Red Giant Grain Stir-Ator - David Manufacturing Co.

More documents

Recommendations

Info

4. Installation Procedures21. Installation of gearbox drive belts - 4 Auger Unit: Using two (2) set of AX-38 V-belts, install onematched set on each end of top drive assembly. Check to be sure belt alignment is proper. Also,be sure clutch idlers are positioned as shown in Figure 4R on Page 23 and Figure 4S.Installation of gearbox drive belts - 6 Auger Unit: First, follow the instructions given for the4 auger unit. Then, proceed to bolt bearing bracket and clutch idler on to the top of the 6 auger trolley.(See Figure 4T and Page 60.) Next, bolt 6 auger extension drive shaft into place, using two (2)carriage bolts, 5/16" x 3/4", with lock washers and nuts. DO NOT TIGHTEN THE 5/16" x 3/4"CARRIAGE BOLTS AT THIS TIME. BE SURE BEARING IS BOLTED IN POSITION AS SHOWNIN Figure 4U.Using extension shaft Delrin coupler, connect extension shaft to top drive shaft assembly as shownin Figure 4V on Page 25. Secure Delrin coupler with drive-in pin or with steel pin and clip. Nowtighten securely the 5/16" x 3/4" carriage bolts. Complete installation by installing matched pair ofAX-38 V-belts.BE SURE CLUTCH IDLER IS INSTALLED AS SHOWN IN Figure 4R on Page 23, Figure 4S belowand Figure 4W on Page 25 WHEN INSTALLATION IS COMPLETE.DO NOT FORGET TO FILL GEARBOXES WITH #90 OIL.Figure 4SFigure 4TFigure 4U24 PNEG-1358 Red Giant Grain Stir-Ator
4. Installation ProceduresFigure 4VFigure 4W22. Installation of gearbox connecting shaft shields using two (2) shields for 4 auger unit and three (3)shields for 6 auger unit. Simply place shield in position as shown in Figure 4X. Firmly place notchedend of shield between gearbox mounting brackets and complete installation by hooking spring to thebottom side of the trolley frame. (See Figure 4X and Page 40.)Greenfield shown in photo has been replaced with 14-3 rubber covered wire.PROPER INSTALLATION GREATLY REDUCES SERVICE CALLS.Figure 4XPNEG-1358 Red Giant Grain Stir-Ator 25
Page 1: Red Giant Grain Stir-AtorModel 176O
Page 6 and 7: 1. SafetySafety InstructionsOur for
Page 9 and 10: 1. SafetyWear Protective ClothingWe
Page 11 and 12: 2. DecalsTHE DECALS SHOWN ON THIS P
Page 13 and 14: 2. DecalsTHE DECALS SHOWN ON THIS P
Page 15 and 16: 4. Installation ProceduresNOTE: Pri
Page 17 and 18: 4. Installation ProceduresChain idl
Page 19 and 20: 4. Installation Procedures12. For 6
Page 21 and 22: 4. Installation Procedures15. Next
Page 23: 4. Installation Procedures19. Insta
Page 27 and 28: 4. Installation Procedures25. Take
Page 29 and 30: 4. Installation ProceduresFigure 4A
Page 31 and 32: 4. Installation Procedures28. Assem
Page 33 and 34: 4. Installation Procedures32. After
Page 35 and 36: 5. Bin Wall StressesRead the follow
Page 37 and 38: 6. Overall Size and DimensionsRed G
Page 39 and 40: 7. Parts List1. 4-6 Auger Shields a
Page 41 and 42: 7. Parts List4-6 Auger Shields and
Page 43 and 44: 7. Parts List4-6 Auger Shields and
Page 45 and 46: 7. Parts List4-6 Auger Trolley Base
Page 51 and 52: 7. Parts ListOutboard Pivot End and
Page 53 and 54: 7. Parts ListOutboard Pivot End and
Page 55 and 56: 7. Parts ListCenter Inboard Pivot E
Page 57 and 58: Center Inboard Pivot End - Model 17
Page 59 and 60: Center Inboard Pivot End - Model 17
Page 61 and 62: 7. Parts List6 Auger Trolley Extens
Page 63 and 64: 7. Parts List6 Auger Trolley Extens
Page 65 and 66: 7. Parts ListPinion ShaftsVon Ruden
Page 67 and 68: 7. Parts ListGearbox #129 (104B2134
Page 69 and 70: 7. Parts ListGearbox #150 (104B2135
Page 71 and 72: 7. Parts ListRed Giant GearboxesIde
Page 73 and 74: 7. Parts ListDrawingsFigure 7DFigur
Page 75 and 76:
8. Wiring Diagrams3 Phase - 230 Vol
Page 77 and 78:
8. Wiring Diagrams3 Phase - 575 Vol
Page 79 and 80:
9. OperationsDRYING IN GRAIN DEPTHS
Page 81 and 82:
Operation Recommendations10. Drying
Page 83 and 84:
12. Maintenance and AdjustmentsRed
Page 85 and 86:
12. Maintenance and Adjustments10.
Page 87 and 88:
Stir-Guard13. Red Giant Troubleshoo
Page 89 and 90:
Track Unit1. Drive chain too loose.
Page 91 and 92:
Storage14. Storage and Installation
Page 93 and 94:
15. WarrantyGSI Group, LLC Limited
show all

Red Giant Grain Stir-Ator - David Manufacturing Co.

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?