Taurus ELECTRO manual 472 ENG.pdf - Pipistrel

More documents

Recommendations

Info

76 TAURUS ELECTRO www.pipistrel.si REV. 0 Handling and maintenance Introduction This chapter determines handling and (preventative) maintenance terms. Also, recommended ground handling is presented. THE FOLLOWING ARE PROVISIONAL VALUES SUBJECT TO CHANGE WITHOUT NOTICE! Inspection periods See “Service manual”. Repairs, spare part replacements and preventative maintenance All major repairs and spare part replacements MUST be done by authorised service personnel. However, you are encouraged to take care of preventative maintenance yourself. This includes: tire and wheel bearings replacements, safety wire replacements, door and safety harness replacement, light bulb replacements, spark plugs replacements and air filter replacements. The table below indicates recommended maintenance periods (see Service manual for detailed information). Table legend: C Check-up - visual only, check for free play and whether everything is in position - DO IT YOURSELF CL Cleaning - DO IT YOURSELF LO Lubricating, oiling - lubricate all designated parts and spots using proper lubricant - DO IT YOURSELF R Replacement - replace designated parts regardless of state and condition. You are encouraged to DO undemanding replacements YOURSELF, otherwise have replacements done by AUTHORISED SERVICE PERSONNEL SC Special check-up - measuring, verifying tolerances and functionality - DONE BY AUTHORISED SERVICE PERSONNEL ONLY O Overhaul EACH daily first 5 hours 50 hours 100 hours 250 hours 500 hours 1.000 hours WING AND TAIL SURFACES SC O surface and structure condition C SC deflections without free play C SC bearings - moving parts bushings C SC lights C self-adhesive sealing tape C C R horizontal tail mount C C SC drain holes CL 10.000 hours
www.pipistrel.si TAURUS ELECTRO 77 Handling and maintenance REV. 0 EACH daily fist 5 hours 50 hours 100 hours 250 hours 500 hours 1.000 hours FUSELAGE SC O surface and structure condition C SC elevator control tube bearing C SC doors, hinges C C SC LO rudder control wires and hinges C C SC drainage holes C CL CABIN SC O control levers, instr. panel, seats C SC control levers’ free play C C SC intstruments and pitot-static C SC test glass surfaces: clean, attached C C SC rivet condition C SC safety harnesses and attach. points C SC parachute rescue sys. activation handle C SC wing connectors: electrical C C SC bolts and spar pins C C SC wing main bushings, control connectors SC 10.000 hours UNDERCARRIAGE tires C C R wheel axis and wheels C wheel bearings C SC R wheel fairings C C C tail wheel mounting bolt check and fasten every 50 landings O CONTROLS general free play C C SC control stick C LO SC rudder pedals (damage, centered, paral.) C C C LO rudder wire rope C SC bolts, visible bearings (tail, fuselage) SC LO difficult-to-reach bearings (wings, under cabin floor) LO aileron, elevator and rudder hinges SC LO equal spoiler extension, undisrupted m. C SC LO spoiler plate springs stiffness C flap handle C SC LO elevator trim C LO springs: flaps, rudder, el. trim, stablizer main fastening bolt LO C R airbrakes internal connector rod (if flown or stored where possibilty for corrosion is increased (oceanside, wet regions...) replace every 2 years spoilers’ (airbrakes’) drive fine adjustment see page 73 for detailed description R
Page 1 and 2:
Flight manual and Maintenance manua
Page 3 and 4:
www.pipistrel.si TAURUS ELECTRO 3 R
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
www.pipistrel.si TAURUS ELECTRO 9 G
Page 11 and 12:
www.pipistrel.si 3-view drawing TAU
Page 13 and 14:
www.pipistrel.si TAURUS ELECTRO 13
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26: www.pipistrel.si Landing gear failu
Page 27 and 28: www.pipistrel.si TAURUS ELECTRO 27
Page 41 and 42: www.pipistrel.si Roundout and touch
Page 49 and 50: www.pipistrel.si Maneuver & gust en
Page 51 and 52: www.pipistrel.si Additional technic
Page 57 and 58: www.pipistrel.si Definitions and ex
Page 59 and 60: www.pipistrel.si Flight mass and c.
Page 67 and 68: www.pipistrel.si Power plant, prope
Page 75: www.pipistrel.si TAURUS ELECTRO 75
Page 83 and 84: www.pipistrel.si Keeping your aircr
show all

Taurus ELECTRO manual 472 ENG.pdf - Pipistrel

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?