Hermetic Compressor - Tecumseh

More documents

Recommendations

Info

When it comes to compressors... Think Safety! Be alert for sounds of arcing (sizzling, sputtering or popping) inside the compressor. IMMEDIATELY GET AWAY if you hear these sounds. Disconnect ALL electrical power before removing the protective thermal cover. Never energize the system unless • the protective terminal cover is securely fastened and • the compressor is properly connected to ground Never reset a breaker or replace a fuse without first checking for a ground fault (also known as a short circuit to ground). <strong>Tecumseh</strong> Products Company 1136 Oak Valley Drive Ann Arbor, MI 48108 800.211.3427 | 734.585.9500 www.tecumseh.com ©2011 <strong>Tecumseh</strong> Products Company. All rights reserved. Publication No. TR - 103
Page 1:
Hermetic Compressor Service Handboo
Page 5 and 6:
Handbook Purpose and Description Te
Page 7:
Table of Contents Servicing 29 Intr
Page 10 and 11:
2 SERVICE HANDBOOK Introduction Tec
Page 12 and 13:
4 SERVICE HANDBOOK Refrigerants and
Page 14 and 15:
6 SERVICE HANDBOOK Prevention of Wa
Page 17 and 18:
Model and Application Chapter 2
Page 19 and 20:
11 AEA4440YXA XC Condensing Unit Mo
Page 21:
13 Table 2-1: Serial Label Month Id
Page 24 and 25:
16 SERVICE HANDBOOK Single-phase Co
Page 26 and 27:
18 SERVICE HANDBOOK Minimum startin
Page 28 and 29:
20 SERVICE HANDBOOK External Line-B
Page 30 and 31:
22 SERVICE HANDBOOK Relay Type Tabl
Page 32 and 33:
24 SERVICE HANDBOOK FIGURE 3-16: Po
Page 34 and 35:
26 SERVICE HANDBOOK Capacitor Type
Page 37 and 38:
Servicing Chapter 4
Page 39 and 40:
Servicing 31 Introduction to Servic
Page 41 and 42:
33 Step 1: Check for a Ground Fault
Page 43 and 44:
35 Table 4-1: Troubleshooting Chart
Page 45 and 46:
37 Table 4-1: Troubleshooting Chart
Page 47 and 48:
39 Complaint Possible Causes Respon
Page 49 and 50:
41 electrocution, always follow the
Page 51 and 52:
43 Checking for Other Electrical Pr
Page 53 and 54:
45 Step 1: Before Continuing with T
Page 55 and 56:
47 Step 1: Before Continuing Troubl
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
53 This CSIR compressor has the fol
Page 63 and 64:
55 Step 6: Check Start Capacitor CA
Page 65 and 66:
Page 67 and 68:
59 This CSR compressor has the foll
Page 69 and 70: 61 to the OEM service information.
Page 71 and 72: 63 Step 1: Before Continuing with T
Page 81 and 82: Installation and Replacement Chapte
Page 83 and 84: 75 Discharge Tube Discharge Tube AK
Page 85 and 86: 77 Table 5-1: R-22 Refrigerant Line
Page 87 and 88: 79 Table 5-4: R-134a Refrigerant Li
Page 89 and 90: 81 Table 5-7: R-404A Refrigerant Li
Page 91 and 92: 83 7. If a suction line accumulator
Page 93 and 94: 85 WARNING! Never use a compressor
Page 95: 87 Replacing Compressors in Water-U
Page 98 and 99: 90 SERVICE HANDBOOK Control of Liqu
Page 100 and 101: 92 SERVICE HANDBOOK Crankcase Heate
Page 102 and 103: 94 SERVICE HANDBOOK Starting a Syst
Page 104 and 105: 96 SERVICE HANDBOOK FIGURE 6-10: Li
Page 106 and 107: 98 SERVICE HANDBOOK Accumulator Sel
Page 109 and 110: Appendix
Page 111 and 112: 103 Condenser Fan Receiver Tank Hea
Page 113 and 114: 105 Reciprocating Compressor FIGURE
Page 115 and 116: 107 Table A-1: continued Capillary
Page 117 and 118: 109 Source Table A-4: Most Common O
show all

Hermetic Compressor - Tecumseh

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?