Burnham V8 Series Instructions.pdf - Heating Help

More documents

Recommendations

Info

SECTION III: PACKAGED BOILER ASSEMBLYA. REMOVE CRATE.1. Remove all fasteners at crate skid.2. Lift outside container and remove all other insideprotective spacers and bracing. Remove draftregulator box and miscellaneous trim bag containingsafety or relief valve, and pipe fittings.B. REMOVE BOILER FROM SKID.1. Boiler is secured to base with 4 bolts, 2 in front and2 in rear of shipping skid, see Figure 11. Remove allbolts.Figure 11: Packaged Boiler Removal from Skid2. Tilt boiler to right and to rear. Using right rear leg aspivot, rotate boiler 90° in a clockwise direction, andlower left side of boiler to floor. Tilt boiler andremove crate skid. Care should be exercised toprevent damage to jacket or burner.CAUTIONDo not drop boiler. Do not bump boilerjacket against floor.C. MOVE BOILER TO PERMANENT POSITIONby sliding or walking.D. PROCEDURE TO OPEN, CLOSE AND SECUREBURNER SWING DOOR with articulated hinge.Throughout this manual you will be instructed to openand close the burner swing door for various reasons.There is a proper and improper method to closing andsecuring the burner swing door after it has beenremoved and re-installed for Field Assembly(Knockdown Boiler) or opened for inspection, cleaningor field service.1. TO OPEN BURNER SWING DOOR (see Figures11A and 11B).Step 1. Loosen and remove right side latchinghardware (5/16" flange nut and washer).Step 2. Loosen and remove left side hinge hardware(5/16" x 3-1/2" lg. hex head flange bolt).Step 3. The duel pivot articulated hinge allows rightside of door to be pulled outward and rotated tothe left all in one motion. To do so, place yourright hand under burner air tube and lift upslightly to help carry the weight of the door andburner. Use your left hand to grasp the door'sleft side hinge flange, pull outward to rotate thehinge, this motion will move the door outwardand to the left approximately 3" (see Figure 11B,Position 2).Figure 11A: Partial Front View - Burner Swing Door Mounted to Boiler - Fully Closed and Secured20
21Figure 11B: Top View - Burner Swing Door Mounted to Cast Iron Block Assembly (Jacket Removed for Clarity)
Page 1: INSTALLATION, OPERATING ANDSERVICE
Page 4 and 5: 4WARNINGpipeanyunscrewnotDopressure
Page 6 and 7: 6Figure 1A: V82 thru V89 Water Boil
Page 8 and 9: 8Figure 1C: V83 thru V89 Water Boil
Page 10 and 11: A. INSPECT SHIPMENT carefully for a
Page 12 and 13: SECTION II: KNOCKDOWN BOILER ASSEMB
Page 14 and 15: H. INSTALL TRIM. The following stea
Page 16 and 17: NOTICEWhen securing burner swing do
Page 18 and 19: 8. Connect the field wiring to the
Page 22 and 23: Step 4. From this position the door
Page 24 and 25: SECTION IV: WATER BOILER PIPING AND
Page 26 and 27: 26Figure 13A: Water Boiler Piping f
Page 28 and 29: 28Figure 13C: Optional Water Boiler
Page 30 and 31: Figure 14: V83 Thru V89 Recommended
Page 32 and 33: Figure 15A: Schematic Tankless Heat
Page 34 and 35: SECTION VII: VENTING AND AIR INTAKE
Page 36 and 37: 2. After determining location, cut
Page 38 and 39: Figure 19: Wiring Diagram, Steam, S
Page 40 and 41: Figure 21: Wiring Diagram, Steam, O
Page 42 and 43: Figure 23A: Wiring Diagram, Water w
Page 44 and 45: SECTION IX: OIL PIPINGA. GENERAL1.
Page 46 and 47: SECTION X: SYSTEM START-UPWARNINGAl
Page 48 and 49: the bleeder port or the nozzle port
Page 50 and 51: a. FEATURES AND CONTROLSi. The R718
Page 52 and 53: LOW LIMIT OPERATION —On a tempera
Page 54 and 55: SECTION XI: MAINTENANCE AND SERVICE
Page 56 and 57: testing with hydrion paper which is
Page 58 and 59: SECTION XII: BOILER CLEANINGWARNING
Page 60 and 61: A. COMBUSTION1. NOZZLES — Althoug
Page 62 and 63: 62Bare Boiler Assembly
Page 64 and 65: 64Bare Boiler Assembly (Continued)
Page 66 and 67: 66Jacket Assembly
Page 68 and 69: V83 Thru V89 Steam Boilers - Trim a
Page 70 and 71:
V82 Thru V89 Water Boilers - Trim a
Page 72 and 73:
72Beckett AFG Burner
Page 74 and 75:
BECKETT OIL BURNER PART NOS. FOR V8
Page 76 and 77:
DATESERVICE RECORDSERVICE PERFORMED
Page 78 and 79:
DATESERVICE RECORDSERVICE PERFORMED
Page 80:
Limited WarrantyFOR RESIDENTIAL CAS
show all

Burnham V8 Series Instructions.pdf - Heating Help

Create successful ePaper yourself

Delete template?

Save as template?