PGO PMX Sport (PM) servicemanual - Scootergrisen

More documents

Recommendations

Info

(5)Spark plug 1.Remove spark plug 2.Check the spark plug electrode and check if it is Burnt out or not and carbonized or not 3.Clean the electrode, if it is dirty 4.Spark plug specification NGK:BY7HS or same spec. Gap of spark plug:0.6~0.7mm Electrode Burn out Carbon piled up Washer is Distorted or not Procelain is Cracked or not
Page 3: (12)Fuel tank, oil tank 5.Electric
Page 9 and 10: 3.Other parts: Please refer the fol
Page 11: C. Wheel bearing part
Page 14 and 15: 2.Weak acceleration: Check and Adju
Page 17 and 18: 4.Engine running unsmoothly (high s
Page 20 and 21: 9.Oil indicator malfunction (a)The
Page 22 and 23: (b)Fuel gauge needle is not steady
Page 24 and 25: (b)Starting motor running slowly or
Page 27: 3.Checking and Adjustment: (1)Regul
Page 38: (11)Rear brake adjustment 1.Check t
Page 41 and 42: (1)Lubrication system: 1.Lubricatio
Page 43 and 44: 5.Assemble the oil pump. a. Assembl
Page 45 and 46: 3.Screwing out the screws of the re
Page 47 and 48: 7.Screwing out the screws of right
Page 49 and 50: 11.screwing out the screws of front
Page 51 and 52: (3)Dismantling Engine A.Dismantling
Page 53 and 54: B. installing engine. 1.Install eng
Page 55 and 56: C. Driving pulley. 1.Remove the 10
Page 57 and 58: 7. Loosen 2 hexagon screws, and tak
Page 59 and 60: 13.Assemble the slide driving plate
Page 61 and 62: E. Clutch driven pulley 1.Dismantle
Page 63 and 64: (5)Cylinder head, cylinder, piston:
Page 65 and 66: 4.Remove the cooling cowl and fan c
Page 67 and 68: 9.Remove the C-type clip on the pis
Page 69 and 70: G. Check cylinder and piston: 1.Che
Page 71 and 72: 6.Outer diameter measurement of the
Page 73 and 74: (6)A.C. Generator, Flyweel Magneto
Page 75 and 76: (7)Final Transmission Mechanism A.
Page 77 and 78: C. Check the final transmission mec
Page 79 and 80: B. Troubleshooting. Engine noise: 1
Page 81 and 82: 4.Remove carburetor. 5.Remove intak
Page 83 and 84: E. Check crankshaft: 1.measure the
Page 85:
(9)Carburetor, Reed Valve and Auto
Page 88 and 89:
D. Dismantling carburetor 1.Remove
Page 90 and 91:
G. Check the auto cock 1.When the e
Page 92 and 93:
C. Change speedometer cable: 1.Remo
Page 94 and 95:
8.Remvoe the bolts and nuts fixed t
Page 96 and 97:
5.Checking front axle a. Check the
Page 98 and 99:
4.Disassembling and assembling the
Page 100 and 101:
(11)Rear wheel, rear brake, rear da
Page 102 and 103:
E. Rear brake: 1.Rear brake disasse
Page 104 and 105:
(12)Fuel tank, oil tank: A. Trouble
Page 106 and 107:
4.Remove the side cover. 5.Remvoe t
Page 108 and 109:
5.Electric equipment: (1)Troublesho
Page 110 and 111:
(2)Battery: Always remove the batte
Page 112 and 113:
(3)Recharge system: 1.Recharge syst
Page 114:
(4)Ignition system: 1.the wiring or
show all

PGO PMX Sport (PM) servicemanual - Scootergrisen

Create successful ePaper yourself

Delete template?

Save as template?