IS 18 50 Hz IS 21 60 Hz50 Hz 60 HzDimension (Length x Width x Height.)Weight1225x630x830mm - 48.2x24.8x32.7 (in.) (with soundproof box)625 Kg. - 1388 (lb) (with soundproof box)Noise Level 54 dB A at 7mt (23 ft) 56 dB A at 7mt (23 ft)maseGENERATORS1225133 110 680 110 190630680710830Ø12,7FITTINGSEXHAUST COMPONENTS KITSIPHON BREAKW.G. SEPARATOR KITREMOTE CONTROL PANEL COMPLETED OF INSTRUMENTSThis drawing is only a reference and is not indicatly for the installation. Formore information, you may contact your local dealer or mase generatorsS.p.A..mase generators S.p.A. reserves the right to change the design orspecifications without notice and without any obligations or liability whatsoeverFor more information, you may contact your local mase dealer.Dealer:maseGENERATORSMASE GENERATORS S.p.A. Via Tortona, 34547023 Cesena (FC) ItalyTel.+39-0547-354311 Fax.+39-0547-317555Email: mase@masegenerators.comwww.masegenerators.comRev.0 del 21-07-2006
maseGENERATORSTNV TURBO seriesIS 20.120.1 kW 50 HzTHE INTERCOOLER W/AIS 23.123.1 kW 60 HzAssures the perfect functioning of the generator independentlyof the external ambient temperature, therefore the alternatorand the engine will work at ideal temperature optimizing theperformance and reliability of the gen-set.Control PanelThe gen-set control panel was designed to include, in one singlepanel, the switches, control devices and the protection devicesThe components are the following :• Engine cut-off module for automatic stop of engine in case of highwater temperature, low oil pressure, high alternator temperature.• Hour-meter.• Start-stop button.• Breaker for protection against of overload or short circuit.• Thermal switch.Engine• Easy access in case of maintenance to the feeding system andlubrication, of the sea/water pump and the air filter.• Safety stop in case of low oil pressure.• Safety stop in case high water/exhaust gas temperature.• Double vibration dumping system.• Oil and fuel filters of easy access.• Oil drain pump.Alternator• Synchronous, 4 poles, self-regulated, brush less self-excited withelectronic voltage regulator (AVR).• Rotor and stator epoxy resin coated against external agents.• Rotor dynamically balanced.• Insulation class H.Soundproof cabinA new project engineering design with a structure of a draw piece ofaluminum supporting, painted aluminum panels type 5754 of highresistance to external agents.Of limited weight and easy accessibility to the inner cabin in caseof maintenance services.Engine 50 Hz 60HzModelTypeCylinders (nr.)Cylinder block materialBore (mm. - in.)Stroke (mm.- in.)Displacement (cc. - CID)Yanmar 4TNV84 TURBODiesel 4 stroke4Cast iron84 - 3,390 - 3,51995Power (hp) 29,3 37,1RPM 1500 1800Compression ratioInjection systemEngine head materialSpeed governorLubrication systemOil sump capacity with filter(l -gl)Engine stop systemFuel pumpFuel pump discharge (cm. - ft)7,1 - 1,9Stop solenoidElectric70 - 2,3Fuel consumption (l/h - gl/h) 5,6 - 1,5 7,3 - 1,9Air intake (l/min. - gl/min.) 1950 - 515 2340 - 618Starting battery (Ah-V)Battery charger (Ah-V)Starter (kW-V)Max. inclination80 - 1240 - 121,2 - 1230°Water pump flow (l/min. - gl/min.) 40 - 10,5 48 - 12,7Alternator 50 Hz 60HzTypeRegulationCoolingSynchronous, 4-poles,brush less self-excitedElectronicAir/water ( Intercooler W/A )Voltage (V) 115 - 230 120 - 240Frequency (Hz) 50 60Amps 174,8 - 87,4 192,5 - 96,25Max. power (kW) 20,1 23,1Continuous power (kW) 18,7 22,2Power factor ( cos ø )Insulating classVoltage stabilityFrequency stabilityCooling system18,9:1DirectCast ironCentrifugal mechanicalForced1H±2%±5%The cooling of the engine is based on a closed inner flow ofcoolant.The system is based on a heat exchanger seawater/coolanttype, of cupronickel, where the thermal exchange occursbetween the two liquids.Two separate pumps contribute to the flow of the coolant andthe sea water. The cooling of the air inside the gen-set is obtainedthrough a seawater/air heat exchanger. This provides theefficacious cooling of the alternator and the optimal temperaturefor the best performance and reliability of the gen-set despiteits on board allocation and room temperature.