MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

permission for drawl of 16 MGD of water. The wastewater generation will remain at37,715 m 3 /day. The existing wastewater treatment plant has a capacity to treat 85,000m 3 /day while the wastewater generation will be less than 38,000 m 3 /day. The boiler ashgeneration will increase from 140 tpd to 150 tpd during post project. This will be used inTNPL’s cement plant. The sludge from the DIP will be about 90 tpd and this will be usedas feed stock in TNPL’s cement plant.The Committee deliberated on the issues raised during the Public Hearing / PublicConsultation meeting conducted by the Tamil Nadu Pollution Control Board on 18 thMay,2012. The issues raised in the public hearing were regarding ccompliance to thepromises made earlier, falling of coal dust and lime dust in the houses, pollution ofground water, provision of Cauveri water for drinking, laying of pipelines for supply ofdrinking water, employment to land losers, roads etc.which were addressed in theEIA/EMP report.The Committee had sought the action plan for the disposal of RO rejects anddevelopment of 33% area under green belt, details of OHS of the workers, comparisonof AAQ data pre and post Mill expansion of existing unit at common locations,commitments made during public hearing and CSR activities carried out by TNPL in thelast 5 years. The above sought information was submitted by the proponent and found tobe satisfactory.After detailed deliberations, the Committee found the EIA/EMP report adequateand suggested to stipulate following specific conditions along with other environmentalconditions while considering for accord of environmental clearance:(i)(ii)(iii)(iv)(v)Compliance to all the specific and general conditions stipulated for the existingplant by the Central/State Government shall be ensured and regular reportssubmitted to the Ministry and its Regional Office at Bangalore.The project authority shall install multi cyclones, wet scrubbers with the boilers toachieve the particulate emission below 50 mg/Nm 3 . The emissions from chemicalrecovery section shall be controlled through primary and secondary venturiscrubbers.Data on ambient air, stack and fugitive emissions shall be regularly submittedonline to Ministry’s Regional office at Bangalore, SPCB and CPCB as well ashard copy once in six months and display data on RSPM, SO 2 and NOx outsidethe premises at the appropriate place for the general public.In case of treatment process disturbances/failure of pollution control equipmentadopted by the unit, the respective unit shall be shut down and shall not berestarted until the control measures are rectified to achieve the desired efficiency.The total water requirement (including existing) shall not exceed 52,800 m 3 /day.The industry shall ensure the compliance of the standards for discharge of thetreated effluent from the unit as stipulated under the EPA rules or SPCBwhichever is more stringent. The company shall make efforts to limit the waterconsumption upto 75 m 3 /tonne of product. Adequate steps including use ofmodern RO/UF based technologies should be used to increase recycling andreduce water consumption.
(vi)(vii)(viii)(ix)(x)(xi)(xii)(xiii)(xiv)(xv)(xvi)(xvii)Adequate number of influent and effluent quality monitoring stations shall be setup in consultation with the State Pollution Control Board and regular monitoringshall be carried out for all relevant parameters to maintain the effluent treatmentefficiency. Online flow meter, pH meter, conductivity meter etc. shall be installed.The report shall be submitted to Ministry’s Regional Office at Bangalore, SPCBand CPCB.Ground water quality study in and around the project area shall be conductedand report submitted to Ministry’s Regional Office at Bangalore, SPCB andCPCB.The company shall install Oxygen Delignification (ODL) Plant and shall maintainAOX below 1 kg/tonne of paper production.ECF technology shall be used and lime kiln shall be installed to manage limesludgeThe company shall submit the comprehensive water management plan alongwith monitoring plan for the ground water quality and the level, within threemonths from date of issue of this letter.The ash generated from the plant shall be disposed of in accordance with theprovisions of the Fly Ash Notification, 2009.The project authority shall dispose of hazardous waste as per the provision ofHazardous Wastes (Management, Handling and Transboundary Movement)Rules, 2008.The company shall develop green belt in 33% of the total land as per the CPCBguidelines to mitigate the effect of fugitive emissions.Occupational health surveillance of the workers shall be done on a regular basisand records maintained as per the Factories Act.The company shall make the arrangement for protection of possible fire hazardsduring manufacturing process in material handling.All the recommendations made in the Charter on Corporate Responsibility forEnvironment Protection (CREP) for the pulp and paper sector shall be strictlyimplemented.All the commitments made to the public during the Public Hearing / PublicConsultation meeting held on 18 th May,2012 shall be satisfactorily implementedand a separate budget for implementing the same should be allocated andinformation submitted to the Ministry’s Regional Office at Bangalore.(xviii) At least 5 % of the total cost of the project shall be earmarked towards theEnterprise Social Commitment based on Public Hearing issues and item-wisedetails along with time bound action plan shall be prepared and submitted to the
Page 1: MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5: 5. Regular monitoring of influent a
Page 6 and 7: The revised draft EIA/EMP report sh
Page 8 and 9: vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11: 4. Secondary fugitive emissions fro
Page 12 and 13: µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 16 and 17: Ministry’s Regional Office at Ban
Page 18 and 19: iv.Secondary fugitive emissions sha
Page 20 and 21: EIA/EMP. Leather/skin/hide processi
Page 22 and 23: By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25: y M/s K. P. R. Industries (India) L
Page 26 and 27: chlorine storage area shall be prov
Page 28 and 29: ii.Bag filter alongwith stack of ad
Page 30 and 31: Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 48 and 49: project will be 56.51 MW, which wil
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65:
vii) All the solvent storage tanks
Page 66 and 67:
v) Total fresh water requirement fr
Page 68 and 69:
5. Cathodic protection shall be pro
Page 70 and 71:
SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

Create successful ePaper yourself

Delete template?

Save as template?