SAFETY DATA SHEET PHILLYMASTIC TG-7B LIQUID RESIN

REVISION DATE: 15/12/2005SAFETY DATA SHEETPHILLYMASTIC TG-7B LIQUID RESIN.1 IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY/UNDERTAKINGPRODUCT NAMEPRODUCT NO.SUPPLIERPHILLYMASTIC TG-7B LIQUID RESIN.Y0011Philadelphia ResinsSHANNON INDUSTRIAL ESTATECO. CLAREIRELAND.T: 353 (0)61 471299F: 353 (0)61 4712852 COMPOSITION/INFORMATION ON INGREDIENTSNameEC No.CAS-No.ContentClassificationDIBUTYL PHTHALATE: DBP201-557-484-74-2 1-10%Repr2;R61 Repr3;R62 N;R50EPOXY RESIN (Number average MW

REVISION DATE: 15/12/2005PHILLYMASTIC TG-7B LIQUID RESIN.6 ACCIDENTAL RELEASE MEASURESPERSONAL PRECAUTIONSAvoid contact with skin and eyes. Wear protective clothing as described in Section 8 of this safety data sheet. Provide adequate ventilation.ENVIRONMENTAL PRECAUTIONSDo not allow to enter drains, sewers or watercourses. Spillages or uncontrolled discharges into watercourses must be IMMEDIATELYalerted to the Environmental Agency or other appropriate regulatory body. Avoid subsoil penetration.SPILL CLEAN UP METHODSAbsorb with sand or other inert absorbent. Transfer to a container for disposal. Containers with collected spillage must be properly labelledwith correct contents and hazard symbol.7 HANDLING AND STORAGEUSAGE PRECAUTIONSUse only in well-ventilated areas. Keep away from heat, sparks and open flame. Open drum carefully as content may be under pressure.Good personal hygiene is necessary. Wash hands and contaminated areas with water and soap before leaving the work site.STORAGE PRECAUTIONSStore in tightly closed original container in a cool, dry well-ventilated place.8 EXPOSURE CONTROLS/PERSONAL PROTECTIONNameDIBUTYL PHTHALATE: DBPStdWELLT - ppm LT - mg/m3 ST - ppm ST - mg/m35 mg/m310 mg/m3SILICA SANDRESPIRATORY EQUIPMENTWEL0.3 mg/m3 RespDust, HKNo specific recommendation made, but respiratory protection must be used if the general level exceeds the Recommended WorkplaceExposure Limit.HAND PROTECTIONUse protective gloves made of: Rubber or plastic.EYE PROTECTIONWear approved chemical safety goggles where eye exposure is reasonably probable.HYGIENE MEASURESKeep away from food, drink and animal feeding stuffs. Good personal hygiene is necessary. Wash hands and contaminated areas withwater and soap before leaving the work site. Do not eat, drink or smoke when using the product. Change work clothing daily before leavingwork place.SKIN PROTECTIONWear apron or protective clothing in case of contact.9 PHYSICAL AND CHEMICAL PROPERTIESAPPEARANCECOLOURODOURViscous liquidWhite / off-whiteAromatic.BOILING POINT (°C) >200 RELATIVE DENSITY 1.44 20 ºCVAPOUR PRESSURE 171 AUTO IGNITIONTEMPERATURE (°C)10 STABILITY AND REACTIVITY>250STABILITYStable under normal temperature conditions and recommended use.CONDITIONS TO AVOIDAvoid excessive heat for prolonged periods of time.MATERIALS TO AVOIDAvoid contact with: Strong oxidising agents. Strong acids. Amines.2 / 4

REVISION DATE: 15/12/2005HAZARDOUS DECOMPOSITION PRODUCTSPHILLYMASTIC TG-7B LIQUID RESIN.Thermal decomposition or combustion may liberate carbon oxides and other toxic gases or vapours. Vapours/gases/fumes of: Acids -organic. Aldehydes.11 TOXICOLOGICAL INFORMATIONTOXIC DOSE 1 - LD 50TOXIC CONC. - LC 5030000 mg/kg (oral rat)0 mg/l/4h (inh-rat)SKIN CONTACTThis substance is a moderate irritant. May cause sensitisation by skin contact.EYE CONTACTIrritating to eyes.HEALTH WARNINGSMay cause harm to the unborn child. Possible risk of impaired fertility.ROUTE OF ENTRYInhalation. Ingestion.12 ECOLOGICAL INFORMATIONECOTOXICITYDo not release into the environment.MOBILITYDo not discharge into drains, water courses or onto the ground.13 DISPOSAL CONSIDERATIONSDISPOSAL METHODSDispose of waste and residues in accordance with local authority requirements.WASTE CLASS08 04 9914 TRANSPORT INFORMATIONUK ROAD CLASS 9PROPER SHIPPING NAMEUN NO. ROADENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (EPOXY RESIN (Number averageMW

REVISION DATE: 15/12/2005PHILLYMASTIC TG-7B LIQUID RESIN.15 REGULATORY INFORMATIONLABELLINGCONTAINSToxicDangerous for theenvironmentDIBUTYL PHTHALATE: DBPEPOXY RESIN (Number average MW