Shanks Owners manual (10 Build) 30, 30H, 35, 35H, 40 ... - EP Barrus

More documents

Recommendations

Info

SHANKS 35, 35H and 40 Calorifier outlet Air bleed connection (small ID on bottle) Header tank Engine connections filler (large ID on bottle) Figure 7: Header Tank Connections Shanks 35, 35H and 40 SHANKS 45 To header tank Calorifier outlet Calorifier inlet Figure 8: Header Tank Connections Shanks 45 RDG6039484 Shanks10 Owners Manual Issue 1 Page 16 of 51
14. Calorifier • The temperature of coolant flowing to the calorifier from the engine can be 85 – 90°C. A blender valve must be incorporated in the calorifier/hot water system outlet to lower the hot water temperature for domestic use. 15. Control Cables • Connect engine speed control cable. With the engine off, ensure that the engine speed control lever achieves full travel from idle to full speed. Adjust if necessary. • Check the gearbox shift lever selects positively and that the drive direction corresponds with the gearshift control lever. Ensure that the gearbox control lever and the gearshift lever are both in neutral before connection. Adjust if necessary. 16. Domestic Battery Bank Domestic battery banks that are too large create excessive loads on the domestic alternator. Alternators running at maximum output for prolonged periods of time will eventually fail; alternators that fail due to the battery bank being over the maximum recommended size will not be covered by warranty. Higher output alternators or travelpower kits are available; if larger battery banks are required discuss your individual power requirements with the boat builder. • The maximum domestic battery bank is calculated using the following: Live aboard, three times domestic alternator, maximum output current. Hire fleet use, three and a half times domestic alternator, maximum output current. If the engine is fitted with a Barrus approved alternator management system the domestic battery bank can be up to four times the domestic alternator, maximum output current. Example: Hire fleet application fitted with 110 amp domestic charge alternator 3.5 x 110 = 385 ampere/hour maximum domestic battery bank size. 17. Control Panel All Shanks engines are supplied with high quality engine control panel that all show RPM and hours run and include warning lights and a warning buzzer, the deluxe panels also have gauges for water temp, oil pressure and 160A battery charging. The panels are designed to be splash proof and are correctly installed with the gauges vertical. RDG6039484 Shanks10 Owners Manual Issue 1 Page 17 of 51
Page 1 and 2: SHANKS CANAL BOAT ENGINE MANUAL For
Page 3 and 4: 5. Primary Fuel Filter Change .....
Page 5 and 6: PLEASE NOTE: This manual has been c
Page 7 and 8: 6. Batteries WARNING: EXPLOSIVE GAS
Page 9 and 10: SECTION 3 - Installation 1. Ventila
Page 11 and 12: engine, along with the 10mm packing
Page 13 and 14: 9. Engine Alignment • The gearbox
Page 15: pump lift pump (see Figure 11 page
Page 19 and 20: • Visually check the engine for o
Page 21 and 22: Filler Cap Air Vent to Header Tank.
Page 23 and 24: element simply pulls out. • The a
Page 25 and 26: 4. Primary Fuel Filter Water Drain
Page 27 and 28: • Clean up any spilt fuel and dry
Page 29 and 30: hand, to guide the new belt into th
Page 31 and 32: 15. Gearbox Hydraulic Oil Filter (S
Page 33 and 34: when observed from the front of the
Page 35 and 36: SECTION 6 - Service Schedule Specif
Page 37 and 38: SECTION 7 - Shanks Engine Specifica
Page 39 and 40: SECTION 8 - Wiring Diagrams Harness
Page 41 and 42: Panel Wiring Diagram RDG6039484 Sha
Page 43 and 44: SECTION 9 - General Arrangements Sh
Page 45 and 46: Shanks10 35 RDG6039484 Shanks10 Own
Page 47 and 48: Shanks10 40 RDG6039484 Shanks10 Own
Page 49 and 50: Shanks Instrument Panels Engine ove
Page 51: SECTION 11 - Shanks Service Parts E

Shanks Owners manual (10 Build) 30, 30H, 35, 35H, 40 ... - EP Barrus

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?