to download CV, PSV, LCV, Agricultural & Plant Catalogue - Yuasa

Health & Safety InformationHandling and the proper use of Lead Acid Batteries are not hazardous providing sensibleprecautions are observed, appropriate facilities are available and personnel have been givenadequate training.In accordance with the Consumer Protection Act 1987, the purpose of this guide is to :-1. Indicate the main hazards which may arise2. Outline the precautions to be taken to minimise such hazards3. Indicate the emergency actions to be taken in the event of the occurrence of a hazardA - Label InformationThe following symbols are being used on all batteries andmean the following:Note Operating InstructionsShield eyes – eye protection must be wornB - Battery AcidThe HazardBatteries contain Sulphuric Acid which may leak for variousreasons. Also acid may be given off as droplets and/or spray/mist during recharge.Sulphuric Acid is a corrosive and poisonous liquid which willcause burns and irritation to the skin and eyes and couldseverely damage clothing.Refer to Health & Safety Executive Guidance Note EH40 for thelatest occupational exposure limits for acid mist in air.InformationKeep away from childrenBattery acid – corrosive and poisonousNo smoking – no naked flames – no sparksExplosive gasesContains leadNever dispose of as domestic waste – take toa designated waste reclamation sitePrecautions• Always handle batteries with care• Never overfill with acid• Always store upright• Never allow children access to a battery• Always charge in a well ventilated area• Never allow battery vents to become blocked• Always wear eye protection• Always wear protective clothingAccident or Emergency Actionand TreatmentSkin contact –Immediately soak the affected area with copious amounts ofclean water, remove any contaminated clothing and seek medicalattention if irritation persists.Eye contact –Immediately irrigate eyes for at least 10 minutes with cleanwater, seek medical attention.Ingestion –Immediately drink as much water as possible – do NOT inducevomiting, seek urgent medical attention.Spillages –For small spillages wash away with large quantities of water.For larger volumes dispose of in suitable acid resistantcontainers, clearly labelled – see section H.Battery is recyclable – follow local recycling& reclaiming procedures518