Daf LF.book - Peterbilt Motors Company

More documents

Recommendations

Info

Technical Data and Identification STEERING GEAR Hydraulic power steering ATF DEXRON III with valid approval number CAB TILTING MECHANISM Cab tilting pump The following may be used: Oil must meet MIL-H-5606C ESSO Univis J13 FINA Hydran B5219B TEXACO Aircraft Hydraulic Oil 5606G TOTAL Aerohydraulic 520 CLUTCH Hydraulic clutch Brake fluid DOT 3 or DOT 4 248
XXXXXXX Technical Data and Identification CHASSIS NUMBER The chassis number is stamped on the right chassis side member close to the front axle. D0 00 579 D0 00 597 ENGINE NUMBER The engine number is stamped on the front right of the engine. Cummins Cummins Engine <strong>Company</strong> Inc. Box 3005 Columbus, Indiana 47202-3005 Warning injury may result and warranty is voided if fuel rate or rpm or altitudes exceed published maximum values for this model and application. C.I.D./L CPL Engine Serial No. Family Cust. spec. Engine model Low idle RPM Valve lash cold Int. Exh. Fuel rate at rated HP mm3/st Date of Mig Made in Great Britain by Cummins Engine Co Ltd Firing Order Timing-TDC Rated HP/KW at RPM D0 00 599 249
Page 1 and 2:
Table of contents Warnings and safe
Page 3 and 4:
Table of contents Seats Roof consol
Page 5 and 6:
Table of contents Coupling and unco
Page 7 and 8:
Table of contents Emergency repairs
Page 9 and 10:
Table of contents Consumer Informat
Page 11 and 12:
WHY THIS HANDBOOK IS SO IMPORTANT!
Page 13 and 14:
Warnings and Safety Regulations 13
Page 15 and 16:
Warnings and Safety Regulations D00
Page 17 and 18:
Warnings and Safety Regulations War
Page 19 and 20:
Warnings and Safety Regulations Mai
Page 21 and 22:
Warnings and Safety Regulations TEC
Page 23 and 24:
Warnings and Safety Regulations Cha
Page 25 and 26:
Warnings and Safety Regulations Mob
Page 27 and 28:
Warnings and Safety Regulations - W
Page 29 and 30:
Warnings and Safety Regulations Ins
Page 31 and 32:
Alarm System 31
Page 33 and 34:
Alarm System The system is now full
Page 35 and 36:
Alarm System DEACTIVATION LOADSPACE
Page 37 and 38:
Alarm System LOSS OF HAND-HELD TRAN
Page 39 and 40:
Cab, Instruments and Controls 39
Page 41 and 42:
Cab, Instruments and Controls DOORS
Page 43 and 44:
Cab, Instruments and Controls D0 00
Page 45 and 46:
Cab, Instruments and Controls On so
Page 47 and 48:
Cab, Instruments and Controls D0 00
Page 49 and 50:
Cab, Instruments and Controls 1 /2
Page 51 and 52:
Cab, Instruments and Controls INTER
Page 53 and 54:
Cab, Instruments and Controls DASHB
Page 55 and 56:
Cab, Instruments and Controls 1 Ins
Page 57 and 58:
Cab, Instruments and Controls A Spe
Page 59 and 60:
Cab, Instruments and Controls F. TR
Page 61 and 62:
Cab, Instruments and Controls A1 A2
Page 63 and 64:
Cab, Instruments and Controls B1. F
Page 65 and 66:
Cab, Instruments and Controls H5. R
Page 67 and 68:
Cab, Instruments and Controls 2 Dim
Page 69 and 70:
Cab, Instruments and Controls 5. FO
Page 71 and 72:
Cab, Instruments and Controls 17. A
Page 73 and 74:
Cab, Instruments and Controls 4. Co
Page 75 and 76:
Cab, Instruments and Controls To ac
Page 77 and 78:
Cab, Instruments and Controls CENTR
Page 79 and 80:
Cab, Instruments and Controls 7 Ash
Page 81 and 82:
Cab, Instruments and Controls 11. S
Page 83 and 84:
Cab, Instruments and Controls ROOF
Page 85 and 86:
Cab, Instruments and Controls LEFT-
Page 87 and 88:
Cab, Instruments and Controls RIGHT
Page 89 and 90:
Cab, Instruments and Controls ADJUS
Page 91 and 92:
Cab, Instruments and Controls 2. Th
Page 93 and 94:
Cab, Instruments and Controls Progr
Page 95 and 96:
Seats 95
Page 97 and 98:
Seats SEAT SETTINGS Note: In case o
Page 99 and 100:
Seats 6 Entry/exit aid - Knob down
Page 101 and 102:
Seats Checking the seat belts - Giv
Page 103 and 104:
Master Display 103
Page 105 and 106:
Master Display LAYOUT OF MASTER DIS
Page 107 and 108:
Master Display If the indication ba
Page 109 and 110:
Master Display By turning the menu
Page 111 and 112:
