with a ro<strong>of</strong> overhang notto exceed a total <strong>of</strong> 12" may be transported with a baywindow, room extension, or porch providing the protrusiondoes not extend beyond the maximum 12" <strong>of</strong> ro<strong>of</strong> overhangor the total width <strong>of</strong> overhang on the appropriate side <strong>of</strong> thehome. An extender shall be placed on the front and rear <strong>of</strong>the mobile home with a length to extend horizontally equalto but not beyond the extreme outermost edge <strong>of</strong> the home'sextension. The extenders shall have retro-reflective sheeting,TEMPORARY RULES<strong>16</strong>:<strong>15</strong> NORTH CAROLINA REGISTER February 1, 20021739a minimum <strong>of</strong> 4", which is required to be Type III highintensity (encapsulated lens) or Type IV high performance(prismatic) with alternating fluorescent yellow and blackdiagonal stripes sloping towards the outside <strong>of</strong> the home witha minimum area <strong>of</strong> 288 square inches. The bottom <strong>of</strong> theextenders shall be 6' to 8' above the road surface with a 5"amber flashing beacon mounted on the top <strong>of</strong> each extender.Authorization to move commodities wider than <strong>15</strong> feet inwidth may be denied if considered by the issuing agent to beunsafe to the traveling public or if the highway cannotaccommodate the move due to width.(b) A single trip permit shall not be issued vehicle specific toexceed a width in excess <strong>of</strong> <strong>15</strong> feet for all movements unlessauthorized by the Central Permit <strong>Office</strong> or the StateMaintenance and Equipment Engineer after analysis <strong>of</strong> theproposed load and evaluation <strong>of</strong> the proposed route <strong>of</strong> travel.Exception: A mobile/modular unit with maximummeasurements <strong>of</strong> <strong>16</strong>' wide unit and a 3" gutter edge may beissued a single trip permit in agreement with permit policy.Permits for house moves may be issued as specified in G.S. 20-356 through G.S. 20-372.(c) An annual oversize/overweight permit may be issuedvalid for unlimited movement without an escort on all NorthCarolina highways, where permitted by the posted road andbridge limits, for vehicle/vehicle combinations transportinggeneral commodities which has a minimum extremewheelbase <strong>of</strong> 51 feet and which does not exceed: width <strong>of</strong> 12feet; height <strong>of</strong> 13 feet, 6 inches; length <strong>of</strong> 75 feet; grossweight <strong>of</strong> 90,000 pounds; and axle weights <strong>of</strong> 12,000 poundssteer axle, 25,000 pounds single axle, 50,000 pounds tandemaxle, and 60,000 pounds for a three or more axle grouping.An annual oversize/overweight permit may be issued validfor unlimited movement without the requirement <strong>of</strong> anescort on all North Carolina highways, where permitted bythe posted road and bridge limits, for four or five axle selfpropelledequipment or special mobile equipment capable <strong>of</strong>traveling at a highway speed <strong>of</strong> 45 miles per hour which hasa minimum wheel base <strong>of</strong> 30 feet and which does not exceed:width <strong>of</strong> 10 feet; height <strong>of</strong> 13 feet, 6 inches; length <strong>of</strong> 45 feetwith front and rear overhang not to exceed a total <strong>of</strong> 10 feet;gross weight <strong>of</strong> 90,000 pounds; axle weights <strong>of</strong> 20,000 poundssingle axle; 50,000 pounds tandem axle; and 60,000 poundsfor a three or more axle grouping. An annualoversize/overweight permit may be issued valid for unlimitedmovement with the requirement <strong>of</strong> an escort vehicle on allNorth Carolina highways, where permitted by the postedbridge and load limits, for vehicles/vehicle combinationstransporting farm equipment and which does not exceed: awidth <strong>of</strong> 14 feet; a height <strong>of</strong> 13 feet 6 inches; and a weight asset forth in G.S. 20-118(b)(3). Mobile/modular homes with amaximum height <strong>of</strong> 13' 6" being transported from themanufacturer to an authorized North Carolina mobile/modularhome dealership are an exception and shall be permitted for awidth not to exceed a 14' unit with an allowable ro<strong>of</strong> overhangnot to exceed a total <strong>of</strong> 12". These mobile/modular homesshall be authorized to travel on designated routes approved bythe Department <strong>of</strong> Transportation considering construction workzones, highway lane widths, origin and destination or otherfactors to ensure safe movement. An annual permit may beco-issued to the North Carolina licensed mobile/modularhome retail dealer and the transporter for delivery <strong>of</strong>
