General Generator Permit - Arizona Department of Environmental ...

More documents

Recommendations

Info

II.FUEL REQUIREMENTSA. Gasoline Fuel Sulfur LimitsThe Permittee operating a stationary SI ICE subject to this Attachment that use gasoline shalluse gasoline that meets the per gallon sulfur limit of 80 parts per million (ppm) as stated in 40CFR 80.195. [40 CFR 60.4235]B. Permit ShieldCompliance with the condition of this Part shall be deemed compliance with 40 CFR 60.4235.[A.A.C. R18-2-325]III.EMISSION STANDARDS – NON-EMERGENCY SI ENGINESA. ApplicabilityThis Section is applicable to generators identified as Non-Emergency use and NSPS SubpartJJJJ applicable on the respective ATO.B. The Permittee operating an SI ICE that commenced construction (date engine was ordered), ormodified or reconstructed after June 12, 2006 and that was manufactured in the year specifiedin Table C below shall comply with the emission standards listed in under the ApplicableRegulations for the same engine rating and model year:Table C: Emission Standards for Non-Emergency SI ICE [40 CFR 60.4233]ItemEngine Rating1 ≤ 19 kW (25 HP)2 > 19 kW (25 HP) < 500 HP3 ≥ 500 HP456≥ 500 HP < 1350 HP(Lean Burn)> 19 kW (25 HP) < 75 kW(100 HP)(except gasoline & rich burnLPG)≥ 75 kW (100 HP)(except gasoline & rich burnLPG)ManufactureDateOn or afterJuly 1, 2008On or afterJuly 1, 2008On or afterJuly 1, 2007On or afterJanuary 1, 2008On or afterJanuary 1, 2011Prior toJanuary 1, 2011Prior toJanuary 1, 2011Applicable Regulations40 CFR 60.4231(a) – Standards for NewNonroad SI Engines in 40 CFR Part 90 or Part1048, as applicableGasoline Engines40 CFR 60.4231 (b)Field testing standards in40 CFR Part 1048.101(c)Rich Burn LPGEngines40 CFR 60.4231 (c)If certified to Table 1 of 40 CFR Part 60 SubpartJJJJ Emission Standards for SI ICE > 100 HPand < 500 HP, Permittee may chose to be subjectto the same standardsTable 1 of 40 CFR Part 60 Subpart JJJJIf certified to CO limit for non-severe dutyengines in 40 CFR Part 1048 and above the COstandard in Table 1 of 40 CFR Part 60 SubpartJJJJ, Permittee may meet CO certificationstandardAir Quality Control General Permit Page 32 of 62 Issue Date: July 19, 2011For Generators Expires: July 19, 2016
789n/a – not applicableModified or ReconstructedICE RatingModified or ReconstructedAfter June 12, 2006 &> 130 HP < 500 HPModified or ReconstructedAfter June 12, 2006 &≥ 500 HPModified or ReconstructedAfter June 12, 2006 &> 19kW (25hp) < 100hpManufactureDatePrior toJuly 1, 2008Prior toJuly 1, 2007NOx CO VOC3.0 g/hp-hror250 ppmvd@ 15% O 2n/a4.0 g/hp-hror540 ppmvd@ 15% O 25.0 g/hp-hror675 ppmvd@ 15% O 21.0 g/hp-hror86 ppmvd@ 15% O 2n/aD. Compliance Requirements [40 CFR 60.4243]1. The Permittee operating a stationary SI ICE manufactured after July 1, 2008, and mustcomply with the emission standards specified in the applicable regulation in items 1through 4 of Table C above, shall comply by purchasing an engine certified to theemission standards in §60.4231(a) through (c), as applicable, for the same engine classand maximum engine power. The Permittee shall also meet the requirements asspecified in 40 CFR Part 1068, subparts A through D, as they apply. If the Permitteeadjusts engine settings according to and consistent with the manufacturer's instructions,the stationary SI internal combustion engine will not be considered out of compliance.2. The Permittee shall also meet one of the requirements specified in III.D.2.a and b of thissection:a. If the Permittee operates and maintains the certified stationary SI ICE andcontrol device according to the manufacturer's emission-related writteninstructions, the Permittee shall keep records of conducted maintenance todemonstrate compliance, but no performance testing is required.b. If the Permittee does not operate and maintain the certified stationary SIinternal combustion engine and control device according to the manufacturer'semission-related written instructions, the engine will be considered a noncertifiedengine, and compliance shall be demonstrated according to III.D.2.b.ithrough iii of this section, as appropriate.i. Stationary SI ICE less than 100 HPThe Permittee operating a stationary SI internal combustion engine lessthan 100 HP shall develop a maintenance plan and keep records ofconducted maintenance to demonstrate compliance and shall, to theextent practicable, maintain and operate the engine in a mannerconsistent with good air pollution control practice for minimizingemissions. No performance testing is required.ii.Stationary SI ICE greater than or equal to 100 HP and less than orequal to 500 HPAir Quality Control General Permit Page 33 of 62 Issue Date: July 19, 2011For Generators Expires: July 19, 2016
Page 3: ATTACHMENT “D”: NSPS REQUIREMEN
Page 6 and 7: 4. The Director or the Administrato
Page 8 and 9: C. A progress report on all outstan
Page 10 and 11: 2. An emergency constitutes an affi
Page 12 and 13: for in the applicable requirement,
Page 14: B. If the Permittee has failed to s
Page 17 and 18: D. Test PlanAt least 14 calendar da
Page 19 and 20: AIR QUALITY CONTROLGENERAL PERMIT F
Page 24 and 25: the applicable requirements specifi
Page 26 and 27: d. Keeping records of control devic
Page 28 and 29: Compliance with the conditions of t
Page 30 and 31: Compliance with the conditions of t
Page 34 and 35: The Permittee operating a stationar
Page 36 and 37: 4. If the stationary SI ICE is not
Page 38 and 39: D. Monitoring Requirements1. Emerge
Page 42 and 43: emission-related written instructio
Page 44 and 45: 9. Permit Shielde. A summary of the
Page 46 and 47: . 4SLB RICEThe Permittee operating
Page 48 and 49: change requirement, an oil analysis
Page 50 and 51: f. Non-Emergency CI RICE 300 < HP
Page 52 and 53: a. Identification of the parameters
Page 54 and 55: iv.Conduct a temperature measuremen
Page 56 and 57: [40 CFR 63.6603(a); Table 2d of Sub
Page 58 and 59: v. Take reasonable precautions, suc
Page 60 and 61: 2. Monitoring and Recordkeeping Req
Page 62: C. Demolition/Renovation - Hazardou

General Generator Permit - Arizona Department of Environmental ...

Create successful ePaper yourself

Delete template?

Save as template?