Installation Manual C15, C20, C25 - Waltco

More documents

Recommendations

Info

Chapter 4 Basic power down liftgate wiring Installation GR02904 Hydraulic Schematic Power Down Lowering Speed Flow Control Valve (pressure compensated) Hydraulic Cylinder Lowering Solenoid Valve Pump/Reservoir Raise Solenoid Valve GR02596 Page 20
Chapter 4 HOSE INSTALLATION Avoid twisting of hoses. Avoid sharp bends when routing hoses Hoses will contract under pressure. Allow plenty of slack between connecting points. Do not clamp hoses at bends to allow for length changes when hose is pressurized. Installation High Pressure No Pressure GR00717 FILLING HYDRAULIC RESERVOIR Position liftgate deck per chart below (use forklift, crane, or other safe device). Remove Reservoir Plug. of reservoir. If low, fill as required. Use appropriate fluid per chart. Replace Plug. Run liftgate full cycle several times to release trapped air from system. Plug GR02130 LIFTGATE POSITION FOR OIL LEVEL CHECK Gravity Down Pump: Power Down Pump: Deck should be in this position: Ground Level Bed Level Recommended Fluids Fill reservoir Temperature Range Acceptable Fluids Fill with recommended fluid or equivalent. 0 to 120 F Waltco Biodegradable Liftlube TM part #85803860 F Fluids are available from the Waltco parts Shell Tellus S2 V 32 Dept. 1-800-411-5685 www.waltco.com Chevron AW32 -20 to 90 F Waltco Biodegradable LiftLube Arctic part #85803866 NOTE: Do not use the following fluids: Shell Tellus S2 V 15 Mobil DTE 13 Brake Fluid Power steering fluid MIL H - 5606 Automatic Transmission Fluid (ATF) A good quality SAE 10W motor oil may also be used in temperatures above 32 F. Page 21
Page 1 and 2: www.waltco.com Phone: 800.411.5685
Page 3 and 4: Introduction If anyone observes imp
Page 5 and 6: Liftgates with Tilt Function Proper
Page 7 and 8: Chapter 2 Liftgate Terminology 15.
Page 9 and 10: Chapter 3 BASIC MOUNTING REQUIREMEN
Page 11 and 12: Chapter 4 Installation PREPARATION
Page 13 and 14: Chapter 4 Installation Position lif
Page 15 and 16: Chapter 4 MOUNT PLATE INSTALLATION
Page 17 and 18: Chapter 4 INSTALLATION OF CONTROLS
Page 19: Chapter 4 DIVERT WATER FROM ENCLOSU
Page 23 and 24: Chapter 4 Installation For C-25 Onl
Page 25 and 26: Chapter 4 NOTE: If properly install
Page 27 and 28: Chapter 4 OPTIONAL SUPER DUTY DOCK
Page 29 and 30: 02-09 TRANS IT CHAIN 8010151 7 Chap
Page 31 and 32: Ch 7. FINAL INSPECTION SHEET IMPORT
Page 33 and 34: Hand Held Remote Installation DRILL
Page 35 and 36: BATTERY KIT INSTALLATIONS 80101387
Page 37 and 38: BATTERY KIT INSTALLATIONS 80101387
Page 39 and 40: Page 39
Page 41 and 42: Date:8-23-2010 No. TT100006 Model:
Page 43 and 44: INSTALL RUBBER SNUBBERS Raise Platf
Page 45 and 46: Page 45
Page 47 and 48: Every vehicle that has a WALTCO Lif

Installation Manual C15, C20, C25 - Waltco

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?