- Page 1:
GTS 250 JOYMAX 250 SERVICE MANUAL F
- Page 5:
Serial Number Home page Contents
- Page 9 and 10:
1. General Information � The leng
- Page 11 and 12:
1. General Information � When sep
- Page 13:
1. General Information � Do not l
- Page 17 and 18:
1. General Information Troubles Dia
- Page 19 and 20:
1. General Information C. Engine ru
- Page 21:
1. General Information Lubrication
- Page 26:
Primary adjustment is conducted fro
- Page 31 and 32:
2. Maintenance Information Steering
- Page 33:
2. Maintenance Information Brake Li
- Page 37 and 38:
2. Maintenance Information NAME Inn
- Page 39 and 40:
2. Maintenance Information Note: 2-
- Page 41:
3. Lubrication System Precautions i
- Page 46 and 47:
Gear Oil Gear Oil Change Remove oil
- Page 48 and 49:
Mechanism Diagram .................
- Page 50:
Trouble Diagnosis Poor engine start
- Page 55:
4. Fuel System Float Chamber Disass
- Page 59 and 60:
4. Fuel System Remove fuel tank upp
- Page 61 and 62:
4. Fuel System Air Cleaner Removal
- Page 63 and 64:
5. Removal & Installation of Engine
- Page 65 and 66:
5. Removal & Installation of Engine
- Page 67 and 68:
5. Removal & Installation of Engine
- Page 69 and 70:
5. Removal & Installation of Engine
- Page 71 and 72:
5. Removal & Installation of Engine
- Page 74:
6. Cylinder Head / Valve Troublesho
- Page 78: Remove valve cotters, spring retain
- Page 84: After the valve seat ground, coat v
- Page 88: Mechanism Diagram ········
- Page 91: 7. Cylinder / Piston Check cylinder
- Page 94: Piston Installation Install piston
- Page 97 and 98: 8. V-Belt Driving System Maintenanc
- Page 99: 8. V-Belt Driving System Left crank
- Page 102 and 103: Drive Face Removal Remove left cran
- Page 104 and 105: With 4~5g grease spreads wipes driv
- Page 106 and 107: Clutch lining Measure each clutch w
- Page 108 and 109: Install snap ring and mounting plat
- Page 110 and 111: Mechanism Diagram·········
- Page 112 and 113: Disassembly of Final Driving Mechan
- Page 114 and 115: Bearing Replacement Left crankcase
- Page 116 and 117: Install new final shaft bearing and
- Page 118 and 119: Mechanism Diagram·········
- Page 120 and 121: Right Crankcase Cover Removal Remov
- Page 122 and 123: Flywheel Removal Remove right crank
- Page 124 and 125: Remove the starting gear Loosen 3 s
- Page 126 and 127: AC.G. Set Installation Install the
- Page 130 and 131: Disassembly of Crankcase Remove the
- Page 132 and 133: Measure the clearance of the big en
- Page 134 and 135: Hold left crank shaft puller, and t
- Page 136: Mechanism Diagram ········
- Page 141 and 142: 12. Cooling System Check reserve ta
- Page 143 and 144: 12. Cooling System Water Pump Check
- Page 145 and 146: 12. Cooling System Install the new
- Page 147: 12. Cooling System Thermostat Pleas
- Page 150 and 151: Mechanism Diagram·········
- Page 152 and 153: Handle Cover Remove Loosen the 2 sc
- Page 154 and 155: Loosen 2 bolts from the front cover
- Page 156 and 157: Inner Box Remove Remove wind screen
- Page 158 and 159: Side Cover Remove Loosen 2 screws f
- Page 160 and 161: Luggage Box Remove Open the seat. L
- Page 162 and 163: Floor Panel Remove Remove wind scre
- Page 164: Mechanism Diagram·········
- Page 167 and 168: 14. Brake System Disk Brake System
- Page 169 and 170: 14. Brake System Brake fluid replac
- Page 171 and 172: 14. Brake System Rear Brake Caliper
- Page 173 and 174: 14. Brake System Remove the rubber
- Page 175 and 176: 14. Brake System Note: 14-12 To thi
- Page 178 and 179:
Steering Handle Remove Remove the r
- Page 180 and 181:
Front Wheel Loosen 2 bolts from the
- Page 182 and 183:
Assembly Fill out the block of bear
- Page 184 and 185:
Steering Stem Remove Remove handle,
- Page 186 and 187:
Mechanism Diagram·········
- Page 188 and 189:
Muffler Removal Loosen the 2 nuts f
- Page 190 and 191:
Rear Fork Inspection rear fork bear
- Page 192 and 193:
Mechanism Diagram ········
- Page 194:
Trouble Diagnosis No voltage � Ba
- Page 198 and 199:
Inspection on AC. Generator coil Re
- Page 201 and 202:
17. Electrical System Inspection on
- Page 203 and 204:
17. Electrical System Disconnect th
- Page 205 and 206:
17. Electrical System Removal of me
- Page 207 and 208:
17. Electrical System Replacement h
- Page 209:
17. Electrical System Replacement t
- Page 212:
Fuel Unit Open the seat. Remove the
- Page 216 and 217:
Home page Contents 18. Electrical D