Model 777-KW/HP - SymCom

More documents

Recommendations

Info

RM-2000The RM-2000is a motor-monitoring device to be used in conjunction with SymCom’s Model 777 productline.The RM-2000/777 motor management system combines unsurpassed electronicmotor protection and critical, user-friendly motor monitoring.The RM-2000 has membrane keypad controls which allow both monitoring andcontrol of a 777 MotorSaver ® through an RS-485 network using Modbus RTU protocol.A second communication port is available to allow monitoring and control of up to 99RM-2000 devices from a PLC, DCS, or SCADA system or a PC with Solutions softwareinstalled.The RM-2000 is environmentally protected and is easily mounted on the frontof a panel or motor control center.See Appendix A, Figure 4 for a typical wiring diagram.Available Models:RM-2000RM-2000 CBM+RM-2000-RTDWFeaturesDisplays:• Average current, individual line currents, and current unbalance• Current to ground• Average voltage, line-line voltages, and voltage unbalance• Instantaneous power• Power factor• Last four faults• All parameters programmed into 777 MotorSaver ®• Remaining restart delay timesControls:• Start and stop buttons• Key lock input to prevent setpoint changes• Change 777 setpoints from keypadThe RM-2000 is also equipped with a real-time clock, which allows access tothe following motor management information (most readings can be reset):• Total motor run-time• Time and date of last four faults, along with voltage and current at time of trip• Time and date of last 10 motor starts• Total number of motor restarts• Minimum time between any two starts with time and date• Run-time since last start• kWh consumed• kVARs consumedSpecificationsControl Voltage • • • • • • • • • • • 115VAC ±10%; 50/60HzTransient Protection (Internal) • 2500V for 10msPower Consumption • • • • • • • • 3 Watts (max.)Communication • • • • • • • • • • • 1 Port for 777 1 Port for PC, PLC, etc.Baud Rate• • • • • • • • • • • • • • • • • 9600 300-28800Setup • • • • • • • • • • • • • • • • • • • Even ParityNone, Odd, or Even• • • • • • • • • • • • • • • • • • • • • • 1 Stop BitParity 1 or 2 Stop BitsProtocol • • • • • • • • • • • • • • • • • Modbus RTU Modbus RTUSerial Interface • • • • • • • • • • • • • RS-485RS-485Available Addresses • • • • • • • • • • 01A01-A99Real-time ClockBattery Back-up Life • • • • • • • • • • 10 years @ 25˚C without external powerLast fault memory • • • • • • • • • • • Stores up to 4 faults with time and date stamp,• • • • • • • • • • • • • • • • • • • • • • includes voltages and currents at time of tripConfiguration • • • • • • • • • • • • • • Two independent electro-mechanical form C (SPDT)Contact Material. • • • • • • • • • • • • Silver/Tin OxidePilot Duty Rating.• • • • • • • • • • • • 240VA @ 120VACGeneral Purpose Rating• • • • • • • • 5A @ 120VACEnvironmentClass of Protection• • • • • • • • • • • NEMA 3RAmbient Operating Temp. • • • • • • -40˚ to 70˚C (-40˚ to 158˚F)Ambient Storage Temp. • • • • • • • • -40˚ to 70˚C (-40˚ to 158˚F)Humidity • • • • • • • • • • • • • • • • • Up to 85%, non-condensingSafety MarksUL • • • • • • • • • • • • • • • • • • • UL508CE • • • • • • • • • • • • • • • • • • • IEC 60947-6-2EnclosureDimensions• • • • • • • • • • • • • • • • 6" W x 6 3 /8" H x 1 1 /16" DWeight • • • • • • • • • • • • • • • • • • 1.2 lbs.Material • • • • • • • • • • • • • • • • • • Black polycarbonateDisplay • • • • • • • • • • • • • • • • • • Liquid crystal with extended temp. rangeSize • • • • • • • • • • • • • • • • • • • • 2 rows x 20 charactersLighting • • • • • • • • • • • • • • • • • • LED BacklightKeypad• • • • • • • • • • • • • • • • • • Eight 0.5" stainless steel dome buttons for tactile feedbackMechanical Life • • • • • • • • • • • • • 100,000 actuationsOverlay Material • • • • • • • • • • • • PolyesterUV Exposure w/o degradation • • • • 2000 hrs.Terminal • • • • • • • • • • • • • • • • Depluggable terminal block10 www.symcom.com • tel: 605-348-5580 800-843-8848 • fax: 605-348-5685
