Spicer Tandem Drive Axles Service Manual

More documents

Recommendations

Info

This page intentionally left blank.
General Inspection General Information The description and specifications contained in this service publication are current at the time of printing. Dana Corporation reserves the right to discontinue or to modify its models and/or procedures and to change specifications at any time without notice. Any reference to brand names in this publication is made simply as an example of the types of tools and materials recommended for use and should not be considered an endorsement. Equivalents, if available, may be used. Important Notice This symbol is used throughout this manual to call attention to procedures where carelessness or failure to follow specific instructions may result in personal injury and/or component damage. Departure from the instructions, choice of tools, materials and recommended parts mentioned in this publication may jeopardize the personal safety of the service technician or vehicle operator. Always use genuine Dana replacement parts. WARNING: Failure to follow indicated procedures creates a high risk of personal injury to the servicing technician. CAUTION: Failure to follow indicated procedures may cause component damage or malfunction. IMPORTANT: Highly recommended procedures for proper service of this unit. Note: Additional service information not covered in the service procedures. Tip: Helpful removal and installation procedures to aid in the service of this unit. i General Information
Page 1: Spicer ® Tandem Drive Axles Servic
Page 5 and 6: Introduction ......................
Page 7 and 8: Model Identification Drive Axle 1 -
Page 9 and 10: Failure Analysis Failure analysis i
Page 11 and 12: Inspection Clean 1. Wash steel part
Page 13 and 14: Differential Carrier Assembly - Par
Page 15 and 16: Differential Carrier Assembly Insta
Page 17 and 18: Power Divider - Parts Exploded View
Page 19 and 20: 10. Remove the thrust washer and he
Page 21 and 22: Lube Manifold Disassembly 1. Discon
Page 23 and 24: Pump Assembly Use these instruction
Page 25 and 26: Helical Gear Bushing Replacement: a
Page 27 and 28: 17. A. For axles built before Augus
Page 29 and 30: 6. Mount the differential carrier i
Page 31 and 32: Failure to de-stake the pinion nut
Page 33 and 34: Drive Pinion Drive Pinion Overhaul
Page 35 and 36: 5. For Forward Carriers Only: Insta
Page 37 and 38: 14. With 5 tons of force on the pre
Page 39 and 40: CAUTION The stake must be deep enou
Page 41 and 42: Wheel Differential Disassembly Duri
Page 43 and 44: Wheel Differential Assembly IMPORTA
Page 45 and 46: Wheel Differential Assembly Set Bac
Page 47 and 48: 9. With a dial indicator, check the
Page 49 and 50: 21. When contact pattern is correct
Page 51 and 52: Adjust Ring Gear Position (Backlash
Page 53 and 54:
Install and Adjust Wheel Differenti
Page 55 and 56:
Remove Output Shaft Assembly Note:
Page 57 and 58:
Output Shaft Assembly & Rear Cover
Page 59 and 60:
Measure Correct endplay for a new a
Page 61 and 62:
Guidelines for Reusing Yoke CAUTION
Page 63 and 64:
Housing Breather Dana has an axle b
Page 65 and 66:
Remove and Overhaul Wheel End Seal
Page 67 and 68:
Never tighten the inner nut for ali
Page 69 and 70:
Lubricate Wheel End CAUTION Before
Page 71 and 72:
General Lubrication Information The
Page 73 and 74:
Change Lube Drain Drain when the lu
Page 75 and 76:
Tandem Rear Axles Installation Angl
Page 77 and 78:
Theory of Operation Power Divider O
Page 79 and 80:
Operate Wheel Differential Assembly
Page 81 and 82:
Wheel Differential Lock The Dana Wh
Page 83 and 84:
Power Divider - Parts Exploded View
Page 85 and 86:
Parts Identification Rear Axle Pini
Page 87 and 88:
Parts Identification Housing and Ou
Page 89 and 90:
This page intentionally left blank.
show all

Spicer Tandem Drive Axles Service Manual

Create successful ePaper yourself

Delete template?

Save as template?