mobile/modular homes not to exceed a maximum width <strong>of</strong> a14' unit with a total ro<strong>of</strong> overhang not to exceed 12" and aheight <strong>of</strong> 13' 6". The annual permit shall be valid fordelivery <strong>of</strong> mobile/modular homes within a maximum 25-mile radius <strong>of</strong> the dealer location. Confirmation <strong>of</strong>destination for delivery is to be carried in the permittedtowing unit readily available for law enforcement inspection.(d) The maximum weight permitted on a designated route isdetermined by the bridge capacity <strong>of</strong> bridges to be crossedduring movement. Moves exceeding weight limits for highwaysor bridge structures may be denied if considered by the issuingagent to be unsafe and if they may cause damage to suchhighway or structure. A surety bond may be required asdetermined by the issuing agent to cover the cost <strong>of</strong> potentialdamage to pavement, bridges or other damages incurred duringthe permitted move.(1) The maximum single trip and annual permitweight allowed for a specific vehicle orvehicle combination not including <strong>of</strong>f highwayconstruction equipment without an engineeringstudy is:Steer Axle12,000 lbs.Single axle25,000 lbs.2 axle tandem 50,000 lbs.3 or more axle group 60,000 lbs.3 axle single vehicle may have a maximumgross weight up to 70,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration4 axle single vehicle may have a maximumgross weight up to 90,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration5 axle single vehicle may have a maximumgross weight up to 94,5000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration5 axle vehicle combination may have amaximum gross weight up to 112,000 lbs.based on the extreme axle measurement6 axle single vehicle may have a maximumgross weight up to 108,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration6 axle vehicle combination may have amaximum gross weight up to 120,000 lbs.based on the extreme axle measurement7 axle single vehicle may have a maximumgross weight up to 122,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration7 axle vehicle combination may have amaximum gross weight up to 132,000 lbs.based on the extreme axle measurement7 axle vehicle combination with a gross wt.exceeding 132,000 lbs. requires aDepartment <strong>of</strong> Transportation EngineeringStudy.(2) The maximum permit weight allowed for selfpropelled <strong>of</strong>f highway construction equipmentwith low pressure/flotation tires is:TEMPORARY RULESSingle axle37,000 poundsTandem axle50,000 pounds2 axle single vehicle may have a maximumgross weight up to 70,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration3 axle single vehicle may have a maximumgross weight up to 80,000 lbs. based on ananalysis <strong>of</strong> weight distribution and axleconfiguration4 axle single vehicle may havea maximum gross weight up to 90,000 lbs.based on an analysis <strong>of</strong> weight distributionand axle configuration.(3) A vehicle combination consisting <strong>of</strong> a powerunit and trailer hauling a sealed shipcontainer may qualify for a specific routeoverweight permit not to exceed 94,500 lbs.provided the vehicle:(A) Is going to or from a designatedseaport (to include in state and out <strong>of</strong>state) and has been or shall betransported by marine shipment;<strong>16</strong>:<strong>15</strong> NORTH CAROLINA REGISTER February 1, 20021740(B) Is licensed for the maximumallowable weight for a 51' extremewheelbase measurement specifiedin G.S. 20-118;(C) Does not exceed maximumdimensions <strong>of</strong> width, height andlength specified in Chapter 20 <strong>of</strong>the Motor Vehicle Law;(D)(E)Is a vehicle combination with atleast five axles;Has proper documentation (shippersbill <strong>of</strong> lading or trucking bill <strong>of</strong>lading) <strong>of</strong> sealed commodity beingtransported available for lawenforcement <strong>of</strong>ficer inspection.(e) Overlength permits shall be limited as follows:(1) Single trip permits are limited to 105 feetinclusive <strong>of</strong> the towing vehicle. Approvalmay be given by the Central Permit <strong>Office</strong> forpermitted loads in excess <strong>of</strong> 105 feet afterreview <strong>of</strong> geographic route <strong>of</strong> travel,consideration <strong>of</strong> local construction projectsand other dimensions <strong>of</strong> the load.Mobile/modular home units shall not exceeda length <strong>of</strong> 80 feet inclusive <strong>of</strong> a 4 foottrailer tongue. Total length inclusive <strong>of</strong> thetowing vehicle is 105 feet.(2) Annual (blanket) permits shall not be issuedfor lengths to exceed 75 feet. Mobile/modularhome permits may be issued for a length not toexceed 105 feet.(3) Front overhang may not exceed the length<strong>of</strong> 3' specified in Chapter 20 unless iftransported otherwise would create a safetyhazard. If the front overhang exceeds 3', anoverlength permit may be issued.(f) An Overheight Permit Application for heights in excess<strong>of</strong> 14' must be submitted in writing to the Central Permit<strong>Office</strong> at least two working days prior to the anticipated date