Owner's Manual - At Andiron Fireplace Shop

More documents

Recommendations

Info

13 AccessoriesA. Gas Log/Lighter ProvisionWARNING! Fire and/or Asphyxiation Risk! Use with solidwood fuel or decorative gas appliance only. Gas fi re generatesfumes.• DO NOT install unvented gas logs• Damper must be locked fully open when gas logs areinstalledA certifi ed gas log lighter or decorative gas log set can beinstalled in this fi replace.• Maximum input is 150,000 BTU/hr.• Decorative gas appliance must be certified to ANSI Z21.60“Standard for Decorative Gas Appliances for Installationin Vented Fireplaces”.• Must be installed in accordance with the National FuelGas Code, ANSI Z223.1.• A gas log set must incorporate a gas shutoff.• Gas log set requires the damper to be locked fully open. • A listed automatic damper system with safety interlock maybe used in this fireplace with only compatible, listed gas logsets. See damper system manufacturer’s instructions.• Knockouts are provided on both sides of the fi replace for1/2 in. (13 mm) iron pipe.• A locating dimple (see Figure 13.2) is located on both sidesof the fi replace in the molded brick panels for drilling a 1in. (25 mm) diameter hole for installation of a gas line.After the panel is installed, drill the hole for the gas line.• Seal panel around pipe with fi replace mortar or a hightemperature, noncombustible sealant.B. Wood Burning InsertsWARNING! Risk of Fire! Improper installation of woodinserts may cause fi replace or chimney system to overheat.If a wood burning insert is being installed in this fi replace,Hearth & Home Technologies recommends full reline of thechimney.• Cooling air openings at the top of the chimney must notbe obstructed in any manner.• Hearth & Home Technologies recommends securing thereline at the top of the flue and using the cap certifi ed foruse with this fi replace system.RefractoryFireboxSeal withfireplace mortaror non-combustiblesealantGas LineRepackInsulationKnockoutOuter Shellof FireplaceMaintain air clearanceto combustibles.Gas Line4 in.(102 mm)Figure 13.1 Gas Line InstallationCombustibleMaterials1 1/2 in. (38 mm)air space aroundpipeCombustible materialsmay be located at zeroclearance to gas linebeyond 4 in. (102 mm)from fireplace side.Gas LineDimpleGas LineDimpleFigure 13.2 Gas Line Dimples46Heatilator • Birmingham BIR42 • 4059-308 Rev C • 07/08
14Reference MaterialsA. Fireplace Dimensions37 1/8 in.943 mm11 in.281 mm74° TYP.27 1/2 in.699 mm97 1/2in.2477 mm74 1/8 in.1883 mmGas LineKnockout54 in.1372 mm70 3/4 in.1797 mmGas LineKnockout5 in.129 mm6 7/8 in.175 mm38 in.965 mm6 7/8 in.175 mm5 in.129 mm16 1/8 in.408 mm11 1/8 in.282 mm42 in.1067 mm52 7/8 in.1343 mm3 3/4 in.97 mm11 1/8 in.282 mm16 1/8 in.408 mmHeatilator • Birmingham BIR42 • 4059-308 Rev C • 07/0847
Page 1: Owner’s ManualInstallation and Op
Page 5 and 6: 1Listing and Code ApprovalsA. Appli
Page 7 and 8: B. Seasoned WoodProperly seasoned w
Page 9 and 10: M. Wood FuelHardwood vs SoftwoodYou
Page 11 and 12: C. Check Firebox Molded Brick Panel
Page 13 and 14: 5Getting StartedA. Typical Fireplac
Page 16: F. Tools and Supplies NeededBefore
Page 19 and 20: C. Sidewalls/Surrounds• Locate ad
Page 21 and 22: 3 ft min. fromtop of uppermostchimn
Page 23 and 24: 8Chimney AssemblyNOTICE: Chimney pe
Page 25 and 26: B. Using Offsets/Returns• Use an
Page 27 and 28: D. Install Ceiling FirestopsCAUTION
Page 29 and 30: F. Cut Out Hole in Roof• Refer to
Page 31 and 32: 9Chase InstallationsA. Construct th
Page 33 and 34: D. Install Termination CapInstall t
Page 35 and 36: 10 ShroudsA. Radiation Shield• So
Page 37 and 38: 11Installation of Molded Brick Pane
Page 39 and 40: F. Install MortarNote: Mortar is ap
Page 42 and 43: Non-combustible SealantAfter comple
Page 44 and 45: E. Combustible Mantel• See Figure
Page 48 and 49: B. Optional Components66 in.(1676 m
Page 50 and 51: InsideDiameter11 in.(279 mm)A21 in.
Page 52 and 53: 13-3/8 in.(340 mm)72 in.(1829 mm)36
Page 54 and 55: D. Service PartsService PartsBIR421
Page 56: E. Contact InformationHearth & Home

Owner's Manual - At Andiron Fireplace Shop

Create successful ePaper yourself

Delete template?

Save as template?