Owner's Manual - At Andiron Fireplace Shop

More documents

Recommendations

Info

Mailbox Style Shroud (radiation shield required)Min. Heightabove radiationshieldMin.Base Dim3 in. (76 mm)Min. Opening HeightMin. Base DimMin. Opening WidthTR11/11T TR11/11T TVMin. Base Dims.in 34 x 34 28 x 30mm 864 x 864 711 x 762Min. Height Above Radiation Shieldin 21-1/4 20-1/2mm 540 521Min. Opening Widthin 28 x 28 22 x 24mm 711 x 711 559 x 6103 in. (76 mm) Min.Radiation Shield Heightfrom top of ChaseFigure 10.3 Mailbox Style Shroud DimensionsRoofed Style Shroud (Radiation Shield Required)3 in. (76 mm)RadiationShield HeightMinimumHeight aboveRadiation ShieldTerminationCapRadiation ShieldChase TopMin. Base DimensionMinimumOpeningHeightMinimumBase DimensionMin. Opening WidthTR11/11T TR11/11T TVMin. Base Dims.in 34 x 34 34 x 34mm 864 x 864 864 x 864Min. Height Above Radiation Shieldin 16 16mm 406 406Min. Opening Widthin 28 28mm 711 711Min. Opening Heightin 12 12mm 305 305Figure 10.4 Roofed Style Shroud Dimensions36Heatilator • Birmingham BIR42 • 4059-308 Rev C • 07/08
11Installation of Molded Brick PanelA. Install Hearth Molded Brick Panel• Place hearth panel into the fi replace.B. Install Side Molded Brick Panel/Traditional• If a gas line is to be installed, remove the knockouts inthe inner fi rebox and in the outer shell on the side ofyour choice. Refer to dimension drawings for location ofknockouts and Section 13.A. for gas provisions.• Do NOT remove screen rods.• Refer to Figure 11.1.• Install lower side panel, tapered edge to the front. Alignthe front edge with the front of the column (or butted tothe surround if installed).• Install two T-brackets stem down into mortar line, do nottighten.• Install upper side panel in the unit, tapered edge tothe front. Position the bottom of panel behind the T-brackets.• Install two T-brackets stem up into mortar lines, one onits side on the front edge, do not tighten.• Install two Z-brackets in the mortar lines across the top.Tighten these and all previously installed brackets.• Install second side panel following the steps above.Note: Use T-brackets as templates and drill pilotholes into the inner shell with the drill bit provided.Side panels must be installed fi rst.C. Install Back Molded Brick Panel/Traditional• Refer to Figure 11.1.• Set the grate brackets in place, 26.5 in. (673 mm) centerto center.• Install the lower back panel. Center from side to side.• Install three T-brackets stem down into mortar line to holdlower back in position. Do not tighten.• Install upper back panel. Position bottom of panel behindthe previously installed T-brackets.• Install two T-brackets stem side up into mortar line, do nottighten• Install two Z-brackets in the mortar lines across the top.Tighten these and all previously installed brackets.FrontUpper SideMolded Brick PanelUpper BackMolded Brick PanelRight SideMolded Brick Panelremoved forclarityLower SideMolded Brick PanelLower BackMolded Brick PanelHearth Molded Brick PanelFigure 11.1 Traditional Molded Brick PanelHeatilator • Birmingham BIR42 • 4059-308 Rev C • 07/0837
Page 1: Owner’s ManualInstallation and Op
Page 5 and 6: 1Listing and Code ApprovalsA. Appli
Page 7 and 8: B. Seasoned WoodProperly seasoned w
Page 9 and 10: M. Wood FuelHardwood vs SoftwoodYou
Page 11 and 12: C. Check Firebox Molded Brick Panel
Page 13 and 14: 5Getting StartedA. Typical Fireplac
Page 16: F. Tools and Supplies NeededBefore
Page 19 and 20: C. Sidewalls/Surrounds• Locate ad
Page 21 and 22: 3 ft min. fromtop of uppermostchimn
Page 23 and 24: 8Chimney AssemblyNOTICE: Chimney pe
Page 25 and 26: B. Using Offsets/Returns• Use an
Page 27 and 28: D. Install Ceiling FirestopsCAUTION
Page 29 and 30: F. Cut Out Hole in Roof• Refer to
Page 31 and 32: 9Chase InstallationsA. Construct th
Page 33 and 34: D. Install Termination CapInstall t
Page 35: 10 ShroudsA. Radiation Shield• So
Page 39 and 40: F. Install MortarNote: Mortar is ap
Page 42 and 43: Non-combustible SealantAfter comple
Page 44 and 45: E. Combustible Mantel• See Figure
Page 46 and 47: 13 AccessoriesA. Gas Log/Lighter Pr
Page 48 and 49: B. Optional Components66 in.(1676 m
Page 50 and 51: InsideDiameter11 in.(279 mm)A21 in.
Page 52 and 53: 13-3/8 in.(340 mm)72 in.(1829 mm)36
Page 54 and 55: D. Service PartsService PartsBIR421
Page 56: E. Contact InformationHearth & Home

Owner's Manual - At Andiron Fireplace Shop

Create successful ePaper yourself

Delete template?

Save as template?