M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

More documents

Recommendations

Info

ARMY TM 9 1005 319 23&P AIR FORCE TO 11W3 5-5 42 2-18. BUTTSTOCK ASSEMBLY (CONT). c. INSPECTION NOTE M16A2 buttstocks, PN 9349121, with unauthorized markings may be used under the following conditions: a. The only authorized markings are those which are temporary In nature, i e , paint, tape, etc b. When marking a buttstock, only use temporary markings c. Buttstocks with unauthorized markings that have been stamped into the surface of the buttstock will not be used d. Unauthorized markings that have previously been scratched, etched, carved, etc may continue In use if the marks do not extend Into the fiber of the buttstock Cutting Into the fiber of the buttstock may weaken it e. These marks may be at any location on the buttstock Unauthorized markings are not desirable. However, if previously applied, they will be allowed to continue In use due to the cost of the buttstock. 1. Inspect buttstock for cracks using the following guidelines: a. Under the following conditions, hairline cracks (no chipped away material allowed) originating from buttplate end of buttstock are acceptable. (1) One hairline crack, not to exceed 1 in. 12.54 cm) In length, per side of buttstock. (2) Two additional hairline cracks up to 0 25 in (0 64 cm) In length, per side of buttstock (3) A total of three cracks per side of buttstock, originating from buttplate end, are allowable. b. Cracks In the critical area at the front end of the buttstock are not acceptable and these buttstocks must be replaced. 2. While buttplate Is Installed on rifle, Inspect for cracks around the mounting holes Check for cracks In excess of 0 25 In. (O 64 cm) In length which extend through the buttplate Replace If cracked. 3. Inspect door assembly for cracks, corrosion, stuck plunger, separations on outer face, or other damage Replace If defective. 2-66
ARMY TM 9 1005319-23&P AIR FORCE TO 11W3-5-542 d. REPAIR e. LUBRICATION Replace all authorized unserviceable Items Unserviceable Items are those Lubricate all metal components (p 2-33) Items which are damaged. (operator’s manual) f. REASSEMBLY RIFLE ONLY 1. Position hinge (1) on door assembly (2) and Install straight pin (3) RIFLE ONLY 2. Install door assembly (2) into buttplate (4) and press plunger (5) to lock RIFLE ONLY 3. Position buttplate group (6) and small sling swivel (7) to the buttstock (8) and secure with self-locking screw (9). NOTE See page 2-62, reassembly, for reassembly of buttstock assembly to lower receiver Change 3 2-67
Page 1 and 2:
ARMY TM 9-1005-319-23&P AIR FORCE T
Page 3 and 4:
By Order of the Secretary of the Ar
Page 5 and 6:
Remove Pages Insert Pages 4-1 and 4
Page 7 and 8:
Page 9 and 10:
ARMY TM 9-1005-319-23&P AIR FORCE 1
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 41 and 42:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54: ARMY TM 9-1005-319-23&P AIR FORCE T
Page 77 and 78: 2-16. UPPER RECEIVER AND BARREL ASS
Page 79 and 80: ARMY TM 9-1005-319-23 & P AIR FORCE
Page 83 and 84: c. INSPECTION ARMY TM 9-1005-319-23
Page 87 and 88: ARMY TM 9-1005-319-23 & P AIR FORCE
Page 91 and 92: ARMY TM 9 1005 319 23&P AIR FORCE T
Page 97 and 98: NOTE AIR FORCE ONLY: Only depot mai
Page 103: ARMY TM1 9 1 005 31 9 23&P AIR FORC
Page 115 and 116: ARMY TM 9-1005-319-23&P AIR FORCF T
Page 117 and 118: TROUBLESHOOTING (CONT) ARMY TM 9-10
Page 129 and 130: Section III. MAINTENANCE PROCEDURES
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
ARMY TM 9-1005 319-23&P AIR FORCE T
Page 211 and 212:
ARMY TM 9 1005 319 23&P AIR FORCE T
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
SECTION II ARMY TM 9-1005-319-23&P
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
SECTION II TM9-1005-319-23&P (1) (2
Page 283 and 284:
SECTION II TM9-1005-319-23&P (1) (2
Page 285 and 286:
SECTION II TM9-1005-319-23&P (1) (2
Page 287 and 288:
SECTION II TM9-1005-319-23&P (1) (2
Page 289 and 290:
SECTION II TM9-1005-319-23&P (1) (2
Page 291 and 292:
SECTION II TM9-1005-319-23&P (1) (2
Page 293 and 294:
SECTION II TM9-1005-319-23&P (1) (2
Page 295 and 296:
SECTION II TM9-1005-319-23&P (1) (2
Page 297 and 298:
Section III TM9-1005-319-23&P (1) (
Page 299 and 300:
SECTION IV TM9-1005-319-23&P CROSS-
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
APPENDIX D EXPENDABLE/DURABLE SUPPL
Page 307 and 308:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 309 and 310:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 325:
PIN: 060514-005
show all

M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

Create successful ePaper yourself

Delete template?

Save as template?