Controls Start-Up, Operation, Service, and ... - Climayoreo

More documents

Recommendations

Info

SUB-MODE KEYPAD ENTRY Table 19 — Operating Mode <strong>and</strong> Sub-Mode Directory ITEM DISPLAY *Recycle restart pending 15-minute delay due to loss of refrigerant flow detected at start-up. 30 ITEM EXPANSION MODE ENTER MD01 ON/OFF CSM CONTROLLING CHILLER MD02 ON/OFF WSM CONTROLLING CHILLER MD03 ON/OFF MASTER/SLAVE CONTROL MD04 ON/OFF LOW SOURCE PROTECTION MD05 ON/OFF RAMP LOAD LIMITED MD06 ON/OFF TIMED OVERRIDE IN EFFECT MD07 ON/OFF LOW COOLER SUCTION TEMPA MD08 ON/OFF LOW COOLER SUCTION TEMPB MD09 ON/OFF SLOW CHANGE OVERRIDE MD10 ON/OFF MINIMUM OFF TIME ACTIVE MD11 ON/OFF LOW DISCHRGE SUPERHEAT A MD12 ON/OFF LOW DISCHRGE SUPERHEAT B MD13 ON/OFF DUAL SETPOINT MD14 ON/OFF TEMPERATURE RESET MD15 ON/OFF DEMAND LIMIT IN EFFECT MD16 ON/OFF COOLER FREEZE PROTECTION MD17 ON/OFF LOW TMP COOL/HI TMP HEAT MD18 ON/OFF HI TMP COOL/LO TMP HEAT MD19 ON/OFF MAKING ICE MD20 ON/OFF STORING ICE MD21 ON/OFF HIGH SCT CIRCUIT A MD22 ON/OFF HIGH SCT CIRCUIT B MD23 ON/OFF HIGH MOTOR CURRENT CIR. A MD24 ON/OFF HIGH MOTOR CURRENT CIR. B MD25 ON/OFF CKT A OFF REF FLOW DELAY* MD26 ON/OFF CKT B OFF REF FLOW DELAY* COMMENT MD27 ON/OFF CIRCUIT A — PUMPING OUT SHUTDOWN IN PROGRESS MD28 ON/OFF CIRCUIT B — PUMPOUT OUT SHUTDOWN IN PROGRESS MD29 ON/OFF UNIT OFF: NO WATER FLOW
SUB-MODE KEYPAD ENTRY Table 20 — Run Status Mode <strong>and</strong> Sub-Mode Directory ITEM DISPLAY 31 ITEM EXPANSION VIEW ENTER EWT XXX.X °F ENTERING FLUID TEMP LWT XXX.X °F LEAVING FLUID TEMP SETP XXX.X °F ACTIVE SETPOINT COMMENT CTPT XXX.X °F CONTROL POINT STAT X CONTROL MODE SERVICE TEST OFF LOCAL OFF CCN OFF TIME OFF EMRGCY ON LOCAL ON CCN ON TIME OCC YES/NO OCCUPIED MIN.L XX MIN MINUTES LEFT FOR START MODE YES/NO OVERRIDE MODES IN EFFECT CAP XXX % PERCENT TOTAL CAPACITY DEM.L XXX % ACTIVE DEMAND LIMIT ALRM XXX CURRENT ALARMS & ALERTS TIME XX.XX TIME OF DAY 00.00-23.59 MNTH XX MONTH OF YEAR January, February, etc. DATE XX DAY OF MONTH 01-31 YEAR XX YEAR RUN ENTER HRS.U XXXX HRS MACHINE OPERATING HOURS STR.U XXXX MACHINE STARTS HOUR ENTER HRS.A XXXX HRS CIRCUIT A RUN HOURS HRS.B XXXX HRS CIRCUIT B RUN HOURS HR.A1 XXXX HRS COMPRESSOR A1 RUN HOURS HR.A2 XXXX HRS COMPRESSOR A2 RUN HOURS HR.B1 XXXX HRS COMPRESSOR B1 RUN HOURS HR.B2 XXXX HRS COMPRESSOR B2 RUN HOURS STRT ENTER STR.A XXXX CIRCUIT A STARTS ST.A1 XXXX COMPRESSOR A1 STARTS ST.A2 XXXX COMPRESSOR A2 STARTS STR.B XXXX CIRCUIT B STARTS ST.B1 XXXX COMPRESSOR B1 STARTS ST.B2 XXXX COMPRESSOR B2 STARTS
Page 1 and 2: 30GXN,R080-528 30HXA,HXC076-271 Air
Page 3 and 4: The control system cycles compresso
Page 5 and 6: Oil Pumps — The 30GXN,GXR,HX scre
Page 7 and 8: ComfortLink Compressor Protection (
Page 9 and 10: TERMINAL BLOCK 21 21 22 22 23 23 MI
Page 11 and 12: DEADBAND EXAMPLE 2STARTS 8 47 46 7
Page 13 and 14: UNIT 30GXN,R Table 7 — Fan Stagin
Page 15 and 16: Table 9 — 30GXN,R080-350 Condense
Page 17 and 18: The 09DK054-094 condensers are supp
