- Page 1: READ THIS MANUAL CAREFULLY!
- Page 12 and 13: Read this manual and all labels car
- Page 14 and 15: the hill when possible. Always foll
- Page 16: We are concerned with the safety of
- Page 43 and 44: Always wear clothing suited to the
- Page 45 and 46: Top speed is normally limited when
- Page 47 and 48: The front brake lever is located on
- Page 49 and 50: An over-full master cylinder may ca
- Page 51 and 52: The choke assists in starting a col
- Page 53 and 54: The transmission gear selector is l
- Page 55 and 56: Extending the starter rope too far
- Page 57 and 58: When the switch is set to LOCK , th
- Page 59 and 60: Functions of the respective switch
- Page 61 and 62:
This indicator light comes on when
- Page 63 and 64:
The break-in period for your new AT
- Page 66 and 67:
Engine exhaust contains poisonous c
- Page 68 and 69:
See the Break-In Period section pri
- Page 70 and 71:
Overloading the vehicle or carrying
- Page 72 and 73:
Your ATV has been designed to carry
- Page 74 and 75:
To make a turn, steer in the direct
- Page 76 and 77:
Whenever traveling uphill, follow t
- Page 78 and 79:
2. Lean into the hill, transferring
- Page 80 and 81:
7. Restart the engine, while holdin
- Page 82 and 83:
Be alert! Look ahead and learn to r
- Page 84 and 85:
Avoid parking on an incline if poss
- Page 86 and 87:
This procedure should be practiced
- Page 88 and 89:
Frequent immersion in mud, water or
- Page 90 and 91:
Coolant Daily Check level daily, ch
- Page 92 and 93:
Oil filter change 100H 6 M 620 (100
- Page 94 and 95:
Check and lubricate all components
- Page 96 and 97:
7. If the engine oil is at or below
- Page 98 and 99:
The rear gear case must be checked
- Page 100 and 101:
4. Install the drain bolt and tight
- Page 102 and 103:
5. Disconnect the hose on the coola
- Page 104 and 105:
Check the protective boots for hole
- Page 106 and 107:
3. Install the spark plug and tight
- Page 108 and 109:
12. Install the seat. The air filte
- Page 110 and 111:
After riding in water deep enough t
- Page 112 and 113:
Adjust the engine idling speed befo
- Page 114 and 115:
Observe these precautions: 1. When
- Page 116 and 117:
The rear brake lever free play c sh
- Page 118 and 119:
Turn the adjusting nut while holdin
- Page 120 and 121:
2. Lower the ATV so that the wheel
- Page 122 and 123:
To prevent accidental short-circuit
- Page 124 and 125:
If the tail/brake light bulb burns
- Page 126 and 127:
If your vehicle becomes immersed, m
- Page 128 and 129:
Starting the engine during the stor
- Page 130 and 131:
If you choose not to use Fogging Oi
- Page 132 and 133:
Proper maintenance will protect chr
- Page 134 and 135:
Stuck in mud or snow. Climbing over
- Page 136 and 137:
Crankcase filled with water or fuel
- Page 138 and 139:
Kinked or plugged fuel vent line In
- Page 140:
Overheated engine Clean radiator sc