310526U, Instructions-Parts List for Ram Supply Unit ... - Graco Inc.

More documents

Recommendations

Info

Table Of ContentsSymbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3List of Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6Pump Selection Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . 7Typical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13Troubleshooting Chart . . . . . . . . . . . . . . . . . . . . . . . . . 16Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64Ram Supply Unit Technical Data . . . . . . . . . . . . . . . . . 65Graco Standard Warranty . . . . . . . . . . . . . . . . . . . . . . 66Graco Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 662310526
SymbolsWarning SymbolWARNINGThis symbol alerts you to the possibility of seriousinjury or death if you do not follow the correspondinginstructions.Caution SymbolCAUTIONThis symbol alerts you to the possibility of damage toor destruction of equipment if you do not follow thecorresponding instructions.INSTRUCTIONSEQUIPMENT MISUSE HAZARDWARNINGEquipment misuse can cause the equipment to rupture, malfunction, or start unexpectedly andresult in serious injury.This equipment is for professional use only.Read all instruction manuals, warnings, tags, and labels before operating the equipment.Use the equipment only for its intended purpose. If you are uncertain about usage, call yourdistributor.Do not alter or modify this equipment. Use only genuine Graco parts and accessories.Check the equipment daily. Repair or replace worn or damaged parts immediately.Do not exceed 9 MPa, 9 bar (125 psi) maximum inbound air pressure to the ram.Never exceed the recommended working pressure or the maximum air inlet pressure stated onyour pump or in the Pump Chart on page 7.Be sure that all spray/dispensing equipment and accessories are rated to withstand the maximumworking pressure of the pump. Do not exceed the maximum working pressure of anycomponent or accessory used in the system.Route the hoses away from the traffic areas, sharp edges, moving parts, and hot surfaces. Donot expose Graco hoses to temperatures above 82 C (180 F) or below -40 C (-40 F).Do not kink or overbend hoses or use hoses to pull the equipment.Do not touch the metal heat sink when the surface is hot.Use fluids that are compatible with the equipment wetted parts. See the Technical Data sectionsof all the equipment manuals. Read the fluid manufacturer’s warnings before using fluid orsolvent in this pump.Always wear protective eyewear, gloves, clothing, and respirator as recommended by the fluidand solvent manufacturers.Wear hearing protection when operating this equipment.Comply with all applicable local, state and national fire, electrical and other safety regulations.310526 3
Page 1: Instructions-Parts ListRam Supply U
Page 5 and 6: MOVING PARTS HAZARDWARNINGMoving pa
Page 7 and 8: Pump ChartPumpPart No.Ratio Pump Mo
Page 9 and 10: Typical InstallationThe typical ins
Page 11 and 12: InstallationThe installation proced
Page 13 and 14: OperationWARNINGMOVING PARTS HAZARD
Page 15 and 16: OperationShutdown1. Move the hand v
Page 17 and 18: ServiceThis section describes how t
Page 19 and 20: PartsModel 241082, 76 mm (3 in.) Ra
Page 29 and 30: Notes310526 29
Page 37 and 38: PartsModel 918380, SST, 76 mm (3 in
Page 53 and 54:
PartsModel C59774, 76 mm (3 in.) Ra
Page 55 and 56:
PartsModel C59777, 76 mm (3 in.) Ra
Page 57 and 58:
PartsModel 918407, Ram Air Control
Page 59 and 60:
PartsModel 918408, Follower Plate K
Page 61 and 62:
PartsModel 244757, Heated Follower
Page 63 and 64:
AccessoriesUse Only Genuine Graco P
Page 65 and 66:
Ram Supply Unit Technical DataWARNI
show all

310526U, Instructions-Parts List for Ram Supply Unit ... - Graco Inc.

Create successful ePaper yourself

Delete template?

Save as template?