M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

More documents

Recommendations

Info

ARMY TM 9 1005 319-23&P AIR FORCE TO 11W3-5 5 42 3-5. TROUBLESHOOTING PROCEDURES (CONT). TROUBLESHOOTING (CONT) MALFUNCTION TEST OR INSPECTION CORRECTIVE ACTION 4. FAILURE TO LOCK. Step 1. Damaged bolt carrier key (1). Repair or replace bolt carrier key (1) (p 3-25) Step 2 Loose screws (2) on bolt carrier key (1). a. Disassemble and repair (p 3-25) b. Reassemble using new screws. Step 3 Bent gas tube (3). a Adjust by bending gas tube 13) In area of handguards b Replace gas tube (3) and check alignment (p 3-29) Step 4. Short recoil Refer to page 3 9 3-4
TROUBLESHOOTING (CONT) ARMY TM 9-1005-319-23&P AIR FORCE TO 11W3-5-5-42 MALFUNCTION TEST OR INSPECTION CORRECTIVE ACTION 5. FAILURE TO FIRE. Step 1. Broken hammer (1). Replace hammer (1) (p 3-73). Step 2. Weak or broken hammer spring (2). Replace hammer spring (2) (p 3-73). Step 3. Hammer spring (2) improperly assembled. Assemble properly. Step 4. (M16A2 and M4 ONLY) Burst cam (3) and/or cam spring (4) frozen or improperly assembled Disassemble, clean, lubricate, and reassemble correctly (p 3-73). Step 5. Step 6. Selector lever (5) frozen on SAFE position. Disassemble and clean (p 3-62) Broken firing pin (6) or firing pin does not meet gage protrusion requirement. Replace firing pin (6) (p 3-16). Change 4 3-5’
Page 1 and 2:
ARMY TM 9-1005-319-23&P AIR FORCE T
Page 3 and 4:
By Order of the Secretary of the Ar
Page 5 and 6:
Remove Pages Insert Pages 4-1 and 4
Page 7 and 8:
Page 9 and 10:
ARMY TM 9-1005-319-23&P AIR FORCE 1
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 41 and 42:
PREVENTIVE MAINTENANCE CHECKS AND S
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66: ARMY TM 9-1005-319-23&P AIR FORCE T
Page 77 and 78: 2-16. UPPER RECEIVER AND BARREL ASS
Page 79 and 80: ARMY TM 9-1005-319-23 & P AIR FORCE
Page 83 and 84: c. INSPECTION ARMY TM 9-1005-319-23
Page 87 and 88: ARMY TM 9-1005-319-23 & P AIR FORCE
Page 91 and 92: ARMY TM 9 1005 319 23&P AIR FORCE T
Page 97 and 98: NOTE AIR FORCE ONLY: Only depot mai
Page 103 and 104: ARMY TM1 9 1 005 31 9 23&P AIR FORC
Page 105 and 106: ARMY TM 9 1005319-23&P AIR FORCE TO
Page 115: ARMY TM 9-1005-319-23&P AIR FORCF T
Page 129 and 130: Section III. MAINTENANCE PROCEDURES
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
ARMY TM 9-1005 319-23&P AIR FORCE T
Page 211 and 212:
ARMY TM 9 1005 319 23&P AIR FORCE T
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
SECTION II ARMY TM 9-1005-319-23&P
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
SECTION II TM9-1005-319-23&P (1) (2
Page 283 and 284:
SECTION II TM9-1005-319-23&P (1) (2
Page 285 and 286:
SECTION II TM9-1005-319-23&P (1) (2
Page 287 and 288:
SECTION II TM9-1005-319-23&P (1) (2
Page 289 and 290:
SECTION II TM9-1005-319-23&P (1) (2
Page 291 and 292:
SECTION II TM9-1005-319-23&P (1) (2
Page 293 and 294:
SECTION II TM9-1005-319-23&P (1) (2
Page 295 and 296:
SECTION II TM9-1005-319-23&P (1) (2
Page 297 and 298:
Section III TM9-1005-319-23&P (1) (
Page 299 and 300:
SECTION IV TM9-1005-319-23&P CROSS-
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
APPENDIX D EXPENDABLE/DURABLE SUPPL
Page 307 and 308:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 309 and 310:
EXPENDABLE/DURABLE SUPPLIES AND MAT
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 325:
PIN: 060514-005
show all

M16 Maintenance Manual TM9-1005-319-23.pdf - CombatRifle.net

Create successful ePaper yourself

Delete template?

Save as template?