DTC P0107, P0108 5.19 - harley-davidson-sweden.se

More documents

Recommendations

Info

HOME s0453x9x CKP sensor [79A] [79B] 1 2 1 2 BK BK BK R R BK [78B] [78A] ECM 10 12 28 30 Gnd. CKP. Gnd. CKP. Figure 5-56. CKP Circuit Table 5-40. Wire Harness Connectors in Figure 5-56. NO. DESCRIPTION TYPE LOCATION [78] ECM 36-Place Packard Under Right Side Cover [79] CKP Sensor 2-Place Mini-Deutsch Under Right Side Cover 5-92 2004 Touring: Engine Management (EFI)
HOME Test 5.24 CKP SENSOR: DTC P0373, P0374 1 2 Connect Breakout Box to harness only, leaving ECM disconnected. Measure resistance between terminals 30 and 28 and between terminals 12 and 28 on Breakout Box. Resistance more than 1 megohm YES Check for intermittent connection, pinched or damaged wires, and loose CKP sensor fasteners. Conditions found NO Disconnect connector [79]. Leaving ECM disconnected, measure resistance between terminals 12 and 28 and terminals 30 and 28 on Breakout Box. Continuity to ground (less than 1 megohm resistance) YES NO YES Repair as necessary. Connect DVOM to terminals 12 and 30 on Breakout Box. Set DVOM to AC volts and crank engine. Does DVOM read 1 VAC minimum during cranking NO YES Repair short to ground on R or BK wire between connectors [78B] and [79B]. NO Replace CKP sensor. See Touring Service Manual. With DVOM still connected, check for intermittents using 5.8 WIGGLE TEST. Intermittents present 3 Connect DVOM at Terminals 1 and 2 of connector [79A]. Does DVOM read 1 VAC minimum while cranking YES NO Repair as necessary. Install known good CKP sensor. Clear codes and retest. DTC P0373 or P0374 4 YES Check for continuity between Terminal 1 of connector [79B] and terminal 30 on Breakout Box. Continuity present NO Replace CKP sensor. See Touring Service Manual. YES NO YES NO Reinstall original CKP sensor. Replace ECM. Reprogram and learn password. Replace CKP sensor Repair open on BK wire between Terminal 2 of connector [79B] and terminal 12 of Breakout Box. Repair open on R wire between Terminal 1 of connector [79B] and terminal 30 of Breakout Box. Clear codes using speedometer self diagnostics. See 5.6 SPEEDOMETER SELF DIAGNOSTICS. Confirm proper operation with no check engine lamp. 2004 Touring: Engine Management (EFI) 5-93
Page 1 and 2: 7 HOME DTC P0107, P0108 5.19 GENERA
Page 3 and 4: HOME Test 5.19 (Part 1 of 2) MAP SE
Page 5 and 6: HOME DTC P0112, P0113 5.20 GENERAL
Page 7 and 8: HOME Test 5.20 (Part 1 of 2) IAT SE
Page 11 and 12: HOME Test 5.21 (Part 1 of 2) ET SEN
Page 15 and 16: HOME Test 5.22 (Part 1 of 2) TP SEN
Page 17 and 18: HOME DTC P0261, P0262, P0263, P0264
Page 19 and 20: HOME f2208m8x [62B] System relay [6
Page 21 and 22: HOME Test 5.23 (Part 2 of 3) FUEL I
Page 23: HOME DTC P0373, P0374 5.24 GENERAL
Page 27 and 28: HOME f2208v8x Vehicle speed sensor
Page 29 and 30: HOME Test 5.25 (Part 2 of 2) VEHICL
Page 31 and 32: HOME f2208k8x [78A] [78B] [62B] Sys
Page 33 and 34: HOME Test 5.26 (Part 1 of 2) BATTER
Page 37 and 38: HOME [156B] [156A] f2208u8x BK LtGN
Page 39 and 40: HOME Test 5.28 PASSWORD PROBLEM: DT
Page 41 and 42: HOME f2208h8x [62B] System relay [7
Page 43 and 44: HOME Test 5.29 (Part 1 of 2) IGNITI
Page 45 and 46: HOME DTC U1064, U1255 5.30 GENERAL
Page 47 and 48: HOME f2208t8x BK GY LtGN/V BN/GY Lt
Page 49 and 50: HOME DTC U1097, U1255 5.31 GENERAL
Page 51 and 52: HOME f2208t8x BK GY LtGN/V BN/GY Lt

DTC P0107, P0108 5.19 - harley-davidson-sweden.se

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?