Page 19 and 20: TIME EWT LWT SETP Run Status Servic
Page 21 and 22: SUB- MODE KEYPAD ENTRY Table 12 —
Page 23 and 24: Table 12 ⎯ Configuration Mode and
Page 25 and 26: Table 13 — Service Test Mode and
Page 27 and 28: SUB-MODE KEYPAD ENTRY Table 15 —
Page 29: SUB-MODE KEYPAD ENTRY Table 18 —
Page 33 and 34: SUB-MODE KEYPAD ENTRY Table 23 —
Page 35 and 36: Table 24B — Example of Configurin
Page 37 and 38: MODE CONFIGURATION SUB-MODE RSET KE
Page 39 and 40: educe the current stages by the val
Page 41 and 42: TROUBLESHOOTING The 30GXN,R and 30H
Page 43 and 44: ALARM/ALERT CODE ALARM OR ALERT DES
Page 45 and 46: ALARM/ ALERT CODE ALARM OR ALERT DE
Page 47 and 48: ALARM/ALERT CODE ALARM OR ALERT DES
Page 49 and 50: A/D LEGEND — Analog to Digital Co
Page 51 and 52: BRAZED-PLATE ECONOMIZERS — Brazed
Page 53 and 54: 3 1 3 1 6 8 6 8 CONDENSERS (30HX On
Page 55 and 56: Refrigerant Charging/Adding Charge
Page 57 and 58: 11. If low oil level problems persi
Page 59 and 60: HPS LEGEND RRS HPS — High-Pressur
Page 61 and 62: TEMP (F) VOLTAGE DROP (V) Table 38A
Page 63 and 64: Table 39A — 10K Thermistor Temper
Page 65 and 66: Pressure Transducers — Discrete h
Page 67 and 68: FLOW SWITCH FLOW SWITCH LOCATION ST
Page 69 and 70: Carrier Comfort Network (CCN) Inter
Page 71 and 72: 30HXC machines: Check Condenser Wat
Page 73 and 74: Fig. 44A — 30GXN,R Minimum Load V
Page 75 and 76: UNIT 30GXN,R 080 083 090 093 106 10
Page 77 and 78: UNIT 30GXN,R 178, 328A, 353A, 353B
Page 79 and 80: APPENDIX A (cont) 30GXN,R (Reduced
Page 81 and 82:
UNIT 30HXC 076 086 096 106 116 126
Page 83 and 84:
UNIT 30HXA 076 086 096 106 116 126
Page 85 and 86:
Capacity Loading Sequence Example
Page 87 and 88:
The following tables show the loadi
Page 89 and 90:
STAGE LEGEND 0 — Off 1 — On COM
Page 91 and 92:
*And associated modular sizes. LEGE
Page 93 and 94:
CCN Table Name CIRCBDIO CIRCB_AN OP
Page 95 and 96:
PRESSURE DROP (FT WG) 100 10 1 100
Page 97 and 98:
PRESSURE DROP (ft wg) 50 40 30 20 1
Page 99 and 100:
PRESSURE DROP (ft wg) 100 10 1 100
Page 101 and 102:
Condenser Fans Condenser Fans Conde
Page 103 and 104:
LEGEND EXV — Electronic Expansion
Page 105 and 106:
2 Oil Level Switch & Oil Level Indi
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
APPENDIX G A_UNIT (Unit Operation):
Page 115 and 116:
APPENDIX G (cont) OPTIONS: Status D
Page 117 and 118:
APPENDIX G (cont) EXV_CONF: Configu
Page 119 and 120:
APPENDIX G (cont) RESETCON: Options
Page 121 and 122:
APPENDIX G (cont) ALARMS: Maintenan
Page 123 and 124:
APPENDIX G (cont) OILPRESS: Mainten
Page 125 and 126:
APPENDIX G (cont) WINTLOG: Maintena
Page 127 and 128:
APPENDIX I: MOTORMASTER® V OPERATI
Page 129 and 130:
The MMV also provides real time mon
Page 131 and 132:
CUT ALONG DOTTED LINE CUT ALONG DOT
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
show all

Controls Start-Up, Operation, Service, and ... - Climayoreo

Create successful ePaper yourself

Delete template?

Save as template?