4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

More documents

Recommendations

Info

BUKH STEYR MOTORS SOLASInversion SwitchßThe inversion switch is a mercury switch (A) which is actuatedin case of an inclination of the boat in any directionover 70°.Via the main circuit relay the engine is shut down. For safeguarding reasons the inversion switch is to be checkedevery 50 hrs or 6 months. (See service- and maintenancechart page 64).AATTENTION:qAfter such an event, this temporarilystored operating condition is to becancelled from the engine managementsystem by ignition “OFF” = “Reset”.Without “Reset”, a new start of the engineis not possible.1106012Interrupt crankshaft housing ventilation“During an activation of the mercury switch inversion, the bypassvalve (B) for crankshaft housing ventilation is closedtoo.This avoids a possible oil outlet via suction through the airfilter.B1206010Instrument PanelThe engines are supplied with the standard instrument panel.The respective customer may use a self-adapted STEYR MOTORS instrument panel or one which corresponds tohis own ideas and requirements.ATTENTION:qFor not approved alterations which lead to engine failure, no liability can be undertaken.Dry OperationAfter a dry operation of the engine (without raw water cooling), check the impeller of the raw water pump for damages.Replace if necessary. Grease the impeller, use grease from special impeller kit Z011753/2.40
FUEL AND LUBRICANTSFuel Requirements ................................................................................... 42How to Select Fuel ................................................................................... 42Fuel Selection Chart ................................................................................. 42Engine Lubrication .................................................................................... 43Motor Oil ................................................................................................... 43Oil Identification Symbol ........................................................................... 43Disposal of Automotive Waste Products ................................................... 4441
Page 1: STEYR MOTORS MARINE ENGINES4 CYLIND
Page 4 and 5: How to use this manualTable of Cont
Page 7 and 8: MARINE ENGINE OVERVIEWMAKEengine ty
Page 9 and 10: Installation and pre-delivery inspe
Page 11 and 12: Engine SubmersionRemove engine from
Page 13: SymbolsCertain symbols or combinati
Page 16 and 17: START-UP AND FUNCTIONSDiagnostic sy
Page 18 and 19: Starting the EngineStarting procedu
Page 20 and 21: Run In Procedure After Major Overha
Page 22 and 23: GENERALATTENTION:qIn case of non-ob
Page 24 and 25: Remote Control Operating Instructio
Page 26 and 27: Instrument panelA E DGJFIA1BA1HCIns
Page 28 and 29: BUKH STEYR MOTORS SOLASInstrument p
Page 30 and 31: BUKH STEYR MOTORS SOLASEmergency cu
Page 32 and 33: Electronic Engine Control Unit (ECU
Page 34 and 35: Twin InstallationsAll STEYR MOTORS
Page 36 and 37: Fuel PumpThe STEYR MOTORS Marine En
Page 38 and 39: GENERALElectrical EquipmentThe elec
Page 42 and 43: Fuel RequirementsThe STEYR MOTORS M
Page 44 and 45: Disposal of Automotive Waste Produc
Page 46 and 47: OUTPUTPOWERA100%90%80%70%60%CD50%40
Page 48 and 49: OUTPUTPOWERA100%90%80%70%60%50%40%C
Page 50 and 51: OUTPUTPOWERA100%90%80%70%60%50%40%3
Page 60 and 61: OUTPUTPOWERA100%90%80%70%60%50%40%C
Page 62 and 63: OUTPUTPOWERA100%90%80%70%60%CD50%40
Page 65 and 66: Owner Service LogFOREWORDOn receipt
Page 67 and 68: Service- and Maintenance SchedulePO
Page 69 and 70: MAINTENANCE LOGMade by:1,200 h Serv
Page 71 and 72: Indication status Fault Remarks80°
Page 73 and 74: BUKH STEYR MOTORS SOLASIndication s
Page 75 and 76: Indication and Cancellation of memo
Page 77 and 78: CODE ABBREV. 150 PINWIREChart -Serv
Page 79 and 80: Trouble Check Chart - ContinuedSYMP
Page 81 and 82: LJ12365423XK WVHBUMCA GN D E F TSOP
Page 83 and 84: LJ12365423XK WVHBUMCA GN D E F TSOP
Page 85 and 86: Description - Wiring harness instru
Page 87 and 88: LJWIRING DIAGRAM/INSTRUMENT / INSTR
Page 89: DEALER’S RESPONSIBILITIESCheck mo
Page 92 and 93:
Check coolant (closed cooling circu
Page 94 and 95:
GENERALAir FilterAll STEYR MOTORS M
Page 96 and 97:
FOR 6 CYL. MARINE ENGINES WITH V-BE
Page 98 and 99:
STEYR MOTORS - Dealer - Check-ListN
Page 100 and 101:
COMMISSIONING REPORTEngine-serial n
Page 102 and 103:
Preparations for Off-Season Storage
Page 104 and 105:
ENGINE LOGDateDestinationNumberAbor
Page 106 and 107:
106
Page 108 and 109:
STEYR MOTORS - Marine Engines - LIM
Page 110 and 111:
Extended Major Components WarrantyT
Page 112 and 113:
• You are responsible for keeping
Page 114 and 115:
Venue and Applicable LawThis Limite
Page 116 and 117:
STEYR OWNER IDENTIFICATION CARDOwne
Page 118:
118
show all

4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

Create successful ePaper yourself

Delete template?

Save as template?