READ THIS MANUAL CAREFULLY! - Mojo Motorcycles

More documents

Recommendations

Info

Stuck in mud or snow. Climbing over large objects from a stopped position. Belt slippage from water or snow ingestion into the CVT system. Clutch malfunction. Poor engine performance. Shift the transmission to low range, and carefully use fast, aggressive throttle application to engage clutch. Excessive throttle may cause loss of control and vehicle overturn. Shift the transmission to low range, and carefully use fast, brief, aggressive throttle application to engage clutch. Excessive throttle may cause loss of control and vehicle overturn. Shift the transmission to park. Using the throttle, vary the engine RPM from idle to full throttle. Repeat several times as required. During this procedure, the throttle should not be held at the full position for more than 10seconds. Clutch seals should be inspected for damage if repeated leaking occurs. Contact your dealer for inspection of clutch components. Check for fouled plugs or foreign material in gas tank, fuel lines, or carburetor. Contact your dealer for service.
Contact your dealer for service if you're unable to identify solutions using the following charts. Tripped circuit breaker Low battery voltage Loose battery connections Loose solenoid connections Reset the breaker Recharge battery to 12.5 VDC Check all connections and tighten Check all connections and tighten Out of fuel Clogged fuel valve or filter Water is present in fuel Fuel valve is out of use Old or non-recommended fuel Fouled or defective spark plug(s) No spark to spark plug Refuel Inspect and clean or replace Drain the fuel system and refuel Replace Replace with new fuel Inspect plug(s), replace if necessary Inspect plug(s), verify stop switch is on
Page 1:
READ THIS MANUAL CAREFULLY!
Page 10 and 11:
You should review this information
Page 12 and 13:
Read this manual and all labels car
Page 14 and 15:
the hill when possible. Always foll
Page 16:
We are concerned with the safety of
Page 43 and 44:
Always wear clothing suited to the
Page 45 and 46:
Top speed is normally limited when
Page 47 and 48:
The front brake lever is located on
Page 49 and 50:
An over-full master cylinder may ca
Page 51 and 52:
The choke assists in starting a col
Page 53 and 54:
The transmission gear selector is l
Page 55 and 56:
Extending the starter rope too far
Page 57 and 58:
When the switch is set to LOCK , th
Page 59 and 60:
Functions of the respective switch
Page 61 and 62:
This indicator light comes on when
Page 63 and 64:
The break-in period for your new AT
Page 66 and 67:
Engine exhaust contains poisonous c
Page 68 and 69:
See the Break-In Period section pri
Page 70 and 71:
Overloading the vehicle or carrying
Page 72 and 73:
Your ATV has been designed to carry
Page 74 and 75:
To make a turn, steer in the direct
Page 76 and 77:
Whenever traveling uphill, follow t
Page 78 and 79:
2. Lean into the hill, transferring
Page 80 and 81:
7. Restart the engine, while holdin
Page 82 and 83:
Be alert! Look ahead and learn to r
Page 84 and 85: Avoid parking on an incline if poss
Page 86 and 87: This procedure should be practiced
Page 88 and 89: Frequent immersion in mud, water or
Page 90 and 91: Coolant Daily Check level daily, ch
Page 92 and 93: Oil filter change 100H 6 M 620 (100
Page 94 and 95: Check and lubricate all components
Page 96 and 97: 7. If the engine oil is at or below
Page 98 and 99: The rear gear case must be checked
Page 100 and 101: 4. Install the drain bolt and tight
Page 102 and 103: 5. Disconnect the hose on the coola
Page 104 and 105: Check the protective boots for hole
Page 106 and 107: 3. Install the spark plug and tight
Page 108 and 109: 12. Install the seat. The air filte
Page 110 and 111: After riding in water deep enough t
Page 112 and 113: Adjust the engine idling speed befo
Page 114 and 115: Observe these precautions: 1. When
Page 116 and 117: The rear brake lever free play c sh
Page 118 and 119: Turn the adjusting nut while holdin
Page 120 and 121: 2. Lower the ATV so that the wheel
Page 122 and 123: To prevent accidental short-circuit
Page 124 and 125: If the tail/brake light bulb burns
Page 126 and 127: If your vehicle becomes immersed, m
Page 128 and 129: Starting the engine during the stor
Page 130 and 131: If you choose not to use Fogging Oi
Page 132 and 133: Proper maintenance will protect chr
Page 136 and 137: Crankcase filled with water or fuel
Page 138 and 139: Kinked or plugged fuel vent line In
Page 140: Overheated engine Clean radiator sc
show all

READ THIS MANUAL CAREFULLY! - Mojo Motorcycles

Create successful ePaper yourself

Delete template?

Save as template?