819-0001 JUN 07.pdf - Frymaster

More documents

Recommendations

Info

2.1 Accessories 16 15 5 9 14 8 H50 SERIES GAS FRYERS CHAPTER 2: PARTS LIST 13 ITEM PART # COMPONENT 7 1 12 1 803-0271 Basket, Twin 2 803-0099 Basket, Full (cannot be used with basket lifts) 3 803-0133 Basket Support Rack, Dual Vat 4 803-0132 Basket Support Rack, Full Vat * 803-0136 Basket Support Screen, Full Vat (screen w/handle used in place of Item 4) 5 806-3232 Cover, Frypot, Dual Vat 6 806-5518 Cover, Frypot, Full Vat * 826-0993SP Handle Kit, Frypot Cover (includes handle and screws) 7 823-1885 Connecting Strip w/back plate (Burger King only) 8 910-4617 Connecting Strip (blunt point, ½” sides, 20.70” long) –Applebee’s Fryer to Filter 9 910-2285 Connecting Strip (blunt point, 1” sides, 20.80” long)- B.K. Wide 10 910-7515 Connecting Strip (sharp point, ½” sides, 21.73” long)- B.K. Dump Station to Fryer, Also Applebee’s 11 910-7443 Connecting Strip (sharp point, 1” sides, 21.73” long) 12 910-7515 Connecting Strip (sharp point, 1” sides, 21.84” long) 13 910-2572 Connecting Strip (sharp point, 3” sides, 21.84” long) 14 Gas Line, 1-Inch Dormont Flexible (includes Items 15 and 16) 806-1698 36-Inch (for gas line only (w/o Items 15 and 16), use 810-0088) 806-1699 42-Inch (for gas line only (w/o Items 15 and 16), use 810-0085) Continued on the following page 2-1 10 11 3 4 17 2 18 6
ITEM PART # COMPONENT 15 810-0074 Quick-Disconnect Fitting, 1-Inch Male 16 810-0073 Quick-Disconnect Fitting, 1-Inch Female 17 803-0209 Brush, Frypot Cleaning 18 803-0197 Fryer’s Friend 27” (Clean-out Rod) * 910-3557 Flue Deflector * 810-1306 Valve, Manual Gas Shut Off ½” * 810-1307 Valve, Manual Gas Shut Off ¾” * Not illustrated. NOTE: Sediment Trays: 803-0103 (Full-Vat), 803-0107 (Left Dual-Vat), and 803-0108 (Right Dual-Vat) 2-2
Page 1 and 2:
Service and Parts Manual Frymaster,
Page 3 and 4:
DANGER Improper installation, adjus
Page 5 and 6:
H50 SERIES GAS FRYERS TABLE OF CONT
Page 7 and 8:
1.1 Functional Description H50 SERI
Page 9 and 10:
FREQUENTLY USED TEST POINTS FOR INT
Page 11 and 12:
THERMOSTATS All fryers in the H50 S
Page 13 and 14: CE Standard Burner Manifold Gas Pre
Page 15 and 16: 7. Disconnect the ignition cables f
Page 17 and 18: 1-11 Remove these fasteners. (On bl
Page 19 and 20: Adjusting Air/Gas Mixture CE Units
Page 21 and 22: 15. Examine the burner flame. The c
Page 23 and 24: 10. Remove the flue assembly (10).
Page 25 and 26: 6 5 24 4 23 Apply cement here 1 21
Page 27 and 28: 33. Install the upper oil-zone insu
Page 29 and 30: If popping occurs only during peak
Page 31 and 32: FAILURE TO CONTROL AT SETPOINT Prob
Page 33 and 34: FLOW FREEING A SEIZED PUMP Sediment
Page 35 and 36: plumbing. The new hose is fitted wi
