M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

More documents

Recommendations

Info

NAVMC 10772.........................................Recommended Changes to Technical Publications NAVMC 11003.........................................Ordnance Serialized Items Subsidiary Records SF 364.....................................................Report of Discrepancy (ROD) SF 368.....................................................Product Quality Deficiency Report A-6 SUPPLY CATALOGS/SUPPLY LISTS. ARMY TM 9-1005-319-23&P AIR FORCE TO 1 1W3-5-5-42 SC 4933-95-CL-A11................................Shop Set, Small Arms Field Maintenance SC 5180-95-CL-A07................................Tool Kit, Small Arms Repair A-3/(A-4 blank)
ARMY TM 9 1005 319 23&P AIR FORCE TO 1 1W3 5-5-42 APPENDIX B MAINTENANCE ALLOCATION CHART Section I. INTRODUCTION B-1. GENERAL. a. This section provides a general explanation of all maintenance and repair functions authorized at various maintenance levels b. The Maintenance Allocation Chart (MAC) In section II designates overall authority and responsibility for the performance of maintenance functions on the identified end Item or component. The application of the maintenance functions to the end Item or component will be consistent with the capacities and capabilities of the designated maintenance levels c. Section III lists the tools and test equipment (both special tools and common tool sets) required for each maintenance function as referenced from section II. d. Section IV contains supplemental instructions and explanatory notes for a particular maintenance function. B-2. MAINTENANCE FUNCTIONS. Maintenance functions will be limited to and defined as follows: (except for ammunition MAC’) a. Inspect. To determine the serviceability of an Item by comparing Its physical, mechanical, and or electrical characteristics with established standards through examination leg , by sight, sound, or feel). b. Test. To verify serviceability by measuring the mechanical, pneumatic, hydraulic, or electrical characteristics of an Item and comparing those characteristics with prescribed standards c. Service. Operations required periodically to keep an Item In proper operating condition, I e to clean (includes decontaminate, when required), to preserve, to drain, to paint, or to replenish fuel, lubricants, chemical fluids. or gases. d. Adjust. To maintain or regulate, within prescribed limits, by bringing Into proper or exact position, or by setting the operating characteristics to specified parameters ’Exception is authorized for ammunition MAC to permit the redesignation/redefinition of maintenance function headings to more adequately identify ammunition maintenance functions The heading designations and definitions will be Included In the appropriate technical manual for each category of ammunition B-1
Page 1 and 2:
ARMY TM 9-1005-319-23&P AIR FORCE T
Page 3 and 4:
By Order of the Secretary of the Ar
Page 5 and 6:
Remove Pages Insert Pages 4-1 and 4
Page 7 and 8:
Page 9 and 10:
ARMY TM 9-1005-319-23&P AIR FORCE 1
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 41 and 42:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
2-16. UPPER RECEIVER AND BARREL ASS
Page 79 and 80:
ARMY TM 9-1005-319-23 & P AIR FORCE
Page 81 and 82:
Page 83 and 84:
c. INSPECTION ARMY TM 9-1005-319-23
Page 85 and 86:
Page 87 and 88:
ARMY TM 9-1005-319-23 & P AIR FORCE
Page 89 and 90:
Page 91 and 92:
ARMY TM 9 1005 319 23&P AIR FORCE T
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
NOTE AIR FORCE ONLY: Only depot mai
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
ARMY TM1 9 1 005 31 9 23&P AIR FORC
Page 105 and 106:
ARMY TM 9 1005319-23&P AIR FORCE TO
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
ARMY TM 9-1005-319-23&P AIR FORCF T
Page 117 and 118:
TROUBLESHOOTING (CONT) ARMY TM 9-10
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Section III. MAINTENANCE PROCEDURES
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188: ARMY TM 9-1005-319-23&P AIR FORCE T
Page 209 and 210: ARMY TM 9-1005 319-23&P AIR FORCE T
Page 211 and 212: ARMY TM 9 1005 319 23&P AIR FORCE T
Page 237: ARMY TM 9-1005-319-23&P AIR FORCE T
Page 255 and 256: SECTION II ARMY TM 9-1005-319-23&P
Page 281 and 282: SECTION II TM9-1005-319-23&P (1) (2
Page 289 and 290:
SECTION II TM9-1005-319-23&P (1) (2
Page 291 and 292:
SECTION II TM9-1005-319-23&P (1) (2
Page 293 and 294:
SECTION II TM9-1005-319-23&P (1) (2
Page 295 and 296:
SECTION II TM9-1005-319-23&P (1) (2
Page 297 and 298:
Section III TM9-1005-319-23&P (1) (
Page 299 and 300:
SECTION IV TM9-1005-319-23&P CROSS-
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
APPENDIX D EXPENDABLE/DURABLE SUPPL
Page 307 and 308:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 309 and 310:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 325:
PIN: 060514-005
show all

M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?