from SN 21001, S-60 / S-65 (PN 147769) - Genie

August 2013Part Description IndexThe Part Description Index is an alphabetical index of all part descriptions included in this manual. The index shows what page(s) the part isused on.##1 BOOM TUBE ASSM, W/SYM DECAL..145–146#1 BOOM TUBE ASSY,W/WORDDECAL.....145–146112VDC PROPORTIONAL VALVE.....2432207 HYD MOTOR ASSY, GEN.....24355/16-18 X .75 LG.FLG.LCK.SCREW.....133AACC, BEACON, TRVL ALARM.....203ACC, OIL COOLER,S60, SERV.....213ACC,AIR PRE-CLEANER,DEUTZ.....227ACC,AIR PRE-CLEANER,PERKINS T2.....227ACC,AIRLINE TO PLAT,S60 ,SERV.....207ACC,FULL GAUGE,DEUTZ,SERV.....211ACC,FULL GAUGE,FORD DSG423,SV.....211ACC,FULL GAUGE,PERKINS,SERV.....211ACC,PLAT CONTROL COVER, SERV.....205ACCUMULATOR,10CC,1000PSI,#6SAE.....95–96ADAPTER, 1/8 X 1/4 F3H6-S.....211ADAPTER, MIXER/THRO, MSG425.....133ADAPTER, WATER CONN, MSG425.....133ADAPTER,140130-4-4.....211ADAPTER,140139-8-6.....211ADAPTER,MIXER/THROTTLE BODY.....121ADAPTER,NPT 6-4.....211ADAPTER,WATER CONNECTOR.....121ADJ ROD, LH/RH, 3/8-24.....93ADJUSTABLE STRAP ASSY.....239AIR CLEANER,FORD,T3.....125, 137AIR CLEANER,NELSON.....129AIR CLEANER,NELSON***......113–114, 117–118AIR INTAKE TUBE ASSY.....113–114ALARM,DESCENT.....71ALARM,WARBLE TONE 5-30 VDC***.....172ALARM.INTERMITTENT TONE.24V.....203ALTERNATOR.....233ALTERNATOR, DEUTZ F3L10/F4L10*.....113–114ALTERNATOR, DEUTZ,BF4L2011***.....129ALTERNATOR,65 AMP,PERKINS 404......117–118ALTERNATOR,DSG-423.....125, 135ANGLE,RELAY MNT,W/NUTSERTS,PNT.....87ASSEMBLY, TRAX UNIT, LEFT.....65ASSEMBLY, TRAX UNIT, RIGHT.....65ASSEMBLY,BOOM TUBE #1 S60/65........141–142ASSEMBLY,BOOM TUBE #3 S60/65........145–146ASSEMBLY,FOOT.....167–169ASSEMBLY,FOOT SWITCH.....168–169ASSEMBLY,GFCI/CIRCUIT BREAKER.....229ASSY HEATER, MODEL 18, 120V.....217–218ASSY HEATER, MODEL 18, 240V.....217–218ASSY, ANGLE SENSOR AND COVER.....142ASSY, BATTERY HEATER, 120V.....217–218ASSY, BATTERY HEATER, 240V.....217–218ASSY, CIRCUIT BREAKER 15A.....83–84ASSY, FUEL PICKUP TUBE.....73–74ASSY, LONG LINK LT W/BEARINGS.......141–142ASSY, LONG LINK RT W/BEARINGS......141–142ASSY, TERMINAL RAIL.....87ASSY,120V HEATER, HYD TANK.....217–218ASSY,240V HEATER, HYD TANK.....217–218ASSY,BLEED LINE (139367).....233ASSY,ENGINE TRAY,W/BEARINGS.....79–80ASSY,FOUR LINK CABLE TRACK***.....165ASSY,LS,LOAD SENSE,38.5 IN.....89, 161ASSY,PCB ALC500 S60 LEG V202.....176ASSY,PCB,ALC500-2 S60 V203.....176AUX TOP RAIL,6'(1.25")SERVICE.....205AUX TOP RAIL,6',SWG GT, SRV.....205AUX TOP RAIL,6FT,PTD.....205AUX TOP RAIL,8'(1.25")SERVICE.....205AUX TOP RAIL,8',SWG GT, SRV.....205AUX TOP RAIL,8FT,PTD.....205AXLE ASSEMBLY,S60 FRONT.....57BBACKING PLATE, HOSE BLOCK, JIB.....155BAFFLE, CNTRWT, S60 MSG425.....139BAFFLE,AIR INTAKE S60.....129BAFFLE,AIR INTAKE,FORD PNTD.....79–80BAFFLE,AIR INTAKE,PAINTED.....79–80BAFFLE,PERKINS ENGINE PAINTED.....118BAFFLE,RADIATOR,FORD.....127BALL JOINT, 3/8-24 FEMALE.....93BALL JOINT, 3/8-24 LEFT HAND.....93BALL STUD**.....77BASE, W/1 N.O. CONTACTS***.....172BASE,W/3 