MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

iv.Secondary fugitive emissions shall be controlled and shall be within theprescribed limits and regularly monitored. Guidelines / Code of Practice issuedby the CPCB in this regard should be followed.v. As and Hg shall be monitored in emissions, ambient air and water.vi.vii.viii.ix.The coal yard shall be lined and covered.Efforts shall be made to reduce impact of the transport of the raw materials andend products on the surrounding environment including agricultural land. All theraw materials including fly ash should be transported in the closed containersonly and shall not be overloaded. The company shall have separate truck parkingarea. Vehicular emissions should be regularly monitored.Total fresh water requirement for cement and captive power plant shall notexceed 3,500 m 3 /day. Efforts shall be made to further reduce waterconsumption by using air cooled condensers. All the treated wastewater shall berecycled and reused in the process and/or for dust suppression and green beltdevelopment and other plant related activities etc. No process wastewater shallbe discharged outside the factory premises and ‘zero’ discharge should beadopted.Efforts shall be made to make use of rain water harvested. If needed, capacity ofthe reservoir should be enhanced to meet the maximum water requirement. Onlybalance water requirement shall be met from other sources.x. Regular monitoring of influent and effluent surface, sub-surface and ground watershould be ensured and treated wastewater should meet the norms prescribed bythe State Pollution Control Board or described under the Environment(Protection) Act, 1986 whichever are more stringent. Leachate study for theeffluent generated and analysis should also be regularly carried out and reportsubmitted to the Ministry’s Regional Office at Bangalore, SPCB and CPCB.xi.xii.xiii.xiv.xv.All the bag filter dust, raw mill dust, coal dust, clinker dust and cement dust frompollution control devices should be recycled and reused in the process and usedfor cement manufacturing. Spent oil and batteries shall be sold to authorizedrecyclers / reprocessors only.All the fly ash shall be utilized as per Fly ash Notification, 1999 subsequentlyamended in 2003 and 2008. Efforts should be made to use fly ash maximum inmaking Pozollona Portland Cement (PPC).Efforts shall be made to use low-grade lime, more fly ash and solid waste in thecement manufacturing.An effort shall be made to use of high calorific hazardous waste in the cementkiln and necessary provision should be made accordingly.As proposed, green belt shall be developed in at least 33 % area in and aroundthe cement plant as per the CPCB guidelines to mitigate the effects of airemissions in consultation with local DFO.
xvi.xvii.xviii.All the recommendations made in the Charter on Corporate Responsibility forEnvironment Protection (CREP) for the Cement plants should be implemented.All the commitments made to the public during the Public Hearing / PublicConsultation meeting held on 18 th July,2012 shall be satisfactorily implementedand a separate budget for implementing the same shall be allocated andinformation submitted to the Ministry’s Regional Office at Bangalore.At least 5 % of the total cost of the project shall be earmarked towards theEnterprise Social Commitment based on Public Hearing Issues and item-wisedetails along with time bound action plan shall be prepared and submitted to theMinistry’s Regional Office at Bangalore. Implementation of such program shall beensured accordingly in a time bound manner.2.2.8. Proposed Phase -IV Expansion of Coal beneficiation Plant, Iron orebeneficiation plant, Iron ore pelletisation plant at Village Chadri Hariharpur,Tehsil Panposh, block Kuarmunda, District Sundargarh in Orissa by M/sAdhunik Metaliks Limited. - regarding EC.The Committee noted that EIA/EMP report has been prepared by M/sEnvironmental Research and Services (India) Pvt. Ltd., Bhubaneswar, who is a nonaccreditedconsultant as on date and also listed in list ‘C’ ‘application not approved/withdrawn/ineligible applications’ as the Ministry’s O.M dated 30 th September, 2011.Therefore, Committee advised that EIA/EMP report shall be validated by theQCI/NABET accredited consultant and submitted to the Ministry for consideration ofenvironmental clearance.The proposal was deferred till EIA/EMP report validated by the QCI/NABETaccredited consultants submitted.2.2.9. Expansion of Bulk Drug Unit (2551.5 MTPA to 3322.0 MTPA) at Sejavta,Ratlam, M.P. by M/s Ipca Laboratories Ltd. (TOR to EC)The Committee noted that the Ministry vide letter no.J-11011/850/2007-IA(II)dated 12 th May, 2008 has accorded environmental clearance for the existing unit. As percircular dated 30 th May, 2012 issued by MoEF, a certified report by RO, MoEF on statusof compliance of conditions on existing unit to be provided in EIA/EMP report. However,a certified report by RO, MoEF on status of compliance of conditions on existing unit isnot yet received. Therefore, the proposal was deferred till certified compliance report byRO, MoEF is submitted.2.2.10. Leather Finishing Unit at 524 D & E, HSIDC Industrial Estate, Barhi, Phase- IIby M/s Supreme Fashions. - regarding EC.The project authorities and their consultant, M/s Mantec Consultants Pvt. Ltd.,New Delhi gave a detailed presentation on the salient features of the project andproposed environmental protection measures to be undertaken as per Terms ofReference (TORs) awarded during the 26 th Meeting of the Expert Appraisal Committee(Industry-1) held during 22.7.2011– 23.7.2011 for preparation of
Page 1: MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5: 5. Regular monitoring of influent a
Page 6 and 7: The revised draft EIA/EMP report sh
Page 8 and 9: vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11: 4. Secondary fugitive emissions fro
Page 12 and 13: µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15: permission for drawl of 16 MGD of w
Page 16 and 17: Ministry’s Regional Office at Ban
Page 20 and 21: EIA/EMP. Leather/skin/hide processi
Page 22 and 23: By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25: y M/s K. P. R. Industries (India) L
Page 26 and 27: chlorine storage area shall be prov
Page 28 and 29: ii.Bag filter alongwith stack of ad
Page 30 and 31: Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 48 and 49: project will be 56.51 MW, which wil
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 66 and 67: v) Total fresh water requirement fr
Page 68 and 69:
5. Cathodic protection shall be pro
Page 70 and 71:
SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?