27 Operator's Manual.. - Marlow-Hunter, LLC

More documents

Recommendations

Info

Hunter 27 • Documents and Forms Fig. 2.1 DEALER: _____________________________ ENGINE:_________________________________ MAKE:_______________________________ OWNER: ________________________________ PORT ENGINE NO: ____________________ STBD. ENGINE NO: _______________________ BOAT NAME:__________________________REGISTRYR NO:_________________________ ___ OPERATION___________INITIALS________ OPERATION____________ INITIALS_________ BEFORE LAUNCHING BEFORE STARTINGT ENGINES 1. Hull Side Clean and Gelcoat 23. All engine wiring in good order & tight 2. Bright work clean and finish 24. Throttle control and cable travel 3. Decks cleaned and gelcoat 25. Clutch control and cable travel 4. Interior Finish 26. Crankcase oil level at FULL mark 5. Upholstery clean and carpet in place 27. Reverse gear oil level at FULL mark 6. Bilge cleaned. 7. Bottom clean and paint 28. No fuel leaks in fuel lines, at fittings, at 8. Both shafts turn freely fuel filter, fuel pump 9. Engines and Generator intakes installed 29. No engine water or oil leaks 10. All hull fittings sealed 11. All drain plugs tight, (hull, engines, generator, muffler) 30. Oil pressure and exhaust water flow 12. Sacrificial Anodes installed10 31. Idling speed set at 700-800 RPM and is in proper adjustment WITH BOAT IN WA TER 13. Hose test for cabin and window leaks 14. No water leaks at thru hull fitting with seacocks 15. No water leaks at shaft or rudder 16. With all switches off - no spark when battery cable touched to post 17. All electrical equipment operating including: horn( ); running light( ); bilge pump( ) 18. Toilet operates 19. Water (pressure) system operates 20. Galley stove operates 21. With fuel tanks full, no fuel leaks at fill pipes, overflow vent, or at any fuel line connections 22. With coupling disconnected, engine and shaft alignment INSPECTION DATE:____________________ ___ DEALERS SIGNATURE: _______________________________________________________ OWNERS SIGNATURE: Pre-delivery Service Record WA TER TEST BOAT 33. Engine performance 34. Instruments are registering properly 35. Top RPM wide open throttle for one minute after warm-up 36. Boat performance FINAL CHECK: 37. All accessory equipment operating 38. Carpets and drapes installed and clean 39. All loose equipment on boat ready for new owner. ___________________________________________________________ COMMENTS:____________________________ __________________________________________ _______________________________________________________________________________ 2.10
Hunter 27 • Documents and Forms Float Plan Name of Operator____________________________________________________Age____________________ Address____________________________________________________________________________________ Phone______________________________________________________________________________________ Boat Make ________________________________ Model__________________________________ Length _______________________ Hull Color_________________Deck Color___________________________ Registration No._____________________________Home Port________________________________________ Radio frequencies____________________________________________________________________________ Equipment on Board, PFDs, Flares, Anchor ______________________________________________________ ___________________________________________________________________________________________ Fuel Capacity ______________________________ Water Capacity____________________________________ Distinguishing Features________________________________________________________________________ ____________________________________________________________________________________________ Departed from_______________________________________________________________________________ Date____________________________________________ Time________________________________________ Destination__________________________________________________________________________________ Stops_______________________________________________________________________________________ Estimated time of Arrival: Date_______________________Time________________________________________ Name, age, address and phone number of other persons on board: _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ 2.11
