INT'L Shortcut Cartridge Catalogue - Bibus SK, s.r.o.

More documents

Recommendations

Info

Pilot Control Valves 3-WAY, 2-POSITION, SOLENOID OPERATED, DIRECTIONAL SPOOL VALVE, PILOT CAPACITY b Port 3 Port 2 d 1 Port Locating Shoulder Performance Curves 2 3 Normally Open Port 1 to 2 Nominal Capacity Typical Cartridge Model Code DBAL-X**, DBAL-S** Pressure Differential vs. Flow ■ Maximum operating pressure = 350 bar. ■ Maximum valve leakage at 24cSt = 0,6 cc/min. at 350 bar. ■ Response time - typical = 50 ms. ■ Manual override force requirement = 6,6 kg at 100 bar at port 1. ■ Manual override stroke = 2,5 mm. ■ Maximum switching frequency = 15000 cycles/hr. ■ Viscosity range = 10 - 600 cSt. ■ This valve is direct actuated and requires no minimum hydraulic pressure for operation. ■ The solenoid tube assembly is fatigue rated for 350 bar service. ■ The soft shift feature results in significantly longer response time over Sun’s standard solenoid. Response time is dependant on flow, pressure, coil voltage, oil viscosity and ambient temperature. Typical response time ranges from 150 ms to 300 ms. ■ A wide variety of coil termination and voltage options are available. See Sun website: Products: Accessories: Coils. OPTION ORDERING INFORMATION c a 1 2 3 Normally Open Port 1 to 3 DBAL – X ✱✱ – ✱✱✱ Nominal Capacity Control* Spool Configuration** Coil Options** A 1 L/min. X No Manual Override H Normally Open Port 1 to 2, M Manual Override Closed 1 to 3 1 S Soft Shift C Normally Open Port 1 to 3, D Twist/Lock, Closed 1 to 2 Dual, Manual Override Cartridge Dimensions Cavity a b c*** d L Twist/Lock, Detent, Seal Material Manual Override N Buna-N T Twist/Lock, Momentary, Manual Override V Viton Installation Torque (Nm) M,X,S D,L,T 1 L/min. DBAL – *** T-9A 27,4 22,2 83,5 94,7 37,8 35 - 40 ***An additional 50,8 mm clearance is needed for coil installation and removal. P = bar 40 30 20 10 0 1 2 3 Flow = L/min. * See page 178 for information ** Consult the Sun website for complete information on Spool Configurations, on Control Options the full line of Coil Options and Embedded Amplifier Coils/Controllers. Visit www.sunhydraulics.com for current list pricing and complete technical information on all Sun products. 4 See page 187: Coil option information for Metal Housing (Round) Solenoid Cartridges. 150 Int’l Shortcut Catalogue #999-901-312
Pilot Control Valves 3-WAY, 2-POSITION, HYDRAULICALLY OPERATED, DIRECTIONAL SPOOL VALVE, PILOT CAPACITY b 3 Port 2 Port Port Performance Curves 1 c a Locating Shoulder Visit www.sunhydraulics.com for current list pricing and complete technical information on all Sun products. Int’l Shortcut Catalogue #999-901-312 151 DBAH Pressure Differential vs. Flow ■ Maximum operating pressure = 350 bar. ■ Maximum valve leakage at 24cSt = 0,6 cc/min. at 350 bar. ■ The minimum pilot