7.5 TON - 12.5 TON PACKAGE GAS SERIES CPG SERIES - Goodman

More documents

Recommendations

Info

CPG(090/102/120/150)2104B*/7B* THREE PHASE 460-575/60 HZ BELT DRIVE WIRING DIAGRAM HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING THIS UNIT. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. L1 NOTE 3 L1 4 5 9 R F 2 1 IIC TB1 8 ECON 7 10 G TO THERMOSTAT W2 NOTE 5 INSTALLER/SERVICEMAN THE STATUS LIGHT ON THE FURNACE CONTROL MAY BE USED AS A GUIDE TO TROUBLESHOOTING THIS APPLIANCE. STATUS LIGHT CODES ARE AS FOLLOWS: STATUS LIGHT ON OFF CC1 1 BLINK CC2 2 BLINKS 3 BLINKS 4 BLINKS 5 BLINKS 6 BLINKS BC H C T1 3 6 W1 T1 FS D1 COMP1 RCCF2 T1 EM 12 11 SUPPLY VOLTAGE 460-575/3/60 T2 T3 RCCF1 T2 T3 C F 2 4 WH R 460V OR APPROPRIATE INPUT VOLTAGE 1 3 TR 460V OR APPROPRIATE INPUT VOLTAGE 1 3 PS LS HPS1 T2 24V ALS LPS1 EQUIPMENT STATUS NORMAL OPERATION NO POWER OR INTERNAL CONTROL IGNITION FAILURE OPEN ROLLOUT SWITCH OPEN AUX. LIMIT SWITCH PRESSURE SWITCH OPEN PRESSURE SWITCH CLOSED WITHOUT INDUCER ON C OPEN LIMIT SWITCH TR RS FALSE FLAME SENSED COMPRESSOR OUTPUT DELAY F COMP2 T2 BC BC CC1 CM2 CC2 Y1 Y Y2 CM1 CC1 T3 CC2 IGN FS VMR LPS2 C TB1 GV HPS2 C1 PLF NOTE 2 VM NOTE 3 L2 IIC BC 9 8 7 CHECK C2 ------ CHECK INPUT POWER CHECK FUSE ON CONTROL REPLACE CONTROL GAS FLOW GAS PRESSURE GAS VALVE FLAME SENSOR FLAME ROLLOUT BAD SWITCH AUX. LIMIT OPEN CHECK PRESSURE SWITCH CHECK PRESSURE SWITCH MAIN LIMIT OPEN BAD SWITCH STICKING GAS VALVE 3 MIN. COMP. ANTI-CYCLE TIMER 6 5 4 3 2 1 L2 L3 COMPONENT LEGEND ALS BC COMP CM CC EM F FC FS GND GV HPS IBR IIC IGN LPS LS PLF PS RS TB1 TR VM VMR NOTES AUXILIARY LIMIT SWITCH BLOWER CONTACTOR COMPRESSOR CONDENSER MOTOR COMPRESSOR CONTACTOR EVAPORATOR MOTOR FUSE FAN CAPACITOR FLAME SENSOR EQUIPMENT GROUND GAS VALVE HIGH PRESSURE SWITCH INDOOR BLOWER RELAY INTEGRATED IGNITION CONTROL IGNITOR LOW PRESSURE SWITCH LIMIT SWITCH FEMALE PLUG/CONNECTOR PRESSURE SWITCH ROLLOUT SWITCH TERMINAL BLOCK (24V SIGNAL) TRANSFORMER VENT MOTOR VENT MOTOR RELAY 1. REPLACEMENT WIRE MUST BE THE SAME SIZE AND TYPE OF INSULATION AS ORIGINAL. (USE COPPER CONDUCTOR ONLY). 2. ACCESSORY ECONOMIZER PLUG ADJACENT TO BLOWER HOUSING IN RETURN AIR COMPARTMENT. REMOVE MALE PLUG AND ATTACH FEMALE PLUG TO THE ECONOMIZER ACCESSORY. 3. L1 AND L2 ON IIC CONTROL IS 24V INPUT. 