SPARC Enterprise T5120 and T5220 Servers Service Manual - Fujitsu

More documents

Recommendations

Info

Servicing Power Supplies 129 Power Supplies Overview 129 Power Supply Status LEDs 129 ▼ Remove a Power Supply 131 ▼ Install a Power Supply 134 Power Supply Configuration Reference 136 Servicing Boards and Components 137 Important Safety Instructions 137 Servicing DVD/USB Modules 138 DVD/USB Module Overview 139 ▼ Remove the DVD/USB Module 139 ▼ Install the DVD/USB Module 141 Servicing Fan Power Boards 143 Fan Power Board Overview 143 ▼ Remove the Fan Power Board 143 ▼ Install the Fan Power Board 145 Servicing the Hard Drive Cage 146 Hard Drive Cage Overview 146 ▼ Remove the Hard Drive Cage 146 ▼ Install the Hard Drive Cage 149 Servicing the Hard Drive Backplane 152 Hard Drive Backplane Overview 152 ▼ Remove the Hard Drive Backplane 152 ▼ Install the Hard Drive Backplane 154 Servicing Front Control Panel Light Pipe Assemblies 156 Front Control Panel Light Pipe Assemblies Overview 157 ▼ Remove the Front Control Panel Light Pipe Assemblies 157 ▼ Install the Front Control Panel Light Pipe Assemblies 158 x SPARC Enterprise T5120 and T5220 Servers Service Manual • July 2009
Servicing Power Distribution Boards 160 Power Distribution Board Overview 160 ▼ Remove the Power Distribution Board 161 ▼ Install the Power Distribution Board 163 Servicing Power Supply Backplanes (SPARC Enterprise T5220 Servers) 167 Power Supply Backplane Overview 168 ▼ Remove the Power Supply Backplane 168 ▼ Install the Power Supply Backplane 170 Servicing Paddle Cards 171 Paddle Card Overview 172 ▼ Remove the Paddle Card 172 ▼ Install the Paddle Card 173 Returning the Server to Operation 175 ▼ Install the Top Cover 175 ▼ Reinstall the Server in the Rack 176 ▼ Return the Server to the Normal Rack Position 177 ▼ Connect Power Cords to the Server 178 ▼ Power On the Server Using the poweron Command 179 ▼ Power On the Server Using the Front Panel Power Button 180 Identifying FRUs in SPARC Enterprise T5120 Servers 181 Motherboard Components in T5120 Servers 182 I/O Components in SPARC Enterprise T5120 Servers 184 Power Distribution/Fan Module Components in SPARC Enterprise T5120 Servers 186 Internal Cables for Onboard SAS Controller Cards in SPARC Enterprise T5120 Servers 188 HDD Data Cable Routing for SAS RAID Controller Cards in Four-Disk Capable SPARC Enterprise T5120 Servers 191 Contents xi
Page 3 and 4: Manual Code C120-E463-04EN Part No.
Page 5: Copyright © 2009 Sun Microsystems,
Page 8 and 9: How to Switch From the System Conso
Page 10 and 11: ▼ Remove the Top Cover 67 Servici
Page 14 and 15: HDD Data Cable Routing for SAS RAID
Page 16 and 17: Structure and Contents of This Manu
Page 18 and 19: Title Description Manual Code SPARC
Page 20 and 21: Prompt Notations The following prom
Page 22 and 23: Task Warning Maintenance Damage The
Page 24 and 25: Product Handling Maintenance Warnin
Page 26 and 27: Fujitsu Welcomes Your Comments If y
Page 28 and 29: Infrastructure Boards in SPARC Ente
Page 30 and 31: Board Description Hard drive backpl
Page 32 and 33: FIGURE: Front Panel Controls and In
Page 34 and 35: Related Information ■ “LED Over
Page 36 and 37: FIGURE: Front Panel Controls and In
Page 38 and 39: Related Information ■ “LED Over
Page 40 and 41: Status LEDs for Ethernet Ports and
Page 42 and 43: ■ Power-on self-test (POST) - POS
Page 44 and 45: FIGURE: Diagnostics Flowchart 18 SP
Page 46 and 47: TABLE: Diagnostic Flowchart Referen
Page 48 and 49: TABLE: System Faults and the Corres
Page 50 and 51: Note - No ILOM command is needed to
Page 52 and 53: Service-Related ILOM Command Summar
Page 54 and 55: TABLE: Service-Related Commands (Co
Page 56 and 57: Example of show faulty Output When
Page 58 and 59: ▼ Display FRU Information With th
Page 60 and 61: 3. Log out of the root account afte
Page 62 and 63:
Note - The value of keyswitch_state
Page 64 and 65:
Note - When you change individual P
Page 66 and 67:
-----------------------------------
Page 68 and 69:
2. Clear the fault by setting the F
Page 70 and 71:
Solaris PSH Feature Overview The So
Page 72 and 73:
1. Check the event log using the fm
Page 74 and 75:
3. Use the clear_fault_action prope
Page 76 and 77:
The database that contains the list
Page 78 and 79:
