Owner's Manual - At Andiron Fireplace Shop

More documents

Recommendations

Info

3Maintainance and ServiceA. Disposal of AshesFrequency: When they reach bottom of grateBy: HomeownerWARNING! Risk of Fire! Ashes could contain hot embers.• Place ashes in a metal container with a tight-fi tting lid.• The closed container should be placed on a noncombustiblefl oor or on the ground, well away from all combustiblematerials, pending fi nal disposal.• If the ashes are disposed of by burial in soil or otherwiselocally dispersed, they should be retained in the closedcontainer until all cinders have thoroughly cooled.B. Chimney Inspection/CleaningFrequency: <strong>At</strong> least twice a year during heating season oras recommended by a certifi ed chimney sweepBy: Certifi ed chimney sweepWARNING! Risk of Fire! Ignited creosote is extremelyHOT. Prevent creosote buildup.Refer to Figure 3.1 to remove/reinstall termination caps.Creosote - Formation and Need for RemovalWhen wood is burned slowly, it produces tar and otherorganic vapors, which combine with expelled moisture toform creosote. The creosote vapors condense in the relativelycool chimney fl ue of a slow-burning fi re. As a result,creosote residue accumulates on the fl ue lining. Whenignited this creosote makes an extremely hot fi re.WARNING! Risk of Fire! A chimney fi re can permanentlydamage your chimney system and nearby structures.In the event of a chimney fi re, Hearth & Home TechnologiesInc. recommends• replacement of the chimney, and• inspection of the adjacent structure to the provisions ofNFPA Level III inspection criteriaThe chimney shall be inspected at least twice a year duringthe heating season to determine when a creosote builduphas occurred.When creosote has accumulated it shall be removed toreduce the risk of a chimney fi re.Remove screws,lift top cover.Top CoverRemove 4 screwsand lift top pan off.Remove 2 screws fromthe front and back andlift the top off.CapCapChimneySlipSectionTR11/TR11T/TR11-TVRound Termination CapST1175Square Termination CapTCT1175Terra CottaTermination CapFigure 3.110Chimney & Termination Cap CleaningHeatilator • Birmingham BIR42 • 4059-308 Rev C • 07/08
C. Check Firebox Molded Brick PanelFrequency: After each ash removalBy: HomeownerWARNING! Risk of Fire! Inspect fi replace molded brickpanel. Crumbling, deteriorated molded brick panel can allowoverheating of surrounding materials.Expansion and contraction will cause minor cracking of themolded brick panel. This is normal. The panel will requireperiodic replacement depending on use.The panels should be replaced if• Cracks exceed ¼ inch (6 mm) in width,• Metal is exposed behind a panel,• Large pieces of panel fall out.D. Inspect GrateFrequency: After each ash removalBy: HomeownerInspect grate for:• Warping or sagging 1-1/2 in. (38 mm) or more• Broken welds• Burn-through of grate barsFor safe operation, replace only with the approved gratefrom Hearth & Homes Technologies Inc.E. Glass CleaningFrequency: As desiredBy: HomeownerCAUTION! Handle glass assembly with care. Glass isbreakable.• Avoid striking, scratching or slamming glass• Avoid abrasive cleaners• Do not clean glass while it is hotClean glass with a non-abrasive commercially availablecleaner or ashes:• Light deposits- Use household glass cleaner• Heavy deposits- Use wood ash on damp cloth or,- Use commercial fi replace glass cleaner (consult withyour dealer)Heatilator • Birmingham BIR42 • 4059-308 Rev C • 07/0811
Page 1: Owner’s ManualInstallation and Op
Page 5 and 6: 1Listing and Code ApprovalsA. Appli
Page 7 and 8: B. Seasoned WoodProperly seasoned w
Page 9: M. Wood FuelHardwood vs SoftwoodYou
Page 13 and 14: 5Getting StartedA. Typical Fireplac
Page 16: F. Tools and Supplies NeededBefore
Page 19 and 20: C. Sidewalls/Surrounds• Locate ad
Page 21 and 22: 3 ft min. fromtop of uppermostchimn
Page 23 and 24: 8Chimney AssemblyNOTICE: Chimney pe
Page 25 and 26: B. Using Offsets/Returns• Use an
Page 27 and 28: D. Install Ceiling FirestopsCAUTION
Page 29 and 30: F. Cut Out Hole in Roof• Refer to
Page 31 and 32: 9Chase InstallationsA. Construct th
Page 33 and 34: D. Install Termination CapInstall t
Page 35 and 36: 10 ShroudsA. Radiation Shield• So
Page 37 and 38: 11Installation of Molded Brick Pane
Page 39 and 40: F. Install MortarNote: Mortar is ap
Page 42 and 43: Non-combustible SealantAfter comple
Page 44 and 45: E. Combustible Mantel• See Figure
Page 46 and 47: 13 AccessoriesA. Gas Log/Lighter Pr
Page 48 and 49: B. Optional Components66 in.(1676 m
Page 50 and 51: InsideDiameter11 in.(279 mm)A21 in.
Page 52 and 53: 13-3/8 in.(340 mm)72 in.(1829 mm)36
Page 54 and 55: D. Service PartsService PartsBIR421
Page 56: E. Contact InformationHearth & Home

Owner's Manual - At Andiron Fireplace Shop

Create successful ePaper yourself

Delete template?

Save as template?