pressure required to operate the valve is determined by the following formula: pilot pressure = 6 bar + pressure at port 1 times 0,023. This results in a pilot pressure range of 6 to 14 bar. ■ All ports will accept 350 bar including the pilot control port. Nominal Capacity 2 3 Capacity Ext. Normally Normally Open Open 1 to 2 1 to 3 OPTION ORDERING INFORMATION 1 1 2 3 Typical Cartridge Model Code D B A H – ✱ ✱ ✱ Cartridge Dimensions Cavity a b c Pilot Control Port Spool Configuration Seal Material A 1 L/min. A External H Normally Open N Buna-N 1/8 NPTF Port Port 1 to 2, 1 to 3 Closed V Viton B External SAE-4 Port C Normally Open Port 1 to 3, D External 1 to 2 Closed 1/8 BSPP Port Ext. Installation Torque (Nm) 1 L/min. DBAH – DCN T-9A 27,7 22,2 42,1 35 - 40 P = bar 40 30 20 10 0 1 2 3 Flow = L/min. 4
Page 1 and 2:
Over 35 New Products in this Catalo
Page 3 and 4:
Contents Model Codes printed in Red
Page 5 and 6:
2 1 2 2 2 1 1 1 2 1 2 1 2 1 2 Air P
Page 7 and 8:
Relief Valves DIRECT ACTING AND DIR
Page 9 and 10:
Relief Valves DIRECT ACTING, PILOT
Page 11 and 12:
Relief Valves PILOT OPERATED, BALAN
Page 13 and 14:
Page 15 and 16:
Relief Valves, Electro-Proportional
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Relief Valves Full Adjustment 5 Tur
Page 23 and 24:
Page 25 and 26:
2 1 2 2 3 2 1 2 1 3 T-8A Cav 2 3 3
Page 27 and 28:
Sequence Valves DIRECT ACTING WITH
Page 29 and 30:
Sequence Valves AIR CONTROLLED, PIL
Page 31 and 32:
Sequence Valves, Electro-Proportion
Page 33 and 34:
3 2 1 2 1 3 2 3 2 3 T-8A Cav Air Pi
Page 35 and 36:
Reducing Valves PILOT OPERATED, AIR
Page 37 and 38:
Reducing/Relieving Valves PILOT OPE
Page 39 and 40:
Reducing/Relieving Valves DIRECT AC
Page 41 and 42:
Reducing/Relieving Valves PILOT OPE
Page 43 and 44:
Reducing/Relieving Valves, Electro-
Page 45 and 46:
Reducing/Relieving Valves, Electro-
Page 47 and 48:
2 1 3 2 1 2 1 2 3 3 4 3 Ext. 1 Int
Page 49 and 50:
Pilot-to-Open Check Valves ATMOSPHE
Page 51 and 52:
2 2 2 2 2 2 2 4 2 4 2 3 3 3 3 3 3 3
Page 53 and 54:
Series 2 Series 3 Series 4 Series 2
Page 55 and 56:
Counterbalance Valves NON-VENTED, S
Page 57 and 58:
Counterbalance Valves NON-VENTED, S
Page 59 and 60:
Counterbalance Valves NON-VENTED, R
Page 61 and 62:
Counterbalance Valves VENTED, 280 B
Page 63 and 64:
2 2 4 2 4 2 3 3 3 3 1 1 1 1 Load Co
Page 65 and 66:
Load Control: Load Reactive Valves
Page 67 and 68:
Load Control: Load Reactive Valves
Page 69 and 70:
2 2 3 3 4 1 1 Load Control: Balance
Page 71 and 72:
Load Control: Balanced VENTED, NON-
Page 73 and 74:
2 1 2 1 2 1 2 1 2 1 3 3 Int’l Sho
Page 75 and 76:
Check Valves FREE FLOW, SIDE-TO-NOS
Page 77 and 78:
Check Valves FREE FLOW, SIDE-TO-NOS
Page 79 and 80:
1 1 1 2 1 2 1 2 1 2 1 2 1 2 1 2 1 2
Page 81 and 82:
Flow Control Valves FULLY ADJUSTABL
Page 83 and 84:
Flow Control Valves FIXED ORIFICE,
