SPARC Enterprise T5120 and T5220 Servers Service Manual - Fujitsu

More documents

Recommendations

Info

▼ Remove the Top Cover 67 Servicing Hard Drives 69 Hard Drive Servicing Overview 69 Hard Drive LEDs 70 ▼ Remove a Hard Drive 71 ▼ Install a Hard Drive 73 Four-Drive Capable Backplane Configuration Reference 77 Eight-Drive Capable Backplane Configuration Reference 78 Sixteen-Drive Capable Backplane Configuration Reference 79 Servicing Motherboard Components 81 Servicing FB-DIMMs 81 Memory Fault Handling Overview 82 ▼ Identify Faulty FB-DIMMs Using the show faulty Command 83 ▼ Identify Faulty FB-DIMMs Using the FB-DIMM Fault Locator Button 83 ▼ Remove FB-DIMMs 85 ▼ Install Replacement FB-DIMMs 87 ▼ Verify Successful Replacement of Faulty FB-DIMMs 89 ▼ Upgrade Memory Configuration With Additional FB-DIMMs 91 FB-DIMM Configuration Guidelines 95 Guidelines for Upgrading Memory 95 When Replacing Faulty FB-DIMMs 95 FB-DIMM Configuration Reference 96 Servicing the Air Duct 100 ▼ Remove the Air Duct 100 ▼ Install the Air Duct 101 Servicing PCIe/XAUI Risers 102 PCIe/XAUI Riser Overview 102 viii SPARC Enterprise T5120 and T5220 Servers Service Manual • July 2009
▼ Remove a PCIe/XAUI Riser 102 ▼ Install a PCIe/XAUI Riser 104 ▼ Remove a PCIe or XAUI Card 106 ▼ Install a PCIe or XAUI Card 107 PCIe/XAUI Card Configuration Reference for SPARC Enterprise T5120 Servers 110 PCIe and XAUI Card Reference for SPARC Enterprise T5220 Servers 111 Servicing the Battery 112 System Battery Overview 112 ▼ Remove a Battery 113 ▼ Install a Battery 114 Servicing the SCC Module 114 SCC Module Overview 114 ▼ Remove a Faulty SCC Module 115 ▼ Install a New SCC Module 116 Servicing the Motherboard Assembly 117 Motherboard Servicing Overview 117 ▼ Remove the Motherboard Assembly 118 ▼ Install the Motherboard Assembly 120 Servicing Fan Modules 123 Fan Module Overview 123 Fan Module Configurations for SPARC Enterprise T5120 Servers (4- and 8- Disk Capable) 124 Fan Module Configurations for SPARC Enterprise T5220 Servers (8- and 16-Disk Capable) 124 Fan Module Status LEDs 125 ▼ Remove a Fan Module 125 ▼ Install a Fan Module 127 Contents ix
Page 3 and 4: Manual Code C120-E463-04EN Part No.
Page 5: Copyright © 2009 Sun Microsystems,
Page 8 and 9: How to Switch From the System Conso
Page 12 and 13: Servicing Power Supplies 129 Power
Page 14 and 15: HDD Data Cable Routing for SAS RAID
Page 16 and 17: Structure and Contents of This Manu
Page 18 and 19: Title Description Manual Code SPARC
Page 20 and 21: Prompt Notations The following prom
Page 22 and 23: Task Warning Maintenance Damage The
Page 24 and 25: Product Handling Maintenance Warnin
Page 26 and 27: Fujitsu Welcomes Your Comments If y
Page 28 and 29: Infrastructure Boards in SPARC Ente
Page 30 and 31: Board Description Hard drive backpl
Page 32 and 33: FIGURE: Front Panel Controls and In
Page 34 and 35: Related Information ■ “LED Over
Page 36 and 37: FIGURE: Front Panel Controls and In
Page 38 and 39: Related Information ■ “LED Over
Page 40 and 41: Status LEDs for Ethernet Ports and
Page 42 and 43: ■ Power-on self-test (POST) - POS
Page 44 and 45: FIGURE: Diagnostics Flowchart 18 SP
Page 46 and 47: TABLE: Diagnostic Flowchart Referen
Page 48 and 49: TABLE: System Faults and the Corres
Page 50 and 51: Note - No ILOM command is needed to
Page 52 and 53: Service-Related ILOM Command Summar
Page 54 and 55: TABLE: Service-Related Commands (Co
Page 56 and 57: Example of show faulty Output When
Page 58 and 59: ▼ Display FRU Information With th
Page 60 and 61:
3. Log out of the root account afte
Page 62 and 63:
Note - The value of keyswitch_state
Page 64 and 65:
Note - When you change individual P
Page 66 and 67:
-----------------------------------
Page 68 and 69:
2. Clear the fault by setting the F
Page 70 and 71:
Solaris PSH Feature Overview The So
Page 72 and 73:
1. Check the event log using the fm
Page 74 and 75:
3. Use the clear_fault_action prope
Page 76 and 77:
The database that contains the list
Page 78 and 79:
-> start /SYS Are you sure you want
Page 80 and 81:
FIGURE: SunVTS Browser Interface 4.
Page 82 and 83:
56 SPARC Enterprise T5120 and T5220