Master Display Main menu Sub-menu 1
Page 113 and 114:
Master Display WARNING SYMBOLS Red
Page 115 and 116:
Master Display Yellow warnings Alte
Page 117 and 118:
Master Display Trailing axle fault
Page 119 and 120:
Inspections and Maintenance 119
Page 121 and 122:
Inspections and Maintenance OPENING
Page 123 and 124:
o -25 C o -11 F Inspections and Mai
Page 125 and 126:
Inspections and Maintenance D0 00 5
Page 127 and 128:
Inspections and Maintenance DRIVER'
Page 129 and 130:
Inspections and Maintenance Note: B
Page 131 and 132:
Inspections and Maintenance A B D0
Page 133 and 134:
Inspections and Maintenance - Check
Page 135 and 136:
Inspections and Maintenance LUBRICA
Page 137 and 138:
Inspections and Maintenance - Do no
Page 139 and 140:
Inspections and Maintenance Cleanin
Page 141 and 142:
Inspections and Maintenance MAINTEN
Page 143 and 144:
Coupling and Uncoupling 143
Page 145 and 146:
Coupling and Uncoupling A D000424 5
Page 147 and 148:
Coupling and Uncoupling Trailer cou
Page 149 and 150:
Coupling and Uncoupling FIFTH WHEEL
Page 151 and 152:
Coupling and Uncoupling JOST fifth
Page 153 and 154:
Coupling and Uncoupling 2 1 2 Locki
Page 155 and 156:
Coupling and Uncoupling Unlocking -
Page 157 and 158:
Coupling and Uncoupling - red = eme
Page 159 and 160:
Coupling and Uncoupling } Consequen
Page 161 and 162:
Coupling and Uncoupling D000505 CON
Page 163 and 164:
Driving 163
Page 165 and 166:
Driving STEERING LOCK/CONTACT/START
Page 167 and 168:
Driving In case of an optional engi
Page 169 and 170:
Driving Activating the engine speed
Page 171 and 172:
Driving ON OFF B RES O SET C D 1 2
Page 173 and 174:
Driving Note: The function of key (
Page 175 and 176:
Driving DIFFERENTIAL LOCK The rear
Page 177 and 178:
Driving } In the event of a serious
Page 179 and 180:
Driving ABS warning symbol in maste
Page 181 and 182:
Driving - when the engine speed dro
Page 183 and 184:
Manual Gearbox 183
Page 185 and 186:
Manual Gearbox ZF 6S-850 gearbox Th
Page 187 and 188:
Manual Gearbox - Pre-selection is p
Page 189 and 190:
Automatic Gearbox 189
Page 191 and 192:
Automatic Gearbox therefore advisab
Page 193 and 194:
Automatic Gearbox Neutral Drive Rev
Page 195 and 196:
Automatic Gearbox Normal program Th
Page 197 and 198: Automatic Gearbox Gearbox The ECU w
Page 199 and 200: Air suspension 199
Page 201 and 202: Air suspension REMOTE CONTROL Remot
Page 203 and 204: Air suspension ENGAGING AIR SUSPENS
Page 205 and 206: Emergency repairs 205
Page 207 and 208: Emergency repairs } } } If the vehi
Page 209 and 210: Emergency repairs - Tilt the cab ba
Page 211 and 212: Emergency repairs REPLACING THE FUE
Page 213 and 214: A B D0 00 620 Emergency repairs DRA
Page 215 and 216: Emergency repairs 3. Lower the spar
Page 217 and 218: Emergency repairs } Always use stan
Page 219 and 220: Emergency repairs Installing the wh
Page 221 and 222: Emergency repairs 9. Retorque the w
Page 223 and 224: Emergency repairs Tractors may be f
Page 225 and 226: Emergency repairs Dipped beam 1. Ti
Page 227 and 228: Emergency repairs Direction indicat
Page 229 and 230: Emergency repairs 1. Remove the tra
Page 231 and 232: Emergency repairs Fuses E004 E005 E
Page 233 and 234: Emergency repairs Fuses E283 E284 E
Page 235 and 236: Technical Data and Identification 2
Page 237 and 238: Technical Data and Identification O
Page 239 and 240: Technical Data and Identification W
Page 241 and 242: Technical Data and Identification T
Page 243 and 244: Technical Data and Identification A
Page 245 and 246: Technical Data and Identification L
Page 247: Technical Data and Identification D
Page 251 and 252: Technical Data and Identification V
Page 253 and 254: Consumer Information 253
Page 255 and 256: Consumer Information campaign. Howe
Page 257 and 258: Alphabetical index 257
Page 259 and 260: Alphabetical index Fifth wheel 134
show all

Daf LF.book - Peterbilt Motors Company

Create successful ePaper yourself

Delete template?

Save as template?