052930E-002One Touch non auto - Carefree of Colorado

ONE-Touch 12Volt Patio Awning TroubleshootingAWNING RETRACTS MORE THAN 30SECONDS (ELECTRICAL)SEE AWNING WON'TROLL IN(MECHANICAL)YESCHECK VOLTAGE AT MOTORCOVER TERMINALS (WITHMETER) IS IT GREATER THAN11.0V WHILE PUSHING RETRACTBUTTON?NOCONTROL MODULEUNPLUG RAFTER HARNESSPLUG FROM WALLRECEPTACLE ON RV. APPLY 12VOLTS DIRECTLY TOTERMINALS ON MOTORCOVERYESDOES AWNING RETRACT MORETHAN 30 SECONDS?APPLY 12V TORAFTER HARNESSPLUGFIGURE 2YESDOES AWNING RETRACT MORETHAN 30 SECONDS?RECONNECT RAFTERHARNESS PLUG TO OUTSIDEWALL RECEPTACLE.DISCONNECT 2 PIN MOTORPLUG FROM CONTROLMODULE AND APPLY 12VOLTS TO PLUGYESDOES AWNING RETRACT MORETHAN 30 SECONDS?NORECONNECT 2 PIN CONNECTOR TOCONTROL MODULE. ADJUST CURRENT LIMITPOT TO UPPER LIMITCHECK WIRE FOR AT LEAST 14GAUGE. CHECK ALLCONNECTIONS FROM 2-PINCONNECTOR TO OUTSIDE WALLRECEPTACLE. REPAIR ORREPLACE WIRE CONNECTIONS'A'AWNING RETRACTS MORE THAN30 SECONDS (MECHANICAL)REMOVE MOTOR COVER.DISCONNECT RAFTERHARNESS PLUG FROM RVWALL RECEPTACLE;DISCONNECT MOTORLEADS FROM COVERTERMINALS; CONNECT12V TO MOTOR LEADSYESDOES AWNING RETRACT MORETHAN 30 SECONDS?NORV MUST BELEVELLOOSEN LOWER CARRIAGEAND SHOCK COLLARYESDOES AWNING RETRACT MORETHAN 30 SECONDS?CHECK MOTOR LEADS FORGOOD CONNECTIONS.REPLACE MOTORADJUST RAFTER CARRIAGEAND COLLAR ON SHOCK PERINSTRUCTIONSYESIS DRIVE SHAFT BENT?NOYESARE THE ARMS BENT?NOREPLACE DRIVE SHAFTDOES AWNING RETRACT MORETHAN 30 SECONDS?YESIS THIS AN A&EROLLBAR ?NOSEEREPLACE ARM ASSY.CHECK TIMING.MEASURE DISTANCEFROM CENTER OFROLL BAR TO BOTTOMBRACKET ON EACHARM. ADJUST ASNECESSARYYESREPLACE WITH CAREFREEROLL BAR'A'DOES AWNING RETRACT MORETHAN 30 SECONDS?NOSEE'A'052958-001