Page 37 and 38: A bell crank style basket lift cons
Page 39 and 40: PROBLEM PROBABLE CAUSES CORRECTIVE
Page 41 and 42: Jumper NOTE: Some units may be wire
Page 43 and 44: Probe Resistance Chart For use with
Page 45 and 46: H50 SERIES— FULL-VAT— BEFORE JU
Page 47 and 48: H50 SERIES — DUAL-VAT — JUNE 19
Page 49 and 50: 1.10 Principal Wiring Connections F
Page 51 and 52: FPH150 ONLY (CE) 27C 27C OIL RETURN
Page 53 and 54: H50 SERIES (NON-CE) OTHER THAN FPH1
Page 55 and 56: H50 SERIES MANUFACTURED GAS UNITS O
Page 57 and 58: CE Transformer Boxes H52 ONLY NOTE:
Page 59 and 60: Modular Basket Lift - 208/250V (NOT
Page 61 and 62: 1.14 WIRING DIAGRAMS - FILTER BOXES
Page 63: Oil Return/Wand Wiring (Japan) Oil
Page 67 and 68: ITEM PART # COMPONENT 1 Gear Motor,
Page 69 and 70: ITEM PART # COMPONENT 1 Mount, Modu
Page 71 and 72: ITEM PART # COMPONENT * 816-0554 Co
Page 73 and 74: 2.5 Cabinet Assemblies and Componen
Page 75 and 76: ITEM PART # COMPONENT 1 Back, Lower
Page 77 and 78: 2.5.4 MJH50 Batteries 6 9 3 2 5 8 2
Page 79 and 80: ITEM PART # COMPONENT 1 910-7480 Tr
Page 81 and 82: ITEM PART # COMPONENT 1 Side, Left
Page 83 and 84: 2.7 Component Box Assemblies and As
Page 85 and 86: ITEM PART # COMPONENT 1 810-2793 Ba
Page 87 and 88: 2.9 Controller Assemblies cont. ITE
Page 89 and 90: 2.11.2 Filter Magic II Square Drain
Page 91 and 92: 2.11.4 FootPrint III Square Drain C
Page 93 and 94: 2.12 Drain Valves, Drain Valve Asse
Page 95 and 96: 2.12.3 FMH50 Dual Vat (1-Inch) Valv
Page 97 and 98: 2.12.5 FPH50 Dual Vat (1-Inch X 1¼
Page 99 and 100: 2.13 Filtration Systems and Compone
Page 101 and 102: 2.13.3 FootPrint III Filter Base As
Page 103 and 104: ITEM PART # COMPONENT 1 Pump Motor
Page 105 and 106: ITEM PART # COMPONENT 1 Motor and G
Page 107 and 108: ITEM PART # COMPONENT 1 807-2484 Va
Page 109 and 110: ITEM PART # COMPONENT 1 813-0165 El
Page 111 and 112: ITEM PART # COMPONENT 1 807-2484 Va
Page 113 and 114: ITEM PART # COMPONENT 806-6309SP FP
Page 115 and 116:
2.13.11 Power Shower Assemblies (Al
Page 117 and 118:
ITEM PART # COMPONENT 806-9087SP Oi
Page 119 and 120:
2.13.14 Oil Disposal Wand Assembly
Page 121 and 122:
ITEM PART # COMPONENT Full Vat Fryp
Page 123 and 124:
ITEM PART # COMPONENT Dual Vat Fryp
Page 125 and 126:
ITEM PART # COMPONENT 1 810-0959 FM
Page 127 and 128:
ITEM PART # COMPONENT 1 Gas Valve a
Page 129 and 130:
2.18 Relays, Transformers, Wiring A
Page 131 and 132:
ITEM PART # COMPONENT 1 807-0012 Re
Page 133 and 134:
Main Wiring Harnesses U.S. and Non-
Page 135 and 136:
ITEM PART # COMPONENT 1 806-6164SP
Page 137 and 138:
THIS PAGE INTENTIONALLY LEFT BLANK
show all

819-0001 JUN 07.pdf - Frymaster

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?