MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

By-products1 HCl 0 16.95 16.952 Ammonium Carbonate Solution(25-28%) from CPC Blue0 148.5 148.5Additionally, PAs informed the Committee that ambient air quality monitoring wascarried out at 6 locations during January, 2011 – May, 2011 and submitted dataindicates PM 10 (53.78-90.28 ug/m 3 ), SO 2 (17.26-35.84 ug/m 3 ), NO x (17.26-23.00 ug/m 3 )and VOC (0.5-1.9 ug/m 3 ). Incremental concentration due to proposed project wasestimated to be PM10 (0.004 ug/m 3 ), SO 2 (0.128 ug/m 3 ) and NOx (0.002 ug/m 3 ).Stack (11m) is provided to existing FO/LDO fired boiler-I & II and Thermopack.Stack (11m) will be provided to proposed FO/NG fired boiler III, Thermopac and hot airdryer. Cyclone followed by bagfilter alongwith stack (11 m) will be provided to pulveriser.Water followed by alkali scrubber will be provided to control HCl less than 10mg/Nm 3 /Cl 2 less than 5 mg/Nm 3 . Water followed by acid scrubber will be provided tocontrol NH 3 less than 175 mg/Nm 3 . Solvent (Xylene/Butanol) will be recovered andrecycled in the process. Total water requirement from GIDC water supply will beincreased from 83.0 m 3 /day to 222.82 m 3 /day after expansion. Effluent generation will beincreased from 70.0 m 3 /day to 208.42 m 3 /day after expansion. Domestic effluent will bedisposed off through septic tank/soak pit. In the existing unit process effluent is treated inETP comprising primary and secondary. Treated effluent is further sent to CETP fortreatment. In the proposed expansion, effluent will be treated in ETP comprising primary,secondary and tertiary treatment and treated effluent will be discharged into CETP forfurther treatment. Final treated effluent from CETP is disposed off into the Arabian sea.ETP Sludge will be Sent to TSDF, Vapi. Used Oil will be Sent to authorized recycler/reprocessor.DiscardedContainers will be sold to authorized recycler.Green belt will be developed in 1100 m 2 out of total plant area. Powerrequirement will be increased from 250 HP to 350 HP. LDO/FO will be consumed 450Kg/day as a fuel. Natural gas will be consumed around 3600 SCM/day. DG set (63KVA) will be installed.After detailed deliberations, the Committee found the final EIA/EMP reportadequate and suggested to stipulate following specific conditions alongwith otherenvironmental conditions while considering for accord of environmental clearance:i) Adequate stack height should be provided to oil/gas fired boiler/thermopack.ii) The levels of PM 10 , SO 2 , NO X , CO, NH 3 , HCl, Cl 2 and VOC should be monitored inambient air.iii) Adequate scrubbing system shall be provided to process vents to control HCl, Cl 2and SO 2 . The scrubbing media should be sent to effluent treatment plant (ETP) fortreatment. Cyclone followed by bag filter shall be provided to pulveriser.Efficiency ofscrubber should be monitored regularly and maintained properly. At no time, theemission levels should go beyond the prescribed standards.iv) Fugitive emissions in the work zone environment, product, raw materials storagearea etc. should be regularly monitored. The emissions should conform to the limitsimposed by GPCB.
v) Total fresh water requirement from GIDC water supply should not exceed 208.42m 3 /day and prior permission should be obtained from the concerned Authority. Noground water should be used.vi) Total effluent generation should not exceed 208 m 3 /day. Effluent should be shouldbe treated in ETP. Treated effluent should be discharged to CETP after conformingto the standards prescribed for norms for the effluent discharge and obtainingpermission from the GPCB regarding. No process effluent shall be discharged inand around the project site. Efforts shall be made to treat ammonical nitrogen in theeffluent.vii) Treated effluent should be passed through guard pond. Online pH meter, flow meterand TOC analyzer should be installed.viii) All the solvent storage tanks should be connected with vent condensers with chilledbrine circulation.ix) The company should obtain Authorization for collection, storage and disposal ofhazardous waste under the Hazardous Waste (Management, Handling and Trans-Boundary Movement) Rules, 2008 and amended as on date for management ofHazardous wastes and prior permission from GPCB should be obtained for disposalof solid / hazardous waste in the TSDF. Measures should be taken for fire-fightingfacilities in case of emergency.x) Green belt should be developed in in 1100 m 2 out of total plant area.xi) All the recommendations made in the risk assessment report should be satisfactorilyimplemented.xii) Occupational health surveillance of the workers should be done on a regular basisand records maintained as per the Factories Act.2.2.12. Proposed Bulk drugs unit at plot no. 632, 633, Village Varsola, Mahemdabad -Nadiad Highway, Taluk Mahemdabad, District Kheda, Gujarat by M/s SwanaPharmaceuticals Pvt. Ltd. (TOR to EC).The Committee noted that EIA/EMP report has been prepared by M/s AksharConsultants, Gujarat, who is a non-accredited consultant as on date and M/s Eco ChemSales & Services came for presentation. Therefore, Committee advised that EIA/EMPreport shall be validated first by the QCI/NABET accredited consultant and submitted tothe Ministry for consideration of environmental clearance.The proposal was deferred till EIA/EMP report validated by the QCI/NABETaccredited consultant is submitted.2.2.13. Membrane Cell based Caustic Soda (400 TPD) and Membrane Cell BasedCaustic Potash Plant (100 TPD) at Sy. No. 1-4, 7-8 &11, VillageBalabhadrapauram, Mandal Bikkavolu, District East Godavari, Andhra Pradesh
Page 1: MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5: 5. Regular monitoring of influent a
Page 6 and 7: The revised draft EIA/EMP report sh
Page 8 and 9: vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11: 4. Secondary fugitive emissions fro
Page 12 and 13: µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15: permission for drawl of 16 MGD of w
Page 16 and 17: Ministry’s Regional Office at Ban
Page 18 and 19: iv.Secondary fugitive emissions sha
Page 20 and 21: EIA/EMP. Leather/skin/hide processi
Page 24 and 25: y M/s K. P. R. Industries (India) L
Page 26 and 27: chlorine storage area shall be prov
Page 28 and 29: ii.Bag filter alongwith stack of ad
Page 30 and 31: Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 48 and 49: project will be 56.51 MW, which wil
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 66 and 67: v) Total fresh water requirement fr
Page 68 and 69: 5. Cathodic protection shall be pro
Page 70 and 71: SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

Create successful ePaper yourself

Delete template?

Save as template?