819-0001 JUN 07.pdf - Frymaster

More documents

Recommendations

Info

2.11.5 FootPrint III Square Drain Components, Foodmaker Configuration 5 8 7 4 ITEM PART # COMPONENT 1 806-6374 Clamp Assembly 2 816-0420 Boot (Connection Seal) 3 KIT-0257SP Clamp Assembly and Seal Kit 4 826-1382 Wing Nut (Pkg. of 10) 5 816-0135 O-Ring 6 823-2223 Drain Outlet Section, Open 23.38” Long 7 823-2301 Drain Section, 15.39” Long 8 823-2198 Right End Section, 7.95” Long 9 823-2222 Left End Section, 7.95” Long 1 6 2 2-29 3 9
2.12 Drain Valves, Drain Valve Assemblies and Associated Parts 2.12.1 Drain Valves and Drain Extensions 1 4 5 8 9 10 3 2 ITEM PART # COMPONENT 1 812-1227 Drain Valve Extension, Screw-In DV (1-inch NPT) 2 812-1226SP Drain Valve Extension, Screw-In FV (1¼-inch NPT) 3 210-4175 Drain Valve Extension, Bayonet Connection (used only with Items 5 and 7) 4 810-1338 Drain Valve, 1-inch NPT Inlet and Outlet, Dual Vat 5 810-2536 Drain Valve, 1-inch NPT Inlet, Bayonet Outlet, Non-Filter Dual Vat 6 810-1569 Drain Valve w/Handle, 1¼-inch NPT Inlet and Outlet, Full Vat 806-4145 Drain Valve, 1¼-inch- CF or High Sediment (Large Bore) 7 810-2535 Drain Valve w/Handle, 1¼-inch NPT Inlet, Bayonet Outlet Non-Filter FV* 8 810-1018 Drain Valve, 1¼-inch NPT Inlet, 1-inch O-Ring Outlet, ½-inch Stem, FV* 9 810-1114 Drain Valve, 1¼-inch NPT Inlet, 1-inch O-Ring Outlet, ⅜-inch Stem, DV* 10 810-1020 Drain Valve, 1¼-inch NPT Inlet, 1-inch NPT Outlet, Full Vat (Filter Magic Unit) * Full Vat and Dual Vat Application Notes: Item 4 is used on non-filter, Filter Magic, and FootPrint III units. Items 5, 6, and 7 are used only on non-filter units. Items 8 and 9 are used only on FootPrint III units. Item 10 is used on Filter Magic units. 2-30 6 7
Page 1 and 2:
Service and Parts Manual Frymaster,
Page 3 and 4:
DANGER Improper installation, adjus
Page 5 and 6:
H50 SERIES GAS FRYERS TABLE OF CONT
Page 7 and 8:
1.1 Functional Description H50 SERI
Page 9 and 10:
FREQUENTLY USED TEST POINTS FOR INT
Page 11 and 12:
THERMOSTATS All fryers in the H50 S
Page 13 and 14:
CE Standard Burner Manifold Gas Pre
Page 15 and 16:
7. Disconnect the ignition cables f
Page 17 and 18:
1-11 Remove these fasteners. (On bl
Page 19 and 20:
Adjusting Air/Gas Mixture CE Units
Page 21 and 22:
15. Examine the burner flame. The c
Page 23 and 24:
10. Remove the flue assembly (10).
Page 25 and 26:
6 5 24 4 23 Apply cement here 1 21
Page 27 and 28:
33. Install the upper oil-zone insu
Page 29 and 30:
If popping occurs only during peak
Page 31 and 32:
FAILURE TO CONTROL AT SETPOINT Prob
Page 33 and 34:
FLOW FREEING A SEIZED PUMP Sediment
Page 35 and 36:
plumbing. The new hose is fitted wi
Page 37 and 38:
