Download Installation Manual (.pdf) - Heat Transfer Products, Inc

More documents

Recommendations

Info

20Anti-scald mixing valve:Field supplied. A thermostatic mixing valve is recommended when storing domestic hot water above 115°F.Unions:Field supplied: Recommended for unit serviceability. DO NOT USE DIELECTRIC UNIONS!ONLY BRASS, COPPER, OR STAINLESS STEEL.Pressure relief valve:Factory supplied on VWH. The pressure relief valve is sized to ASME specifications. Storage tank may require additional relief valvesdepending on local codes.LP- 429 REV. 6.6.13
21I. PIPING DIAGRAMSFigure 5 – Piping LegendLP- 429 REV. 6.6.13
Page 1 and 2: Mod Con VWHINSTALLATIONSTART-UPMAIN
Page 3 and 4: 3The following defined terms are us
Page 5 and 6: 5D. CIRCULATOR PUMPS ..............
Page 7 and 8: 7DO NOT USE THIS APPLIANCE IF ANY P
Page 9 and 10: 9A. WHAT’S IN THE BOXAlso include
Page 12 and 13: 12D. CLEARANCES FOR SERVICE ACCESSS
Page 15 and 16: 7. Any improper operation of the co
Page 17 and 18: 17Never use dielectric unions or ga
Page 19: 19H. WATER CHEMISTRYChemical imbala
Page 23 and 24: 23Figure 7 NOTES:1. This drawing is
Page 25 and 26: 25ItemExhaust vent or Intake pipean
Page 27 and 28: 27NOTE: Due to potential moisture b
Page 29 and 30: 29When installing a condensate pump
Page 31 and 32: 31I. SIDEWALL VENTING DIAGRAMSFigur
Page 34 and 35: 34Under no circumstances should the
Page 36 and 37: 36D. CHECK INLET GAS PRESSUREThe ga
Page 38 and 39: 38Figure 19 - Mod Con 1700 Gas Valv
Page 40 and 41: 40use of a pipe sensor will be some
Page 42 and 43: 42Figure 21Figure 22 - Cascade Resi
Page 44 and 45: 44Figure 23 - Mod Con VWH Cascade M
Page 46 and 47: 46PART 8 - START-UP PREPARATIONA. C
Page 48 and 49: 48Additional Connected Mod Con 1000
Page 50 and 51: Heater Setting Program NavigationOn
Page 52 and 53: Function 21Error Outdoor SensorERRO
Page 54 and 55: 54The following 10 screens display
Page 56 and 57: 56PART 11 - TROUBLESHOOTINGA. HEATE
Page 58 and 59: 58Fault Code F01FLUE TEMP/WAT LV F0
Page 60 and 61: 60Fault Code F15APS OPEN F15 Flappe
Page 62 and 63: 62PART 12 - MAINTENANCEIn unusually
Page 64 and 65: 64Figure 26 - MOD CON 1000 External
Page 66 and 67: 66Figure 28LP- 429 REV. 6.6.13
Page 68 and 69: 68Figure 30LP- 429 REV. 6.6.13
Page 70 and 71:
70BOILER START-UP REPORTLIGHT OFF A
Page 72 and 73:
72LP- 429 REV. 6.6.13
Page 74 and 75:
74MAINTENANCE NOTESLP- 429 REV. 6.6
show all

Download Installation Manual (.pdf) - Heat Transfer Products, Inc

Create successful ePaper yourself

Delete template?

Save as template?