Solutions SoftwareSolutions is a software application that provides the ability toconfigure and monitor Modbus (Solutions-M) or DeviceNet ®(Solutions-D) networks. Solutions features include the ability tolog data, real time data, continuous fault and event monitoring,and intuitive device configuration and setup. Solutions-Msupports both RS-485 and TCP/IP networks (requires aModbus TCP to Modbus RTU converter). Solutions-D providessupport for all DeviceNet capable SymCom devices andmost other DeviceNet devices, including DeviceNet scanners.Requirements• Microsoft Windows XP or higher• Microsoft .net Framework 2.0 (provided with Solutions)• 300 MB of hard drive space• RS-485 to RS-232 converter (with 1 available serial port) for Solutions-M orRS-485 to USB converter (with 1 available USB port) for Solutions-M• USB to CAN converter (with 1 available USB port) for Solutions-DAvailable Models:Solutions-MSolutions-Dwww.symcom.com • tel: 605-348-5580 800-843-8848 • fax: 605-348-568511
Page 3 and 4: Table of ContentsMotor ProtectionMo
Page 5 and 6: 777 Product LineProduct Selection M
Page 7 and 8: 777 Product LineSpecificationsElect
Page 9 and 10: Communication ModulesThe RS485MS-2W
Page 11: Remote Monitoring DevicesAvailable
Page 15 and 16: 3-Phase Voltage MonitorsProduct Sel
Page 17 and 18: Model 102AThe Model 102Ais an auto-
Page 19: Model 201A-AUThe Model 201A-AUis an
Page 24 and 25: Model 455The Model 4553-phase volta
Page 28 and 29: Model 601The Model 601is a fully-pr
Page 30 and 31: Model 50RThe Model 50Rsingle-phase
Page 32 and 33: Model 202-200-SPThe Model 202-200-S
Page 34 and 35: Three-Phase Current MonitorsCurrent
Page 36: Model 520CPThe Model 520CPis a full
Page 39 and 40: Alternating RelaysProduct Selection
Page 41 and 42: Intrinsically-Safe RelaysAn Intrins
Page 43 and 44: Model ISS-102The ISS-102SymCom’s
Page 45 and 46: Pump ControllersPump Controllers ar
Page 47 and 48: Model PC-105The PC-105is a five-cha
Page 49 and 50: Model 460-15-100-SLDThe Model 460-1
Page 51 and 52: Three-Phase PumpSaversMore than jus
Page 53 and 54: Model 777-KW/HPSpecificationsElectr
Page 55 and 56: Model 777-AccuPowerThe Model 777-Ac
Page 57 and 58: 77C-KW/HPThe Model 77C-KW/HPhas imp
Page 59 and 60: 111 & 231-INSIDER-PModels 111-Insid
Page 61 and 62: Models 233-P & 111The Model 233-P a
Page 63 and 64:
Load SensorsSymCom’s load sensors
Page 65 and 66:
Model LSR-24The Model LSR-XXXload s
Page 67 and 68:
Model LSRXThe Model LSRXis an AC cu
Page 69 and 70:
Current TransformersCurrent Transfo
Page 71 and 72:
Auxiliary ProductsInformer IR Kit (
Page 73 and 74:
Enclosure Dimensions777, 77C, 6010.
Page 75 and 76:
Enclosure DimensionsALT, 201, ISS-1
Page 77 and 78:
Enclosure DimensionsLSRX.7218.22.50
Page 79 and 80:
LOVLOVLOVIND. CONT. EQ.LISTEDIND. C
Page 81 and 82:
Appendix ATYPICAL WIRING DIAGRAM FO
Page 83:
Appendix AINPUT POWERL1L2L3MMMOLOLO
Page 86 and 87:
Appendix ATYPICAL WIRING DIAGRAM FO
Page 88:
www.SymCom.com... your electronic c
show all

Model 777-KW/HP - SymCom

Create successful ePaper yourself

Delete template?

Save as template?