A bell crank style basket lift cons
Page 39 and 40:
PROBLEM PROBABLE CAUSES CORRECTIVE
Page 41 and 42: Jumper NOTE: Some units may be wire
Page 43 and 44: Probe Resistance Chart For use with
Page 45 and 46: H50 SERIES— FULL-VAT— BEFORE JU
Page 47 and 48: H50 SERIES — DUAL-VAT — JUNE 19
Page 49 and 50: 1.10 Principal Wiring Connections F
Page 51 and 52: FPH150 ONLY (CE) 27C 27C OIL RETURN
Page 53 and 54: H50 SERIES (NON-CE) OTHER THAN FPH1
Page 55 and 56: H50 SERIES MANUFACTURED GAS UNITS O
Page 57 and 58: CE Transformer Boxes H52 ONLY NOTE:
Page 59 and 60: Modular Basket Lift - 208/250V (NOT
Page 61 and 62: 1.14 WIRING DIAGRAMS - FILTER BOXES
Page 63 and 64: Oil Return/Wand Wiring (Japan) Oil
Page 65 and 66: ITEM PART # COMPONENT 15 810-0074 Q
Page 67 and 68: ITEM PART # COMPONENT 1 Gear Motor,
Page 69 and 70: ITEM PART # COMPONENT 1 Mount, Modu
Page 71 and 72: ITEM PART # COMPONENT * 816-0554 Co
Page 73 and 74: 2.5 Cabinet Assemblies and Componen
Page 75 and 76: ITEM PART # COMPONENT 1 Back, Lower
Page 77 and 78: 2.5.4 MJH50 Batteries 6 9 3 2 5 8 2
Page 79 and 80: ITEM PART # COMPONENT 1 910-7480 Tr
Page 81 and 82: ITEM PART # COMPONENT 1 Side, Left
Page 83 and 84: 2.7 Component Box Assemblies and As
Page 85 and 86: ITEM PART # COMPONENT 1 810-2793 Ba
Page 87 and 88: 2.9 Controller Assemblies cont. ITE
Page 89 and 90: 2.11.2 Filter Magic II Square Drain
Page 91: 2.11.4 FootPrint III Square Drain C
Page 95 and 96: 2.12.3 FMH50 Dual Vat (1-Inch) Valv
Page 97 and 98: 2.12.5 FPH50 Dual Vat (1-Inch X 1¼
Page 99 and 100: 2.13 Filtration Systems and Compone
Page 101 and 102: 2.13.3 FootPrint III Filter Base As
Page 103 and 104: ITEM PART # COMPONENT 1 Pump Motor
Page 105 and 106: ITEM PART # COMPONENT 1 Motor and G
Page 107 and 108: ITEM PART # COMPONENT 1 807-2484 Va
Page 109 and 110: ITEM PART # COMPONENT 1 813-0165 El
Page 111 and 112: ITEM PART # COMPONENT 1 807-2484 Va
Page 113 and 114: ITEM PART # COMPONENT 806-6309SP FP
Page 115 and 116: 2.13.11 Power Shower Assemblies (Al
Page 117 and 118: ITEM PART # COMPONENT 806-9087SP Oi
Page 119 and 120: 2.13.14 Oil Disposal Wand Assembly
Page 121 and 122: ITEM PART # COMPONENT Full Vat Fryp
Page 123 and 124: ITEM PART # COMPONENT Dual Vat Fryp
Page 125 and 126: ITEM PART # COMPONENT 1 810-0959 FM
Page 127 and 128: ITEM PART # COMPONENT 1 Gas Valve a
Page 129 and 130: 2.18 Relays, Transformers, Wiring A
Page 131 and 132: ITEM PART # COMPONENT 1 807-0012 Re
Page 133 and 134: Main Wiring Harnesses U.S. and Non-
Page 135 and 136: ITEM PART # COMPONENT 1 806-6164SP
Page 137 and 138: THIS PAGE INTENTIONALLY LEFT BLANK
show all

819-0001 JUN 07.pdf - Frymaster

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?