Aprilia Scarabeo 4T servicemanual - Scootergrisen

More documents

Recommendations

Info

ELECTRICAL SYSTEM CONTENTS Recharge and general power supply circuit .............. 80 Recharge and general power supply circuit 100 ..... 81 Injection power .......................................................... 82 Injection diagram ....................................................... 83 Stoplight circuit and starter circuit ..................................... 87 Direction indicator circuit and horn circuit ................. 89 Direction indicator circuit and horn circuit 100 ......... 90 Lighting circuit ........................................................... 91 Lighting circuit 100 ................................................... 92 Dashboard lights circuit ..................................................... 93 Wiring diagrams - Scarabeo ..................................... 96 Wiring diagrams - Scarabeo ..................................... 98 Wiring diagrams - Scarabeo 100 ................................... 100 Arrangement of the components ..................................... 102 Arrangement and fastening of cables and wiring ............ 104 Release 00 2003-02 Scarabeo 50 I.E.-50/100 4T 79
RECHARGE AND GENERAL POWER SUPPLY CIRCUIT WIRING DIAGRAM Arrangement of the components: see p. 96 - 97. 13) Fuses 14) Battery 18) Voltage regulator 19) Generator 29) Key switch TECHNICAL DATA Generator ............................................................... 140W Voltage regulator ................................................ 12 V a.c. Battery ................................................. 4 Ah - 12V sealed Fuse ......................................................................... 10 A CHECKING THE CHARGING SYSTEM – Start the engine. – Using the voltmeter function of the multimeter, connect the positive lead to the positive terminal of the battery, and the negative lead to the negative terminal of the battery. – At 6000 rpm voltage must be included between 13.5 and 15 V. TROUBLESHOOTING A.INSUFFICIENT RECHARGE VOLTAGE – Check the fuse and, if necessary, replace it. – Check the cable connections on regulator, flywheel, battery and fuse. – Check the battery (see below). – Check the generator (see below). 80 G Ar 19 V Ar/Bi B.EXCESSIVE RECHARGE VOLTAGE – Check the voltage regulator. – Check the cable connections. C.IF NO VOLTAGE REACHES THE LOADS UNDER DIRECT CURRENT (green/red cables) – Check the fuse and if necessary replace it. – Check the ground connections on regulator, flywheel, B 18 Ar 14 Release 00 2003-02 10 A R/N 13 7,5 A Ar 13 R/N Ar 29 V/R INJECTION RELAY ELECTRICAL FUNCTIONS UNDER D.C. LIGHTS Scarabeo 50 I.E.-50/100 4T INJECTION battery and fuse. – Check the battery (see below). – Check the generator (see below). – Check the ignition switch (see p. 96) and its connections. D.IF THE SYSTEM FUNCTIONS IRREGULARLY – Check the earth connections. TEST DATA GENERATOR – Disconnect the two-way connector from the generator. – Start the engine and bring it to 6000 rpm. – Using the alternating current function of the multimeter, measure the voltage between: • orange cable and generator earth = value over 41.2 V. • yellow cable and generator earth = value over 35V. – Using the alternating current ammeter function of the multimeter, measure the current between: • orange cable and generator earth = value 8 - 10 A. • yellow cable and generator earth = value 8 -10 A. BATTERY – No-load voltage 12.5 ± 1V. – Make sure that there are no signs of sulphation. Replace if necessary.
Page 1 and 2:
www.serviceaprilia.com 8140696 UK 1
Page 3 and 4:
GENERAL SAFETY RULES CARBON MONOXID
Page 5 and 6:
ELECTRICAL CONNECTORS The electrica
Page 7 and 8:
CONTENTS FOREWORD .................
Page 9 and 10:
TECHNICAL DATA DIMENSIONS Max. leng
Page 11 and 12:
TIGHTENING TORQUES TABLE 10 Release
Page 13 and 14:
TIGHTENING TORQUES TABLE 100 12 Rel
Page 15 and 16:
REGULAR SERVICE INTERVALS CHART Com
Page 17 and 18:
REGULAR SERVICE INTERVALS CHART OPE
Page 19 and 20:
ARRANGEMENT OF THE MAIN ELEMENTS KE
Page 21 and 22:
THROTTLE CHECKING THE OPERATION OF
Page 23 and 24:
FAIRINGS REMOVING THE LUGGAGE RACK
Page 25 and 26:
REMOVING THE REAR MUDGUARD Carefull
Page 27 and 28:
REMOVING THE REAR-VIEW MIRRORS Care
Page 29 and 30: REMOVING THE BUMPER Carefully read
Page 31 and 32: REMOVING THE SADDLE SUPPORT 100 Car
Page 33 and 34: DRAINING THE FUEL TANK Carefully re
Page 35 and 36: REMOVING FUEL TANK Carefully read p
Page 37 and 38: REMOVAL Carefully read p. 35 (MIXER
Page 39 and 40: BULBS Carefully read p. 2 (GENERAL
Page 41 and 42: FRONT AND REAR DIRECTION INDICATORS
Page 43 and 44: REAR LIGHT CHANGING THE REAR LIGHT
Page 45 and 46: DASHBOARD 100 CHANGING THE DASHBOAR
Page 47 and 48: BRAKES Do not ride your vehicle wit
Page 49 and 50: FRONT AND REAR BRAKE Carefully read
Page 51 and 52: BRAKE PADS Carefully read p. 2 (GEN
Page 53 and 54: BRAKE CALIPERS Carefully read p. 2
Page 55 and 56: TRANSMISSION CHECKING THE TRANSMISS
Page 57 and 58: Change, repair, maintenance and bal
Page 59 and 60: CHECKING ♦ Before reassembly, che
Page 61 and 62: REAR WHEEL DISASSEMBLY Carefully re
Page 63 and 64: AIR CLEANER Carefully read p. 2 (GE
Page 65 and 66: AIR CLEANER 64 100 Carefully read p
Page 67 and 68: FORK HEAD CHECKING THE BEARING PLAY
Page 69 and 70: FRONT FORK REMOVING THE COMPLETE FO
Page 71 and 72: 70 CAUTION If the additional flange
Page 73 and 74: ♦ Remove the rear brake caliper,
Page 75 and 76: BATTERY Carefully read p. 2 (GENERA
Page 77 and 78: RECHARGING THE BATTERY Carefully re
Page 79: To check the fuse: ♦ Turn the ign
Page 83 and 84: INJECTION POWER WIRING DIAGRAM TROU
Page 85 and 86: TROUBLESHOOTING - Check the efficie
Page 87 and 88: - With throttle CLOSED. - With thro
Page 89 and 90: CHECKING THE START RELAY To check t
Page 91 and 92: DIRECTION INDICATOR CIRCUIT AND HOR
Page 93 and 94: LIGHTING CIRCUIT 100 WIRING DIAGRAM
Page 95 and 96: FUEL LEVEL INDICATOR TROUBLESHOOTIN
Page 97 and 98: WIRING DIAGRAM - SCARABEO 50 96 33
Page 103 and 104: ARRANGEMENT OF THE COMPONENTS KEY 1
Page 105 and 106: ARRANGEMENT AND FASTENING OF CABLES
Page 107 and 108: FASTENING OF CABLES AND WIRINGS 106
Page 109 and 110: NOTES 108 Release 00 2003-02 Scarab
show all

Aprilia Scarabeo 4T servicemanual - Scootergrisen

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?