Installation Instructions Stationary Weighpad_ELWC - WIM

More documents

Recommendations

Info

! Take the frame out of recess and drill anchor holes. Start vertically to about ½” depth, then slowly turn to a 45° angle. Figure 10 - Drilling Frame Anchor Holes123-429-900-970.jpg ! Clean frame recess and anchor holes with compressed air. Dry with a propane gas burner if necessary. The surface must be dry and clean. Epoxy will only adhere to dry and clean rock, concrete, or asphalt surface. Figure 11 - Drying Recess with Propane123-429-901-110.jpg 14 M&E Vendor Documents Control Systems Section 9.11.3 Page 18 of 36
! For inline weighpads that are inline or in adjacent lanes, install a 2" conduit or appropriate length between the weighpads. Figure 12 - 2" In-line Cable and Drainage Conduit ! Install the drain and cable conduit, if not already stubbed-in as with new concrete installations. ! Place frame in recess. Adjust the height of the frame so that studs are 1/16" or less below road surface. All studs must be below the road surface, but not more than 3/32". Tighten lower nuts against leveling aid, and verify frame height. 15 M&E Vendor Documents Control Systems Section 9.11.3 Page 19 of 36
Page 1 and 2: Manual, Weighpad and Frame Installa
Page 3 and 4: TABLE OF CONTENTS 1. GENERAL INFORM
Page 5 and 6: 1. GENERAL INFORMATION The stationa
Page 7 and 8: Trucks, when passing the measuring
Page 9 and 10: Power Tools: Item Quantity Descript
Page 11 and 12: 13 1 Spray paint (epoxy paint) with
Page 13 and 14: 3. INSTALLATION PROCEDURE The follo
Page 15 and 16: Figure 6 - Cutting Frame Recess 123
Page 17: ! Check depth of the cutout by inse
Page 21 and 22: ” Do not use epoxy remaining on t
Page 23 and 24: ! Insert anchors down as far as pos
Page 25 and 26: ! At each mounting stud, measure ne
Page 27 and 28: ! Set weighpad onto two wooden piec
Page 29 and 30: 4. APPENDIX E-Bond G-100 Epoxy 25 E
Page 31 and 32: 27 Ebond G100 Page3.jpg M&E Vendor
Page 33 and 34: 29 Ebond G100 Page5.jpg M&E Vendor
Page 35 and 36: 5. APPENDIX SITE SURVEY FORM Wim Si

Installation Instructions Stationary Weighpad_ELWC - WIM

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?