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Flow Control Valves VENTABLE, FIXED
Page 91 and 92:
Flow Control Valves, Electro-Propor
Page 93 and 94:
3 3 3 3 4 2 4 2 4 2 4 2 Flow Divide
Page 95 and 96:
Flow Divider / Combiner Valves DIVI
Page 97 and 98:
Flow Divider / Combiner Valves DIVI
Page 99 and 100: 4 4 T-8A Cav 4 2 1 2 1 2 1 3 3 3 3
Page 101 and 102: Logic Elements BALANCED POPPET, NOR
Page 109 and 110: Logic Elements UNBALANCED POPPET, V
Page 111 and 112: Logic Elements UNBALANCED POPPET, P
Page 113 and 114: Logic Elements NORMALLY CLOSED, MOD
Page 115 and 116: Logic Elements BI-DIRECTIONAL, MODU
Page 117 and 118: 1 1 4 T-8A 4 T-8A 2 1 3 2 1 3 2 1 3
Page 119 and 120: Directional Valves 2-WAY AND 3-WAY,
Page 121 and 122: Directional Valves 2-WAY AND 3-WAY
Page 123 and 124: Directional Valves 2-WAY AND 3-WAY,
Page 125 and 126: Directional Valves 3-WAY, 2-POSITIO
Page 127 and 128: Directional Valves 2-WAY POPPET, WI
Page 129 and 130: Directional Valves 3-POSITION, 4-WA
Page 131 and 132: 2 2 1 Solenoid Operated Cartridge V
Page 133 and 134: Solenoid Operated Cartridge Valves
Page 141 and 142: 1 2 2 1 2 Air Pilot 2 1 Normally Op
Page 143 and 144: Pilot Control Valves DIRECT ACTING,
Page 145 and 146: Pilot Control Valves FLOW CONTROL,
Page 147 and 148: Pilot Control Valves 2-WAY, HYDRAUL
Page 149: Pilot Control Valves 2-WAY, AIR OPE
Page 153 and 154: Pilot Control Valves 3-WAY, 2-POSIT
Page 155 and 156: 1 Ext. 2 1 2 Ext. 1 2 3 1 2 3 2 4 3
Page 157 and 158: Shuttle Valves BACK-TO-BACK CHECK/S
Page 159 and 160: Shuttle Valves BACK-TO-BACK CHECK/S
Page 161 and 162: Shuttle Valves HIGH SIDE, 3-POSITIO
Page 163 and 164: 2 1 3 2 2 1 3 2 1 2 1 4 2 3 1 3 1 I
Page 165 and 166: Circuit Savers AIR BLEED AND START-
Page 167 and 168: Circuit Savers CHECK, PILOT-TO-CLOS
Page 169 and 170: Circuit Savers ACCUMULATOR SENSE, P
Page 171 and 172: 1 1 1 1 2 2 2 2 4 T-8A 4 3 3 3 3 In
Page 173 and 174: Hybrid Valves DIRECT ACTING RELIEF,
Page 175 and 176: Hybrid Valves PILOT OPERATED, BALAN
Page 177 and 178: Int’l Shortcut Catalogue #999-901
Page 179 and 180: Cartridge Control Kits Service Kit
Page 181 and 182: Cartridge Control Kits Service Kit
Page 183 and 184: Cavity Plugs It is sometimes desira
Page 185 and 186: Cavity Plugs Plugs for Six Port Cav
Page 187 and 188: Sun Coil Options for Solenoids (Met
Page 189 and 190: Sun Coil Options with Embedded Elec
Page 191 and 192: Sun Coil 790-***** Part Numbering S
Page 193 and 194: Sun Model Code System Sun cartridge
Page 195 and 196: Model Code Index Model Code Cavity
Page 197 and 198: Model Code Index Model Code Cavity
Page 199 and 200: Warranty Sun Hydraulics Limited man
Page 201:
Mexico COUNTRY DISTRIBUTOR Componen
show all

INT'L Shortcut Cartridge Catalogue - Bibus SK, s.r.o.

Create successful ePaper yourself

Delete template?

Save as template?