Page 1: Operator's Manual H27 V1.062807 •
Page 4 and 5: Hunter 27 • Operator's Manual As
Page 6 and 7: Hunter 27 • Operator's Manual How
Page 8 and 9: Hunter 27 • Operator's Manual 10.
Page 10 and 11: Hunter 27 • Introduction 1.1 The
Page 12 and 13: Hunter 27 • Introduction Hunter r
Page 14 and 15: Hunter 27 • Introduction Notes: 1
Page 16 and 17: Hunter 27 • Documents and Forms Y
Page 18 and 19: Hunter 27 • Documents and Forms P
Page 20 and 21: Hunter 27 • Documents and Forms _
Page 22 and 23: Hunter 27 • Documents and Forms _
Page 26 and 27: Hunter 27 • Documents and Forms M
Page 28 and 29: Hunter 27 • Documents and Forms (
Page 30 and 31: Hunter 27 • Documents and Forms P
Page 32 and 33: Hunter 27 • Documents and Forms L
Page 34 and 35: Hunter 27 • Documents and Forms D
Page 36 and 37: Hunter 27 • Documents and Forms N
Page 38 and 39: Hunter • Limited Warranty This Pa
Page 40 and 41: Hunter • Limited Warranty Hunter
Page 42 and 43: Hunter • Limited Warranty OWNER I
Page 44 and 45: Hunter • Limited Warranty SAMPLE
Page 46 and 47: Hunter • Limited Warranty GRAPHIC
Page 48 and 49: Hunter 27 • Boating Safety As you
Page 50 and 51: Hunter 27 • Boating Safety •
Page 52 and 53: Hunter 27 • Boating Safety • As
Page 54 and 55: Hunter 27 • Boating Safety D Figu
Page 56 and 57: Hunter 27 • Boating Safety • No
Page 58 and 59: Hunter 27 • Boating Safety Water
Page 60 and 61: Hunter 27 • Boating Safety 4.5.4
Page 62 and 63: Hunter 27 • Boating Safety Interi
Page 64 and 65: Hunter 27 • Boating Safety Dimens
Page 66 and 67: Hunter 27 • Fuel Systems FUEL SAF
Page 68 and 69: Hunter 27 • Fuel Systems Fuel lea
Page 70 and 71: Hunter 27 • Fuel Systems ! WARNIN
Page 72 and 73: Hunter 27 • Fuel Systems 5.5 LPG
Page 74 and 75:
Hunter 27 • Fuel Systems Unlikely
Page 76 and 77:
Hunter 27 • Fuel Systems Notes: 5
Page 78 and 79:
Hunter 27 • Underwater Gear Under
Page 80 and 81:
Hunter 27 • Underwater Gear 6.2.2
Page 82 and 83:
Hunter 27 • Underwater Gear Thru
Page 84 and 85:
Notes: Hunter 27 • Underwater Gea
Page 86 and 87:
Hunter 27 • DC Electric 7.2.1 Bat
Page 88 and 89:
Hunter 27 • DC Electric To operat
Page 90 and 91:
Hunter 27 • DC Electric illustrat
Page 92 and 93:
Hunter 27 • DC Electric Notes: 7.
Page 94 and 95:
Hunter 27 • AC Electric Systems A
Page 96 and 97:
Hunter 27 • AC Electric Systems 8
Page 98 and 99:
Hunter 27 • AC Electric Systems N
Page 100 and 101:
Hunter 27 • Water Systems The fre
Page 102 and 103:
Hunter 27 • Water Systems ! CAUTI
Page 104 and 105:
Notes: Hunter 27 • Water Systems
Page 106 and 107:
Hunter 27 • Waste and Sanitation
Page 108 and 109:
Hunter 27 • Waste and Sanitation
Page 110 and 111:
Notes: Hunter 27 • Waste and Sani
Page 112 and 113:
Hunter 27 • Engines and Transmiss
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
High oil pressure Sludge in oil Hun
Page 120 and 121:
Hunter 27 • Sails and Rigging Sai
Page 122 and 123:
Hunter 27 • Sails and Rigging tot
Page 124 and 125:
Hunter 27 • Sails and Rigging Not
Page 126 and 127:
Hunter 27 • Getting Underway Befo
Page 128 and 129:
Hunter 27 • Getting Underway ! WA
Page 130 and 131:
Hunter 27 • Getting Underway harn
Page 132 and 133:
Hunter 27 • Getting Underway Note
Page 134 and 135:
Hunter 27 • Maintenance Maintenan
Page 136 and 137:
Hunter 27 • Maintenance ish out t
Page 138 and 139:
Hunter 27 • Maintenance is much e
Page 140 and 141:
er’s documentation for the compon
Page 142 and 143:
Hunter 27 • Maintenance under the
Page 144 and 145:
Hunter 27 • Maintenance Tighten a
Page 146 and 147:
Hunter 27 • Glossary A Aback: des
Page 148 and 149:
Hunter 27 • Glossary Leech: 1, th
Page 150:
line; two transit give position fix
show all

27 Operator's Manual.. - Marlow-Hunter, LLC

Create successful ePaper yourself

Delete template?

Save as template?