NC CONTACTS.....171–172BATTERY CABLE,NEGATIVE,BLACK.....89BATTERY CABLE,POSITIVE,RED.....89BATTERY HOLD DOWN,GROUP 31.....71BATTERY,12V,1000 CCA GRP 31.....71BEARING KIT,OMNI***.....56–57, 59–60BEARING KIT,PLAT ROTATOR,SUPER.....155BEARING, SPL BOGEY (128918).....69BEARING,1.00IDX1.25ODX1.00L.....55–57BEARING,1.25IDX1.50X1.25L.....145–146BEARING,1.25IDX1.5ODX1.00L......142, 145–146, 153, 157, 159BEARING,1.5IDX1.75ODX1.5L.....57, 65BEARING,2.00IDX2.25ODX2.00L.....57, 60, 67BEARING,2.0IDX2.25ODX1.50L......141–142,145–146BEARING,2.25IDX2.50ODX1.50L*.....141–142BEARING,BALL DRIVE SHAFT.....55–57, 60BEARING,FL, 1.25X1.5X2.13.....155BEARING,FL,1.25IDX1.41ODX1.50L.....155BEARING,FL,1.25IDX1.5ODX1.25L.....79–80,113–114, 127, 155BEARING,FL,2.00IDX2.25ODX1.50L.......141–142BEARING,FL,2.25IDX2.50ODX1.63L.......142,145–146BEARING,GARLOCK,12FDU12.....157, 161BEARING,POLYGON,20DU12.....153, 155BEARING,TURNTABLE ROTATION.....60BELLCRANK W/BEARINGS(S60).....155BELLOWS,CYLINDER LIFT.....225BELLOWS,CYLINDER,PLAT LEVEL.....225BELLOWS,MASTER CYLINDER.....225BELT, FEAD, MSG425.....135BELT,SERPENTINE,DSG-423.....123BELT,V, DEUTZ DIESEL ENGINE.....113–114BIT,TORX SOCKET,SECURITY.....231BLANKET,BATTERY.....215BLOCK HEATER,FORD DSG-423.....215BOLT,CARRIAGE,1/4-20 X .75,G2.....221BOLT,CARRIAGE,1/4-20 X 1.00,G2.....155BOLT,CARRIAGE,1/4-20 X 2.75,G2.....155BOLT,EXHAUST,PERKINS(54555).....117–118BOLT,FLANGE,3/4-10X1.5"GR8 PLT.....69BOLT,FLANGE,3/4-10X1.75GR8 PLT.....69BOLT,FLANGE,3/4-10X4.5"GR8 PLT.....69BOLT,FLANGE,5/16-18X.50 GR5.....69BOLT,FLANGE,5/8-11X1.5"GR8 PLT.....69BOLT,HHC,1-14X2.0"GR8 PLT.....69BOOT(BELLOWS),E-STOP,BLACK.....171–172BOOT, ROCKER JOYSTICK 75565.....179BOOT,CABLE TERM,MED.BLACK,4/0.....231BOOT,CABLE TERM,MED.RED,4/0.....231BOOT,CABLE TERMINAL,BLACK,2/0.....231BOOT,CABLE TERMINAL,LG,RED,2/0.....231BOOT,DTSCH,DTP4-BT.....145–146BOOT,JOYSTICK.....179BOOT,PLUG 4 WAY.....141–142BOOT,TOGGLE SWITCH,SHORT*...171–172,235, 237, 243BOTTLE,COOLANT RECOVERY,3.7***....117–118, 127BOX,INSTRUCTION STORAGE.....169BRACKET BASE ASSEMBLY.....239BRACKET, EXTEND SHEAVE.....149BRACKET, OSCILLATE VALVE.....63BRACKET,1K OHM 10-TURN POT.....87BRACKET,AIR CLEANER MTG.PAINT*....113–114, 117–118BRACKET,CABLE TRACK,FIXED END*.....165BRACKET,CABLE TRACK,MOVINGEND.....165BRACKET,FILTER MOUNT.....79–80BRACKET,GENERATOR12.5KW,PNTD*.....229, 243BRACKET,HOSE CLAMP.....155BRACKET,HOSE ROUTING,LH,PTD.....55–57BRACKET,HOSE ROUTING,RH,PNTD.....57BRACKET,PBOX WIRE SUPPORT.....175–176BRACKET,POWER TO PLAT TBOX,PNT....231BRACKET,POWER TO PLAT, DOM......207BRACKET,POWER TO PLAT, UK.....207BRACKET,REGULATOR SUPPORT.....127BRACKET,RELAY BLOCK MOUNT.....123BRACKET,SOLEN.MOUNTBRACE,PNTD.....113–114BRACKET,SOLENOID MOUNT PAINT.....113–114BRACKET,TENSIONER.....123BRACKET,V275S WELD LEADS.....231BRACKET,WELDER COVER,PNTD.....231BRACKET,WELDER MOUNT SUPPORT....231BRACKET,WELDER SUPPORT,PNT.....231BRACKET,WELDER TOP.....231252 S-60, S-65, S-60X, S60-XC,, S-60TRAX, S65-TRAX, S60HC Part No. 147769