-> start /SYS Are you sure you want
Page 80 and 81:
FIGURE: SunVTS Browser Interface 4.
Page 82 and 83:
56 SPARC Enterprise T5120 and T5220
Page 84 and 85:
Caution - There is a risk of person
Page 86 and 87:
Properties: type = Host System keys
Page 88 and 89:
▼ Power Off the Server (Power But
Page 90 and 91:
FIGURE: Slide Release Latches 4. Wh
Page 92 and 93:
4. From the front of the server, pu
Page 94 and 95:
FIGURE: Removing the Top Cover 3. R
Page 96 and 97:
If either of these conditions exist
Page 98 and 99:
1. At the Solaris prompt, type the
Page 100 and 101:
Note - SPARC Enterprise T5120 serve
Page 102 and 103:
7. At the Solaris prompt, type the
Page 104 and 105:
Eight-Drive Capable Backplane Confi
Page 106 and 107:
TABLE: Physical Drive Locations, FR
Page 108 and 109:
Memory Fault Handling Overview A va
Page 110 and 111:
Note - The FB-DIMM Fault Locator bu
Page 112 and 113:
FIGURE: Removing FB-DIMMs 6. Press
Page 114 and 115:
FIGURE: Installing FB-DIMMs 7. Alig
Page 116 and 117:
Page 118 and 119:
Caution - You must disconnect the p
Page 120 and 121:
Page 122 and 123:
FB-DIMM Configuration Reference The
Page 124 and 125:
The following table maps FB-DIMM lo
Page 126 and 127:
Related Information ■ “Identify
Page 128 and 129:
Servicing PCIe/XAUI Risers These to
Page 130 and 131:
FIGURE: Removing the PCIe/XAUI Rise
Page 132 and 133:
5. Engage the two captive Phillips
Page 134 and 135:
FIGURE: Installing a PCIe Card (SPA
Page 136 and 137:
11. Connect the power supplies. See
Page 138 and 139:
Related Information ■ “Remove a
Page 140 and 141:
▼ Install a Battery 1. Unpack the
Page 142 and 143:
Note - The server will not function
Page 144 and 145:
Note - The firmware configuration v
Page 146 and 147:
FIGURE: Removing the Motherboard As
Page 148 and 149:
6. If you are installing a new moth
Page 150 and 151:
Fan Module Configurations for SPARC
Page 152 and 153:
1. Extend the server to the mainten
Page 154 and 155:
FIGURE: Installing a Fan Module 2.
Page 156 and 157:
FIGURE: Power Supply LEDs (SPARC En
Page 158 and 159:
FIGURE: Cable management Arm Releas
Page 160 and 161:
▼ Install a Power Supply 1. Align
Page 162 and 163:
7. At the ALOM CMT sc> prompt, type
Page 164 and 165:
TABLE: Components That Require Remo
Page 166 and 167:
2. Unplug the power cords. See “D
Page 168 and 169:
FIGURE: Installing the DVD/USB Modu
Page 170 and 171:
2. Disconnect the power cables. See
Page 172 and 173:
Related Information ■ “Remove t
Page 174 and 175:
FIGURE: Removing a Hard Drive Cage
Page 176 and 177:
FIGURE: Installing a Hard Drive Cag
Page 178 and 179:
14. Power on the system. See “Pow
Page 180 and 181:
FIGURE: Removing a Hard Drive Backp
Page 182 and 183:
FIGURE: Installing a Hard Drive Bac
Page 184 and 185:
FIGURE: Removing the Front Control
Page 186 and 187:
Servicing Power Distribution Boards
Page 188 and 189:
FIGURE: Removing a Power Distributi
Page 190 and 191:
FIGURE: Installing a Power Distribu
Page 192 and 193:
FIGURE: Installing a Power Supply i
Page 194 and 195:
Power Supply Backplane Overview The
Page 196 and 197:
Related Information ■ “Install
Page 198 and 199:
Paddle Card Overview The paddle car
Page 200 and 201:
Page 202 and 203:
FIGURE: Installing the Top Cover No
Page 204 and 205:
FIGURE: Release Tabs on the Rail 2.
Page 206 and 207:
▼ Power On the Server Using the F
Page 208 and 209:
Motherboard Components in T5120 Ser
Page 210 and 211:
I/O Components in SPARC Enterprise
Page 212 and 213:
Power Distribution/Fan Module Compo
Page 214 and 215:
Internal Cables for Onboard SAS Con
Page 216 and 217:
FIGURE: Internal Cables for the Onb
Page 218 and 219:
FIGURE: Hard Drive Data Cable Routi
Page 220 and 221:
FIGURE: Hard Drive Data Cable Routi
Page 222 and 223:
Motherboard Components in T5220 Ser
Page 224 and 225:
I/O Components in SPARC Enterprise
Page 226 and 227:
Power Distribution/Fan Module Compo
Page 228 and 229:
Internal Cables for Onboard SAS Con
Page 230 and 231:
FIGURE: Internal Cables for the Onb
Page 232 and 233:
HDD Data Cable Routing for SAS RAID
Page 234 and 235:
Page 236 and 237:
fan power board FRU name, 187, 201
Page 238:
emoving, 67 topic guidelines, 1, 15
show all

SPARC Enterprise T5120 and T5220 Servers Service Manual - Fujitsu

Create successful ePaper yourself

Delete template?

Save as template?