Controls Start-Up, Operation, Service, and ... - Climayoreo
Controls Start-Up, Operation, Service, and ... - Climayoreo
Controls Start-Up, Operation, Service, and ... - Climayoreo
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
Building Interface — The 30GXN,GXR,HX chiller can<br />
be interfaced with multi-vendor control systems through 3 levels<br />
of inter-operability using BacLink, DataPort, or DataLINK<br />
devices. BacLink functions as a gateway between a CCN <strong>and</strong> a<br />
BACnet system to facilitate the passing of data from the CCN to<br />
BACnet. The Carrier DataPort is an interface device that allows<br />
other HVAC control systems to “read only” values in system<br />
elements connected to a CCN communication bus. The Carrier<br />
CCN Table<br />
Name<br />
A_UNIT<br />
CIRCADIO<br />
CIRCA_AN<br />
APPENDIX D<br />
Object Definitions<br />
30GXN/GXR/HXA/HXC Series 6 with Software Version 1.1 <strong>and</strong> later<br />
92<br />
DataLINK device is an interface device that allows other HVAC<br />
control systems to read <strong>and</strong> change (“read/write”) values in<br />
system elements connected to a CCN bus. Both DataPort <strong>and</strong><br />
DataLINK devices request data from a specified CCN system<br />
element <strong>and</strong> translate this data into ASCII characters off<br />
network. Information from the 30GXN,GXR,HX chiller control<br />
to support interface are listed in the following tables.<br />
Description Status Units Point DataPort DataLink BAClink<br />
GENERAL PARAMETERS<br />
Control Mode<br />
Occupied<br />
CCN Chiller<br />
Alarm State<br />
Active Dem<strong>and</strong> Limit<br />
Override Modes In Effect<br />
Percent Total Capacity<br />
Active Setpoint<br />
Control Point<br />
Entering Fluid Temp<br />
Leaving Fluid Temp<br />
Emergency Stop<br />
Minutes Left for <strong>Start</strong><br />
Heat/Cool Select<br />
CIRC. A DISCRETE OUTPUTS<br />
Compressor A1 Relay<br />
Compressor A2 Relay<br />
Loader A1 Relay<br />
Loader A2 Relay<br />
Minimum Load Valve<br />
Oil Heater<br />
Motor Cooling A1 Solenoid<br />
Motor Cooling A2 Solenoid<br />
Oil Pump<br />
Oil Solenoid A1<br />
Oil Solenoid A2<br />
CIRC. A DISCRETE INPUTS<br />
Compressor A1 Feedback<br />
Compressor A2 Feedback<br />
Oil Level Switch<br />
CIRCUIT A ANALOG VALUES<br />
Percent Total Capacity<br />
Percent Available Cap.<br />
Circuit Running Current<br />
Discharge Pressure<br />
Suction Pressure<br />
Economizer Pressure<br />
Discharge Superheat Temp<br />
Discharge Gas Temp<br />
Discharge Gas Temp – A1<br />
Discharge Gas Temp – A2<br />
Saturated Condensing Tmp<br />
Saturated Suction Temp<br />
EXV% Open<br />
Variable Head Press Pct.<br />
COMP A1 ANALOG VALUES<br />
A1 Oil Pressure Diff.<br />
A1 Oil Pressure<br />
A1 Motor Temperature<br />
Comp A1 Running Current<br />
Comp A1 % Must Trip Amps<br />
COMP A2 ANALOG VALUES<br />
A2 Oil Pressure Diff.<br />
A2 Oil Pressure<br />
A2 Motor Temperature<br />
Comp A2 Running Current<br />
Comp A2 % Must Trip Amps<br />
0=<strong>Service</strong>Test<br />
1 = OFF Local<br />
2 = OFF CCN<br />
3 = OFF Clock<br />
4 = OFF Emergency<br />
5 = ON Local<br />
6 = ON CCN<br />
7 = ON Clock<br />
No/Yes<br />
<strong>Start</strong>/Stop<br />
Normal/Alert/Alarm<br />
0to100<br />
No/Yes<br />
0to100<br />
-20 to 70 (-28.8 to 21.1)<br />
-20 to 70 (-28.8 to 21.1)<br />
snnn.n<br />
snnn.n<br />
Enable/Emstop<br />
00:00 to 15:00<br />
Heat/Cool<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Off/On<br />
Close/Open<br />
0to100<br />
0to100<br />
0 to 1200<br />
nnn.n<br />
nnn.n<br />
nnn.n<br />
snnn.n<br />
nnn.n<br />
nnn.n<br />
nnn.n<br />
snnn.n<br />
snnn.n<br />
0to100<br />
0to100<br />
nnn.n<br />
nnn.n<br />
nnn.n<br />
0to600<br />
0to100<br />
nnn.n<br />
nnn.n<br />
nnn.n<br />
0to600<br />
0to100<br />
%<br />
%<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
Minutes<br />
%<br />
%<br />
Amps<br />
PSIG (KPA)<br />
PSIG (KPA)<br />
PSIG (KPA)<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
°F (°C)<br />
%<br />
%<br />
PSIG (KPA)<br />
PSIG (KPA)<br />
°F (°C)<br />
Amps<br />
%<br />
PSIG (KPA)<br />
PSIG (KPA)<br />
°F (°C)<br />
Amps<br />
%<br />
STAT<br />
OCC<br />
CHIL_S_S<br />
ALM<br />
DEM_LIM<br />
MODE<br />
CAP_T<br />
SP<br />
CTRL_PNT<br />
EWT<br />
LWT<br />
EMSTOP<br />
MIN_LEFT<br />
HEATCOOL<br />
K_A1_RLY<br />
K_A2_RLY<br />
LOADR_A1<br />
LOADR_A2<br />
MLV<br />
OILA_HTR<br />
MTRCL_A1<br />
MTRCL_A2<br />
OILPMP_A<br />
OILSL_A1<br />
OILSL_A2<br />
K_A1_FBK<br />
K_A2_FBK<br />
OILA_SW<br />
CAPA_T<br />
CAPA_A<br />
A_CURR<br />
DP_A<br />
SP_A<br />
ECNP_A<br />
SH_A<br />
DISTMP_A<br />
DISTMPA1<br />
DISTMPA2<br />
TMP_SCTA<br />
TMP_SSTA<br />
EXV_A<br />
VHPA<br />
DOP_A1<br />
OP_A1<br />
TMTR_A1<br />
A1_CURR<br />
A1_MTA<br />
DOP_A2<br />
OP_A2<br />
TMTR_A2<br />
A2_CURR<br />
A2_MTA<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RW<br />
RO<br />
RW<br />
RO<br />
RO<br />
RO<br />
RW<br />
RO<br />
RO<br />
RW<br />
RO<br />
RW<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RO<br />
RW<br />
RO<br />
RW<br />
NA<br />
RO<br />
NA<br />
RW<br />
RO<br />
RO<br />
RW<br />
NA<br />
RW<br />
RO<br />
RO<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
RO<br />
RO<br />
NA<br />
RO<br />
RO<br />
NA<br />
RO<br />
NA<br />
RO<br />
RO<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA<br />
NA
Change language