819-0001 JUN 07.pdf - Frymaster

More documents

Recommendations

Info

Bell Crank Basket Lift (NOTE: There is no CE version of this option.) ON SOME EARLIER UNITS C4 WAS A 6-PIN PLUG. 1-54
1.14 WIRING DIAGRAMS – FILTER BOXES FootPrint III Prior to August 1997 (NOTE: This diagram is used for both CE & Non-CE applications.) 32C 3 4 1 2 12C PUMP RELAY LINE RED 24V LOAD TRANSFORMER TO FRYER 7 8 9 4 5 6 1 2 3 8C 41C 30C RED 52C RED 45C 13C 10C 11C 1-55 T1 T2 26C 9C 62C 7 8 9 4 5 6 1 2 3 92C TO PIN 4 BLACK PUMP TO PIN 6 WHITE HEATER TO PIN 1 TO PIN 3 TO PUMP MOTOR BLACK WHITE LINE HEATER (OPTIONAL) 8050832A FootPrint III August 1997 and Later (NOTE: This diagram is used for both CE & Non-CE applications.) 3 4 1 2 RED RED 108C 12C 11C LINE 24V/50VA T-4 8C 41C 30C TO PIN 1 TO PIN 3 TO PIN 7 TO PIN 9 32C 45C 52C 13C PUMP HEATER PUMP SOLENOID T1 T2 26C 9C 14C 92C 62C 10C 3 6 9 2 5 8 1 4 7 7 4 1 8 5 2 9 6 3 TO PUMP MOTOR 27C 51C 8050902C
Page 1 and 2:
Service and Parts Manual Frymaster,
Page 3 and 4:
DANGER Improper installation, adjus
Page 5 and 6:
H50 SERIES GAS FRYERS TABLE OF CONT
Page 7 and 8:
1.1 Functional Description H50 SERI
Page 9 and 10: FREQUENTLY USED TEST POINTS FOR INT
Page 11 and 12: THERMOSTATS All fryers in the H50 S
Page 13 and 14: CE Standard Burner Manifold Gas Pre
Page 15 and 16: 7. Disconnect the ignition cables f
Page 17 and 18: 1-11 Remove these fasteners. (On bl
Page 19 and 20: Adjusting Air/Gas Mixture CE Units
Page 21 and 22: 15. Examine the burner flame. The c
Page 23 and 24: 10. Remove the flue assembly (10).
Page 25 and 26: 6 5 24 4 23 Apply cement here 1 21
Page 27 and 28: 33. Install the upper oil-zone insu
Page 29 and 30: If popping occurs only during peak
Page 31 and 32: FAILURE TO CONTROL AT SETPOINT Prob
Page 33 and 34: FLOW FREEING A SEIZED PUMP Sediment
Page 35 and 36: plumbing. The new hose is fitted wi
Page 37 and 38: A bell crank style basket lift cons
Page 39 and 40: PROBLEM PROBABLE CAUSES CORRECTIVE
Page 41 and 42: Jumper NOTE: Some units may be wire
Page 43 and 44: Probe Resistance Chart For use with
Page 45 and 46: H50 SERIES— FULL-VAT— BEFORE JU
Page 47 and 48: H50 SERIES — DUAL-VAT — JUNE 19
Page 49 and 50: 1.10 Principal Wiring Connections F
Page 51 and 52: FPH150 ONLY (CE) 27C 27C OIL RETURN
Page 53 and 54: H50 SERIES (NON-CE) OTHER THAN FPH1
Page 55 and 56: H50 SERIES MANUFACTURED GAS UNITS O
Page 57 and 58: CE Transformer Boxes H52 ONLY NOTE:
Page 59: Modular Basket Lift - 208/250V (NOT
Page 63 and 64: Oil Return/Wand Wiring (Japan) Oil
Page 65 and 66: ITEM PART # COMPONENT 15 810-0074 Q
Page 67 and 68: ITEM PART # COMPONENT 1 Gear Motor,
Page 69 and 70: ITEM PART # COMPONENT 1 Mount, Modu
Page 71 and 72: ITEM PART # COMPONENT * 816-0554 Co
Page 73 and 74: 2.5 Cabinet Assemblies and Componen
Page 75 and 76: ITEM PART # COMPONENT 1 Back, Lower
Page 77 and 78: 2.5.4 MJH50 Batteries 6 9 3 2 5 8 2
Page 79 and 80: ITEM PART # COMPONENT 1 910-7480 Tr
Page 81 and 82: ITEM PART # COMPONENT 1 Side, Left
Page 83 and 84: 2.7 Component Box Assemblies and As
Page 85 and 86: ITEM PART # COMPONENT 1 810-2793 Ba
Page 87 and 88: 2.9 Controller Assemblies cont. ITE
Page 89 and 90: 2.11.2 Filter Magic II Square Drain
Page 91 and 92: 2.11.4 FootPrint III Square Drain C
Page 93 and 94: 2.12 Drain Valves, Drain Valve Asse
Page 95 and 96: 2.12.3 FMH50 Dual Vat (1-Inch) Valv
Page 97 and 98: 2.12.5 FPH50 Dual Vat (1-Inch X 1¼
Page 99 and 100: 2.13 Filtration Systems and Compone
Page 101 and 102: 2.13.3 FootPrint III Filter Base As
Page 103 and 104: ITEM PART # COMPONENT 1 Pump Motor
Page 105 and 106: ITEM PART # COMPONENT 1 Motor and G
Page 107 and 108: ITEM PART # COMPONENT 1 807-2484 Va
Page 109 and 110: ITEM PART # COMPONENT 1 813-0165 El
Page 111 and 112:
ITEM PART # COMPONENT 1 807-2484 Va
Page 113 and 114:
ITEM PART # COMPONENT 806-6309SP FP
Page 115 and 116:
2.13.11 Power Shower Assemblies (Al
Page 117 and 118:
ITEM PART # COMPONENT 806-9087SP Oi
Page 119 and 120:
2.13.14 Oil Disposal Wand Assembly
Page 121 and 122:
ITEM PART # COMPONENT Full Vat Fryp
Page 123 and 124:
ITEM PART # COMPONENT Dual Vat Fryp
Page 125 and 126:
ITEM PART # COMPONENT 1 810-0959 FM
Page 127 and 128:
ITEM PART # COMPONENT 1 Gas Valve a
Page 129 and 130:
2.18 Relays, Transformers, Wiring A
Page 131 and 132:
ITEM PART # COMPONENT 1 807-0012 Re
Page 133 and 134:
Main Wiring Harnesses U.S. and Non-
Page 135 and 136:
ITEM PART # COMPONENT 1 806-6164SP
Page 137 and 138:
THIS PAGE INTENTIONALLY LEFT BLANK
show all

819-0001 JUN 07.pdf - Frymaster

Create successful ePaper yourself

Delete template?

Save as template?