Hawke Transit System catalogo

More documents

Recommendations

Info

EMC TRANSIT SYSTEM INSTALL ATION GUIDEEMC TransitSystemThe following diagrams explain step by step how easy it is to installEMC Hawke cable/pipe tolerant blocks into EMC Transit frames.1Draw up a Hawke Design Templateto determine your cable/pipelayout.2Make sure the frame is clean, thenpull cables or pipes through,placingthe largest at the bottom. (Note: Useopen ended frame to fit around existingcables/pipes).3Mark each cable in the centre ofthe frame and 7-8mm either side ofthis point.4Cut and remove cable sheathbetween two outside marks, toexpose the cables conductive screen.5 6Using copper tape provided tightlywrap around the exposed screenuntil the cable outer diameter isregained. Repeat steps 3, 4 & 5 for allcables.Very slightly lubricate the insertblocks taking care not tocontaminate the copper tape on blockor cable.7Ensure when fitting cables intoblocks that the copper tapes onblock and cable align.8Begin packing the frame.A stayplate is inserted betweeneach layer of insert blocks.9Insert the compression platebefore the last row of blocksor earlier if required with additionalstayplates.Pack the last row, insert10the compression tool and 1112tighten until there is sufficient roomto fit the tapered end packers.Insert two outside packing piecesthen remove tool before fittingcentre block.Tighten the nuts on theendpacking to compress andcomplete the seal. Approximately 10mmof thread should protrude on each bolt.If possible after completion the assembly should be tested for conductivity34www.hawke-hts.com
F O R C A B L E S A N D P I P E SHawkeTransit SystemMARINE AND CIVIL FRAME SIZESROUND FRAME SIZESwww.hawke-hts.com35
Page 2 and 3: H A W K E R O U N D , M A R I N E A
Page 4 and 5: WHAT IS A CABLE TRANSIT SYSTEM?A Tr
Page 6 and 7: TOLERANT BLOCK SIZE RANGEThis enabl
Page 8 and 9: SELECTION AND SPECIFICATION PROCEDU
Page 10 and 11: COMPRESSION SYSTEM COMPONENTSCompre
Page 12 and 13: H A W K E C I V I L T R A N S I T S
Page 14 and 15: C I V I L T R A N S I T S Y S T E M
Page 16 and 17: C I V I L F R A M E - D I M E N S I
Page 18 and 19: C I V I L T R A N S I T S Y S T E M
Page 20 and 21: H A W K E M A R I N E T R A N S I T
Page 22 and 23: MARINE FRAME INSTALLATION INSTRUCTI
Page 24 and 25: M U L T I P L E F R A M E A P PFRAM
Page 26 and 27: MARINE FRAME - DIMENSIONAL DATA26ww
Page 28 and 29: 28H A W K E R O U N D T R A N S I T
Page 30 and 31: T R A N S I T I N S T A L L A T I O
Page 32 and 33: T H E H A W K E E M C T R A N S I T
Page 36: HAWKE TRANSIT SYSTEM - HTSHead Offi

Hawke Transit System catalogo

Create successful ePaper yourself

Delete template?

Save as template?