Mase Marine Generators 164536.pdf

More documents

Recommendations

Info

IS 27 50 Hz IS 31 60 HzmaseGENERATORS50 Hz 60 HzDimension (Length x Width x Height.) 1225x630x830mm - 48.2x24.8x32.6 (in.) (with soundproof box)Weight625 Kg. - 1388 (lb) (with soundproof box)Noise Level 54 dB A at 7mt (23 ft) 56 dB A at 7mt (23 ft)48,2"5,2" 4,3" 26,8" 4,3" 7,5"24,8"26,8"28"32,6"Ø0,5"FITTINGSEXHAUST COMPONENTS KITSIPHON BREAKW.G. SEPARATOR KITREMOTE CONTROL PANEL COMPLETED OF INSTRUMENTSThis drawing is only a reference and is not indicatly for the installation. Formore information, you may contact your local dealer or mase generatorsS.p.A..mase generators S.p.A. reserves the right to change the design orspecifications without notice and without any obligations or liability whatsoeverFor more information, you may contact your local mase dealer.Dealer:maseGENERATORSMASE GENERATORS S.p.A. Via Tortona, 34547023 Cesena (FC) ItalyTel.+39-0547-354311 Fax.+39-0547-317555Email: mase@masegenerators.comwww.masegenerators.comRev.0 del 28-04-2005
maseGENERATORSserie TNVIS 30T50 HzTHE INTERCOOLER W/AAssures the perfect functioning of the generator independentlyof the external ambient temperature, therefore the alternatorand the engine will work at ideal temperature optimizing theperformance and reliability of the gen-set.Control PanelThe gen-set control panel was designed to include, in one singlepanel, the switches, control devices and the protection devicesThe components are the following :• Engine cut-off module for automatic stop of engine in case of highwater temperature, low oil pressure, high alternator temperature.• Hour-meter.• Start-stop button.• Breaker for protection against of overload or short circuit.• Thermal switch.Engine• Easy access in case of maintenance to the feeding system andlubrication, of the sea/water pump and the air filter.• Safety stop in case of low oil pressure.• Safety stop in case high water/exhaust gas temperature.• Double vibration dumping system.• Oil and fuel filters of easy access.• Oil drain pump.Alternator• Synchronous, 4 poles, brush less self-excited, electronic voltageregulator (AVR)• Rotor and stator epoxy resin coated against external agents.• Rotor dynamically balanced.• Insulation class H.Soundproof cabinA new project engineering design with a structure of a draw piece ofaluminum supporting, painted aluminum panels type 5754 of highresistance to external agents.Of limited weight and easy accessibility to the inner cabin in caseof maintenance services.Engine50 HzModelYanmar 4TNV98TypeDiesel 4 strokeCylinders (nr.) 4Cylinder block materialCast ironBore (mm. - in.) 98 - 3.8Stroke (mm.- in.) 110 - 3.9Displacement (cc. - CID) 3319 - 202.5Power (hp) 47RPM 1500Compression ratio 18:1Combustion systemDirect injectionEngine head materialCast ironSpeed governorCentrifugal mechanicalLubrication systemForcedOil sump capacity with filter(l -gl) 10.5 - 2.3Engine stop systemStop solenoidFuel pumpElectricFuel pump discharge (cm. - ft) 70-2.3Fuel consumption (l/h - gl/h) 8,9-1.95Air intake (l/min. - gl/min.) 2500 - 550Starting battery (Ah-V) 80 - 12Battery charger (A-V) 40 - 12Starter (kW-V) 2.3 - 12Max. inclination 30°Water pump flow (l/min. - gl/min.) 40Alternator50 HzTypeSynchronous, 4-poles,brush less self-excitedRegulationElectronicCooling Air/water ( Intercooler W/A )Voltage (V) 400Frequency (Hz) 50Max. power (kW - kVA) 24,8 - 31Continuous power (kW - kWA) 22,4 - 28Power factor (cos ø) 1 - 0,8Insulating classHVoltage stability ±2%Frequency stability ±5%Cooling systemThe cooling of the engine is based on a closed inner flow ofcoolant.The system is based on a heat exchanger seawater/coolanttype, of cupronickel, where the thermal exchange occursbetween the two liquids.Two separate pumps contribute to the flow of the coolant andthe sea water. The cooling of the air inside the gen-set is obtainedthrough a seawater/air heat exchanger. This provides theefficacious cooling of the alternator and the optimal temperaturefor the best performance and reliability of the gen-set despiteits on board allocation and room temperature.
Page 1 and 2: maseGENERATORSIS 2.52 kW 50 Hz2.2 k
Page 3: maseGENERATORSIS 2.6 - IS 2.72 kW 5
Page 6 and 7: IS 3.5 50 Hz lIS 4.0 60 HzmaseGENER
Page 8 and 9: IS 5.0 50 Hz lIS 6.0 60 Hz50 Hz 60H
Page 10 and 11: IS 6.1 50 Hz • IS 7.1 60 HzmaseGE
Page 12 and 13: maseIS 7 50 Hz • IS 8.1 60 Hz maG
Page 14 and 15: IS 9 50 Hz • IS 10.2 60 HzmaseGEN
Page 16 and 17: IS 9.1 50 Hz IS9.6 60 HzmaseGENERA
Page 18 and 19: IS 11.2 50 Hz • IS 13.2 60 HzDime
Page 20 and 21: IS 11.5 T 50 HzDimension (Length x
Page 22 and 23: maseIS 12 50 Hz • IS 14 60 HzmaDi
Page 24 and 25: IS 13.1 50 Hz • IS 15.6 60 Hzmase
Page 26 and 27: IS 14.5T 50 HzDimension (Length x W
Page 28 and 29: maseIS 16 50 Hz • IS 19 60 HzmaDi
Page 30 and 31: IS 18 50 Hz IS 21 60 Hz50 Hz 60 HzD
Page 32 and 33: maseIS 20.1 50 Hz • IS 23.1 60 Hz
Page 34 and 35: IS 20T 50 HzDimension (Length x Wid
Page 36 and 37: IS 24 50 Hz IS 28 60 Hz50 Hz 60 HzD
Page 38 and 39: IS 25T 50 Hz50 HzDimension (Length
Page 42 and 43: IS 30T 50 Hz50 HzDimension (Length
Page 44 and 45: IS 34T50 Hz50 HzDimension (Length x
Page 46 and 47: IS 35 50 Hz IS 42 60 HzmaseGENERATO
Page 48 and 49: IS 44T 50 HzDimension (Length x Wid
Page 50: IS 66T 77T 50 Hz 60 HzDimension (Le

Mase Marine Generators 164536.pdf

Create successful ePaper yourself

Delete template?

Save as template?