SWX â€Bâ€ Series Operator's Manual - Shuttlewagon mobile railcar ...

More documents

Recommendations

Info

Controls and Indicators 1. Turn signal lever Activates the signal lights located on each corner of the frame exterior. 2. Emergency Flasher Pull the control out to activate the emergency flashers. Move the turn signal lever to deactivate the flashers 3. Throttle Pedal (Forward) Regulates engine RPM. Depressing pedal increases engine RPM. 4. Brake Pedal (Forward) Controls <strong>Shuttlewagon</strong> ® brakes. Depressing pedal increases braking action. 5. Engine Oil Pressure Gauge Displays the oil pressure in the engine lubricating system in PSI. 6. Engine Water (Coolant) Temperature Gauge Displays the temperature of the engine coolant in degrees Fahrenheit. 5 1 Illustration II. Controls and Indicators 1-4 2 4 3
Controls and Indicators 7. Voltmeter Measures the voltage capacity being supplied by the alternator to recharge the battery. 8. Fuel Gauge Indicates the amount of fuel (Diesel Oil) available in the fuel tank. 9. Tachometer Displays engine speed in RPM (Revolutions Per Minute) times 100 (RPM x 100). 10. Hourmeter Records a total of engine running time in hours and tenths of hours. 11. Low Oil Pressure Warning Light A warning light for low engine oil pressure. A red light will illuminate and a buzzer will sound if engine oil pressure drops below a predetermined pressure. 12. High Water Temperature Warning Light A warning light for high coolant temperature. A red light will illuminate and a buzzer will sound if the engine coolant temperature exceeds normal limits. Caution: Do not attempt to operate the <strong>Shuttlewagon</strong> ® if either oil or water temperature indicator lamp is lit. Engine damage will occur! 5 11 12 7 8 6 10 Illustration III. Controls and Indicators 5-12 9 6
Page 1 and 2: MOBILE RAILCAR MOVERS SWX ”B” S
Page 3 and 4: Table of Contents (cont.) Table of
Page 5 and 6: Introduction The Shuttlewagon ® On
Page 7: III. Controls and Indicators This s
Page 11 and 12: Controls and Indicators 18. Low Ser
Page 13 and 14: Controls and Indicators 31. Windshi
Page 15 and 16: 49 54 50 55 Illustration VI. Contro
Page 17 and 18: 56. Brake Pedal (Rear) Controls Shu
Page 19 and 20: 65 68 67 66 64. Seat Forward/Back A
Page 21 and 22: 74 Controls and Indicators 74. Tran
Page 23 and 24: Pre-Start When checking the coolant
Page 25 and 26: Recommended Monthly Inspections The
Page 27 and 28: V. Road Operation Do not begin star
Page 29 and 30: Check other gauges; fuel (item 8),
Page 31 and 32: Rail Operation back half the distan
Page 33 and 34: Connecting Railcar Air Brakes •Ho
Page 35 and 36: Train Air Brake Control Using the T
Page 37 and 38: When pulling, the couplers continue
Page 39 and 40: SWX “B” Series Lubrication and
Page 41 and 42: Table of Contents Table of Contents
Page 43 and 44: Lubrication and Servicing I. Lubric
Page 45 and 46: Lubrication and Servicing 1 3 2 1.
Page 47 and 48: Lubrication and Servicing Cummins F
Page 49 and 50: Air Filter Lubrication and Servicin
Page 51 and 52: 5 4 9 Axle and Hub 8 1. Drain Plug
Page 53 and 54: Hydraulic Return Filter Lubrication
Page 55 and 56: Hydraulic Pressure Filter Lubricati
Page 57 and 58: 1. 3. 6. 7. 4. Pin 8. Lubrication a
Page 59 and 60:
Operational Adjustment This section
Page 61 and 62:
Main Pump Pressure •With the Rail
Page 63 and 64:
Warning: Initial pre-charging at a
Page 65 and 66:
Trouble Shooting If you develop a p
Page 67 and 68:
Hydraulic Pump Noise Hydraulic oil
Page 69 and 70:
Lubricants Lubricants Component Cum
Page 71:
Maintenance Schedule Air/Oil Sep. F
show all

SWX â€Bâ€ Series Operator's Manual - Shuttlewagon mobile railcar ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?

SWX â€Bâ€ Series Operator's Manual - Shuttlewagon mobile railcar ...