Burnham V8 Series Instructions.pdf - Heating Help

More documents

Recommendations

Info

Figure 15A: Schematic Tankless Heater PipingTABLE 2A: TANKLESS HEATER DATA:Rear Mounted Heater on Steam and Water BoilersBoilerModelHeaterNo.Heater Rating(GPM)SteamWaterPressure Dropthru Heater(PSI)SteamWaterV83V1-22.753 3.9 4. 7V84V1-23 3.254.7 5. 6V85V1-23.253.5 5.6 6. 4V86V1-23.753.757.2 7. 2V87V1-23.754 7.2 8V88V1-24 4.5 8 9. 8V89V1-24 4.5 8 9. 832TABLE 2B: TANKLESS HEATER DATA:Front Mounted Heater on Water BoilersBoilerModelV83V84V85V86V87V88V89HeaterNo.HeaterRating(GPM)Pressure DropThru Heater(PSI)222A3 22222A3.522222A4 30. 5222A4.533222A4.633A545.536222A4.7540A546 39. 5222A4.7540A546 39. 5
Figure 15B: Alliance Water Heater Piping with V8 BoilerB. CONNECT ALLIANCE INDIRECT WATERHEATER PIPING as shown in Figure 15B.1. Refer to Alliance manual for additionalinformation.33
Page 1: INSTALLATION, OPERATING ANDSERVICE
Page 4 and 5: 4WARNINGpipeanyunscrewnotDopressure
Page 6 and 7: 6Figure 1A: V82 thru V89 Water Boil
Page 8 and 9: 8Figure 1C: V83 thru V89 Water Boil
Page 10 and 11: A. INSPECT SHIPMENT carefully for a
Page 12 and 13: SECTION II: KNOCKDOWN BOILER ASSEMB
Page 14 and 15: H. INSTALL TRIM. The following stea
Page 16 and 17: NOTICEWhen securing burner swing do
Page 18 and 19: 8. Connect the field wiring to the
Page 20 and 21: SECTION III: PACKAGED BOILER ASSEMB
Page 22 and 23: Step 4. From this position the door
Page 24 and 25: SECTION IV: WATER BOILER PIPING AND
Page 26 and 27: 26Figure 13A: Water Boiler Piping f
Page 28 and 29: 28Figure 13C: Optional Water Boiler
Page 30 and 31: Figure 14: V83 Thru V89 Recommended
Page 34 and 35: SECTION VII: VENTING AND AIR INTAKE
Page 36 and 37: 2. After determining location, cut
Page 38 and 39: Figure 19: Wiring Diagram, Steam, S
Page 40 and 41: Figure 21: Wiring Diagram, Steam, O
Page 42 and 43: Figure 23A: Wiring Diagram, Water w
Page 44 and 45: SECTION IX: OIL PIPINGA. GENERAL1.
Page 46 and 47: SECTION X: SYSTEM START-UPWARNINGAl
Page 48 and 49: the bleeder port or the nozzle port
Page 50 and 51: a. FEATURES AND CONTROLSi. The R718
Page 52 and 53: LOW LIMIT OPERATION —On a tempera
Page 54 and 55: SECTION XI: MAINTENANCE AND SERVICE
Page 56 and 57: testing with hydrion paper which is
Page 58 and 59: SECTION XII: BOILER CLEANINGWARNING
Page 60 and 61: A. COMBUSTION1. NOZZLES — Althoug
Page 62 and 63: 62Bare Boiler Assembly
Page 64 and 65: 64Bare Boiler Assembly (Continued)
Page 66 and 67: 66Jacket Assembly
Page 68 and 69: V83 Thru V89 Steam Boilers - Trim a
Page 70 and 71: V82 Thru V89 Water Boilers - Trim a
Page 72 and 73: 72Beckett AFG Burner
Page 74 and 75: BECKETT OIL BURNER PART NOS. FOR V8
Page 76 and 77: DATESERVICE RECORDSERVICE PERFORMED
Page 78 and 79: DATESERVICE RECORDSERVICE PERFORMED
Page 80: Limited WarrantyFOR RESIDENTIAL CAS

Burnham V8 Series Instructions.pdf - Heating Help

Create successful ePaper yourself

Delete template?

Save as template?