4. USE COPPER CONDUCTORS ONLY. USE NEC CLASS 2 WIRE. 5. FOR TWO STAGE OPERATION REMOVE W1 TO W2 WIRE JUMPER. WIRE CODE BK BLACK BL BLUE BR BROWN GR GREEN OR ORANGE PK PINK PU PURPLE RD RED WH WHITE YL YELLOW YL/PK YELLOW WITH PINK STRIP BL/PK BLUE WITH PINK STRIP THERMOSTAT FIELD WIRING 2 STAGE COOLING W WH W G GR G R RD R Y1 YL Y1 Y/Y2 PK Y2 C BL C O OR O STAT TB1 NO ECONOMIZER W WH W G GR G R RD R Y1 Y/Y2 YL Y2 C BL C O OR O TB1 WITH ECONOMIZER OPTION W G R Y1 Y/Y2 C O TB1 FACTORY WIRING LINE VOLTAGE LOW VOLTAGE OPTIONAL HIGH VOLTAGE FIELD WIRING HIGH VOLTAGE LOW VOLTAGE WH GR RD YL BL OR STAT W G R Y C O STAT 460-575/3/60 0140L00551 REV B Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. 30
CPG(090/102/120/150)2103B* THREE PHASE 208-240/60 HZ BELT DRIVE WIRING DIAGRAM HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING THIS UNIT. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. BK PU BL BL BK RD YL YL BR PU BR BK RD T1 T2 T3 CM2 BK RD YL BK BK RD BK YL RD BK CC2 L1 L2 RD T1 T2 CC1 L3 T3 RD OR OR BK FC2 GND POWER SUPPLY 208-240/3/60 SEE NOTE 4 COMP2 COMP1 L1 L2 L3 YL PU BK BL RD YL LPS2 HPS2 BK RD FC1 BR CM1 BK LS RD 3 240 RD BK 2 1 208 C TR 24V OR WH 3 BL 1 VMR WH BL EM BK RD OR BC T3 T2 T1 GR C L3 L2 L1 BK RD RD OR RD S1 S2 TB1 PK BR BL BL GR SMOKE/FIRE DETECTOR REPLACES JUMPER WIRE ALS PU PU PU PS RS NOTE 2 PLF GV BL PU YL YL YL 9 6 8 5 7 4 BR 3 2 1 WH BL BL WH GR PU YL YL RD BL PU YL RD RD BL BL WH BL RD BL GR BL RD GR IIC YL YL WH RD WH BR GR OR SEE NOTE 3 GR RD VM BL BK WH SEE NOTE 5 FS IGN W2 Y2 Y1 C R W1 G TB1 WH RD OR BK YL BL LPS1 HPS1 WH RD RD BK 0140L00552 REV B Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. 31
Page 1 and 2: INSTALLATION INSTRUCTIONS FOR COMME
Page 3 and 4: WARNING THIS PRODUCT CONTAINS OR PR
Page 5 and 6: GROUND LEVEL INSTALLATIONS ONLY:
Page 7 and 8: Ensure that the top of the duct con
Page 9 and 10: CAUTION CONDUIT AND FITTINGS MUST B
Page 11 and 12: The rating plate is stamped with th
Page 13 and 14: 6. All pipe connections should be s
Page 15 and 16: Three Phase Models 3) PERCENT VOLTA
Page 17 and 18: NATURAL PROPANE INLET GAS PRESSURE
Page 19 and 20: The pressure regulator on LP gas mo
Page 21 and 22: Open Thermal Protection Device If t
Page 23 and 24: CLEAN OUTSIDE COIL (QUALIFIED SERVI
Page 25 and 26: APPENDIX A BLOWER PERFORMANCE DATA
Page 27 and 28: APPENDIX B ELECTRICAL DATA MODELS E
Page 29: 7 1 11 8 9 CPG(090/102/120/150)2104

7.5 TON - 12.5 TON PACKAGE GAS SERIES CPG SERIES - Goodman

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?