Page 84 and 85:
Caution - There is a risk of person
Page 86 and 87:
Properties: type = Host System keys
Page 88 and 89:
▼ Power Off the Server (Power But
Page 90 and 91:
FIGURE: Slide Release Latches 4. Wh
Page 92 and 93:
4. From the front of the server, pu
Page 94 and 95:
FIGURE: Removing the Top Cover 3. R
Page 96 and 97:
If either of these conditions exist
Page 98 and 99:
1. At the Solaris prompt, type the
Page 100 and 101:
Note - SPARC Enterprise T5120 serve
Page 102 and 103:
7. At the Solaris prompt, type the
Page 104 and 105:
Eight-Drive Capable Backplane Confi
Page 106 and 107:
TABLE: Physical Drive Locations, FR
Page 108 and 109:
Memory Fault Handling Overview A va
Page 110 and 111:
Note - The FB-DIMM Fault Locator bu
Page 112 and 113:
FIGURE: Removing FB-DIMMs 6. Press
Page 114 and 115:
FIGURE: Installing FB-DIMMs 7. Alig
Page 116 and 117:
Page 118 and 119:
Caution - You must disconnect the p
Page 120 and 121:
Page 122 and 123:
FB-DIMM Configuration Reference The
Page 124 and 125:
The following table maps FB-DIMM lo
Page 126 and 127:
Related Information ■ “Identify
Page 128 and 129:
Servicing PCIe/XAUI Risers These to
Page 130 and 131:
FIGURE: Removing the PCIe/XAUI Rise
Page 132 and 133:
5. Engage the two captive Phillips
Page 134 and 135:
FIGURE: Installing a PCIe Card (SPA
Page 136 and 137:
11. Connect the power supplies. See
Page 138 and 139:
Related Information ■ “Remove a
Page 140 and 141:
▼ Install a Battery 1. Unpack the
Page 142 and 143:
Note - The server will not function
Page 144 and 145:
Note - The firmware configuration v
Page 146 and 147:
FIGURE: Removing the Motherboard As
Page 148 and 149:
6. If you are installing a new moth
Page 150 and 151:
Fan Module Configurations for SPARC
Page 152 and 153:
1. Extend the server to the mainten
Page 154 and 155:
FIGURE: Installing a Fan Module 2.
Page 156 and 157:
FIGURE: Power Supply LEDs (SPARC En
Page 158 and 159:
FIGURE: Cable management Arm Releas
Page 160 and 161:
▼ Install a Power Supply 1. Align
Page 162 and 163:
7. At the ALOM CMT sc> prompt, type
Page 164 and 165:
TABLE: Components That Require Remo
Page 166 and 167:
2. Unplug the power cords. See “D
Page 168 and 169:
FIGURE: Installing the DVD/USB Modu
Page 170 and 171:
2. Disconnect the power cables. See
Page 172 and 173:
Related Information ■ “Remove t
Page 174 and 175:
FIGURE: Removing a Hard Drive Cage
Page 176 and 177:
FIGURE: Installing a Hard Drive Cag
Page 178 and 179:
14. Power on the system. See “Pow
Page 180 and 181:
FIGURE: Removing a Hard Drive Backp
Page 182 and 183:
FIGURE: Installing a Hard Drive Bac
Page 184 and 185:
FIGURE: Removing the Front Control
Page 186 and 187:
Servicing Power Distribution Boards
Page 188 and 189:
FIGURE: Removing a Power Distributi
Page 190 and 191:
FIGURE: Installing a Power Distribu
Page 192 and 193:
FIGURE: Installing a Power Supply i
Page 194 and 195:
Power Supply Backplane Overview The
Page 196 and 197:
Related Information ■ “Install
Page 198 and 199:
Paddle Card Overview The paddle car
Page 200 and 201:
Page 202 and 203:
FIGURE: Installing the Top Cover No
Page 204 and 205:
FIGURE: Release Tabs on the Rail 2.
Page 206 and 207:
▼ Power On the Server Using the F
Page 208 and 209:
Motherboard Components in T5120 Ser
Page 210 and 211:
I/O Components in SPARC Enterprise
Page 212 and 213:
Power Distribution/Fan Module Compo
Page 214 and 215:
Internal Cables for Onboard SAS Con
Page 216 and 217:
FIGURE: Internal Cables for the Onb
Page 218 and 219:
FIGURE: Hard Drive Data Cable Routi
Page 220 and 221:
FIGURE: Hard Drive Data Cable Routi
Page 222 and 223:
Motherboard Components in T5220 Ser
Page 224 and 225:
I/O Components in SPARC Enterprise
Page 226 and 227:
Power Distribution/Fan Module Compo
Page 228 and 229:
Internal Cables for Onboard SAS Con
Page 230 and 231:
FIGURE: Internal Cables for the Onb
Page 232 and 233:
HDD Data Cable Routing for SAS RAID
Page 234 and 235:
Page 236 and 237:
fan power board FRU name, 187, 201
Page 238:
emoving, 67 topic guidelines, 1, 15
show all

SPARC Enterprise T5120 and T5220 Servers Service Manual - Fujitsu

Create successful ePaper yourself

Delete template?

Save as template?