Hitachi ZX14-27 -3 - One Call Hire

More documents

Recommendations

Info

MACHINE NUMBERSEngineTYPE:MFG. NO.:ZX14-3, 16-3, 18-3M1NC-00-003Travel MotorTYPE:MFG. NO.:ZX27-3M1NC-00-015M1NC-00-004Swing MotorTYPE:MFG. NO.:M1NC-00-005
MACHINE NUMBERSHydraulic PumpTYPE:MFG. NO.:ZX14-3, 16-3, 18-3M1NC-00-006ZX27-3M1NC-00-016
Page 1 and 2: ZX14-3 • ZX16-3 • ZX18-3 • ZX
Page 3: INDEXEM1NC-EN3-1MACHINE NUMBERSSAFE
Page 6 and 7: CONTENTSBREAK-IN ..................
Page 8 and 9: CONTENTSMEMO ......................
Page 12 and 13: MACHINE NUMBERSMEMO ...............
Page 14 and 15: SAFETYFollow Safety Instructions•
Page 16 and 17: SAFETYTidy Up Inside Operator’s S
Page 18 and 19: SAFETYMove and Operate Machine Safe
Page 20 and 21: Precautions for OperationsdWARNING:
Page 22 and 23: SAFETYEquipment of OPG• In case t
Page 25 and 26: SAFETYAvoid Injury from Rollaway Ac
Page 27 and 28: SAFETYKeep Personnel Clear from Wor
Page 29 and 30: SAFETYDig with Caution• Accidenta
Page 31 and 32: SAFETYPark Machine Safely• Unless
Page 33 and 34: SAFETYPractice Safe Maintenance•
Page 35 and 36: SAFETYStay Clear of Moving Parts•
Page 37 and 38: SAFETYReplace Rubber Hoses Periodic
Page 39 and 40: Check Heat Shield Covers around Eng
Page 41 and 42: SAFETYPrecautions for Welding and G
Page 43 and 44: SAFETYHandle Chemical Products Safe
Page 45 and 46: SAFETY SIGNSAll safety signs and th
Page 47 and 48: SAFETY SIGNS• Stand clear of the
Page 49 and 50: SAFETY SIGNSSS-1710• Serious inju
Page 51 and 52: SAFETY SIGNS• Personal injury may
Page 53 and 54: SAFETY SIGNSZX27-3SS3118030ROPS Cab
Page 55 and 56: COMPONENTS NAMEComponents NameZX14-
Page 57 and 58: Pedals, Levers and Monitor PanelOPE
Page 59 and 60: OPERATOR'S STATIONKey Switch1- OFF
Page 61 and 62:
OPERATOR'S STATIONEngine Oil Pressu
Page 63 and 64:
OPERATOR'S STATIONRadio (ZX14-3, 16
Page 65 and 66:
OPERATOR'S STATIONRadio Operation1.
Page 67 and 68:
OPERATOR'S STATIONOpening/Closing C
Page 69 and 70:
Emergency Exit (ZX14-3, 16-3, 18-3
Page 71 and 72:
OPERATOR'S STATIONAdjusting Operato
Page 73 and 74:
OPERATOR'S STATIONSeat Belt21dWARNI
Page 75 and 76:
Cab Door Release Lever (ZX14-3, 16-
Page 77 and 78:
BREAK-INBreaking in New MachineIMPO
Page 79 and 80:
Before Starting Engine1. Check that
Page 81 and 82:
Starting in Cold Weather ZX14-3, 16
Page 83 and 84:
Check Machine After Starting Engine
Page 85 and 86:
OPERATING ENGINEStopping EngineStop
Page 87 and 88:
DRIVING MACHINETravel LeversTravel
Page 89 and 90:
DRIVING MACHINETravel Mode Switch (
Page 91 and 92:
DRIVING MACHINETowing MachineIn cas
Page 93 and 94:
Parking and Stopping on SlopesdWARN
Page 95 and 96:
OPERATING MACHINEControl Lever (ISO
Page 97 and 98:
Auxiliary PedalOPERATING MACHINEUse
Page 99 and 100:
OPERATING MACHINEPrecautions for Bl
Page 101 and 102:
Extending / Retracting Blade Width
Page 103 and 104:
dBefore Starting Operation:OPERATIN
Page 105 and 106:
OPERATING MACHINEOperating Backhoe
Page 107 and 108:
OPERATING MACHINEAvoid Striking wit
Page 109 and 110:
Precautions for Using Bucket HookdO
Page 111 and 112:
OPERATING MACHINEUsing Rubber Crawl
Page 113 and 114:
OPERATING MACHINEPipings for Breake
Page 115 and 116:
OPERATING MACHINE3. Do not operate
Page 117 and 118:
Precautions for Crusher OperationOP
Page 119 and 120:
OPERATING MACHINEEmergency Boom Low
Page 121 and 122:
TRANSPORTINGTransporting by RoadWhe
Page 123 and 124:
Securing Machine to Trailer for Tra
Page 125 and 126:
Lifting Machine with CranedTRANSPOR
Page 127 and 128:
MAINTENANCEProceduresIMPORTANT:Neve
Page 129 and 130:
MAINTENANCEOpening/Closing Engine A
Page 131 and 132:
Opening/Closing Right Side Covers (
Page 133 and 134:
MAINTENANCEZX27-3Arm CylinderBoomWo
Page 135 and 136:
MAINTENANCEMaintenance GuideA. Grea
Page 137 and 138:
MAINTENANCEH. Electrical System (Se
Page 139 and 140:
MAINTENANCEFuel OilIMPORTANT:Use on
Page 141 and 142:
MAINTENANCEA. Greasing1Front Joint
Page 143 and 144:
MAINTENANCE2.6 Swing cylinderSwing
Page 145 and 146:
MAINTENANCE4Swing Bearing--- every
Page 147 and 148:
MAINTENANCEB. Engine1Engine Oil---
Page 149 and 150:
MAINTENANCE6. Remove oil filter (5)
Page 151 and 152:
Change Gear Oil --- every 1000 hour
Page 153 and 154:
MAINTENANCED. Hydraulic SystemdInsp
Page 155 and 156:
MAINTENANCE2dDrain Hydraulic Oil Ta
Page 157 and 158:
5. Slowly loosen drain plug (2) on
Page 159 and 160:
MAINTENANCE4Clean Suction Filter---
Page 161 and 162:
MAINTENANCE6Replace Pilot Filter---
Page 163 and 164:
7dCheck Hoses and Lines--- daily---
Page 165 and 166:
MAINTENANCELinesInterval(Hours)Dail
Page 167 and 168:
Quick Coupler1. Connection Procedur
Page 169 and 170:
MAINTENANCEfNOTE:When disconnecting
Page 171 and 172:
MAINTENANCE1Check Water Separator--
Page 173 and 174:
MAINTENANCE3Replace Fuel Filter---
Page 175 and 176:
F. Air Cleaner1ddClean Air Cleaner
Page 177 and 178:
MAINTENANCEG. Cooling SystemfNOTE:W
Page 179 and 180:
MAINTENANCE1Check Coolant Level---
Page 181 and 182:
MAINTENANCEZX27-31. Loosen nut (2)
Page 183 and 184:
MAINTENANCE3. Remove the radiator c
Page 185 and 186:
MAINTENANCEH. Electrical SystemIMPO
Page 187 and 188:
Check Electrolyte Specific GravityM
Page 189 and 190:
MAINTENANCE2Replacing Fuses1. If an
Page 191 and 192:
MAINTENANCE3. Clean shank (6) surfa
Page 193 and 194:
MAINTENANCE3Adjust Track Sag (Rubbe
Page 195 and 196:
MAINTENANCE4Replace Rubber TrackdWA
Page 197 and 198:
MAINTENANCE5Check Track Sag (Steel
Page 199 and 200:
dConverting the TrackWARNING:• Co
Page 201 and 202:
MAINTENANCE6Clean Cab Floor (Cab Eq
Page 203 and 204:
13Check Tightening Torque of Bolts
Page 209 and 210:
MAINTENANCE UNDER SPECIAL ENVIRONME
Page 211 and 212:
STORAGEStoring Machine1. Thoroughly
Page 213 and 214:
TROUBLESHOOTINGImpossible to Start
Page 215 and 216:
TROUBLESHOOTINGEngineProblem Cause
Page 217 and 218:
TROUBLESHOOTINGElectrical SystemPro
Page 219 and 220:
TROUBLESHOOTINGControl LeversProble
Page 221 and 222:
TROUBLESHOOTINGHydraulic SystemProb
Page 223 and 224:
SPECIFICATIONSSpecifications ZX14-3
Page 225 and 226:
Bucket Types and Applications ZX14-
Page 227 and 228:
SPECIFICATIONSWorking Ranges ZX16-3
Page 229 and 230:
SPECIFICATIONSSpecifications ZX18-3
Page 231 and 232:
Bucket Types and Applications ZX18-
Page 233 and 234:
SPECIFICATIONSWorking Ranges ZX27-3
Page 235 and 236:
Noise Level Results (2000/14/CE, ar
Page 237 and 238:
Ignition Block System (Optional)Pre
Page 239 and 240:
OPTIONAL ATTACHMENT AND DEVICENumer
Page 241 and 242:
OPTIONAL ATTACHMENT AND DEVICEMetho
Page 243 and 244:
OPTIONAL ATTACHMENT AND DEVICEAlarm
Page 245 and 246:
INDEXAAdjust Operator’s Seat.....
Page 247 and 248:
INDEXReplace Air Cleaner Element...
Page 249:
The EC Declaration of Conformity in
show all

Hitachi ZX14-27 -3 - One Call Hire

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?